MATERIAL SAFETY DATA SHEET
Complies with OSHA hazard communication standard 29 CFR 1910.1200
HMIS Rating
Scot Laboratories Phone: (440) 543-3033 Health- 2
16841 Park Circle Drive Fax: (440) 543-1825 Fire- 0
Chagrin Falls, OH 44023 Date: July 25, 2000 Reactivity-1
0= minimal, 1= slight, 2= moderate, 3= serious, 4= severe
SECTION I - Product Identification
Product Name: SOFT SCOUR Product Code: D 22
SECTION II - Hazardous Ingredients/Identity Information -
Hazardous Components CAS # OSHA Exposure Limit(8 hr TWA[ppm])
Hydroxyacetic Acid 79-14-1 None est.
3 3
Phosphoric Acid 1mg/m ACGIH TLV - 1mg/m
SECTION III - Physical/Chemical Characteristics
Physical State: Cream Vapor Density (AIR = 1): Unknown
Color: Opaque white Vapor Pressure (mm Hg): Unknown
Odor: Mint Solubility in Water: 90% comp.; 10% insol.
Boiling Point: 212F Specific Gravity (H2O): 1.136
Melting Point: 32F Evaporation Rate: < 1 (Butyl Acetate = 1)
SECTION IV - Fire and Explosion Hazard Data
Flash Point: None
Flammability Limits in Air: None
Special Fire Fighting Procedures: Water, foam, or carbon dioxide
Unusual Fire or Explosion Hazards: Avoid contact with chlorine products or chlorine gas may form
SECTION V - Reactivity Data
Stability: Stable
Material to Avoid Contact: Keep away from bleach, cyanides, sulfides, ammonia, strong bases
Conditions to Avoid: Keep away from heat
Hazardous Decomposition Products: Sulfuric acid, sulfur dioxide
SECTION VI - Health Hazard Data
Product Hazard Classification: Corrosive
Carcinogenic ingredients: None
Effects of overexposure: Irritation and chemical burns
First Aid Procedures:
INGESTION: Do not induce vomiting, drink plenty of water, contact a physician immediately.
SKIN/EYE CONTACT: - Flush with water for 15 minutes. If irritation persists, consult a physician.
Medical Conditions aggravated by exposure: Open cuts
SECTION VII - Precautions for Safe Handling and Use
In case of Release or Spill: For small spills in amounts encountered in normal cleaning, spill may be discarded with normal cleaning waste
water. Larger spills require consulting with local or state EPA agencies to conform to waste disposal regulations.
Accidental spill precautions: Absorb with clay absorbant
Handling and Storing: Use precautions for handling of acids
SECTION VIII - Control Measures
Protection required in handling of concentrated product
Gloves: Yes
Eye Protection: Yes
Other Protective Clothing: Wear plastic apron if splashing is anticipated
Respirator: Not normally required
Mechanical Ventilation: Not required, unless in confined area
Work/Hygienic Practices: Wash hands after use.
SECTION IX - Special Precautions
Do not store in hot areas
SECTION X - Department of Transportation
Shipping Hazard Classification: corrosive liquid, acidic, organic, n.o.s., (glycolic acid, phosphoric acid mixture) 8, UN3265, III
DISCLAIMER
The information contained herein was obtained from current and reliable sources. However, the data is provided without any warranty,
expressed or implied, regarding its correctness or accuracy. Since the conditions for use, handling, storage and disposal of this product are
beyond Scot Laboratories' control, it is the user's responsibility both to determine safe conditions for use of this product and to assume liability
for loss, injury, damage or expense arising from the product's improper use. No warranty, expressed or implied, regarding the product
described herein shall be created by or inferred from any statement or omission in this MSDS. Various government agencies (e.g., DOT, EPA,
FDA) may have specific regulations concerning the transportation, handling, storage, use or disposal of this product which may not be
reflected in this MSDS. The user should review these regulations to ensure full compliance.
|