MATERIAL SAFETY DATA SHEET
Complies with OSHA hazard communication standard 29 CFR 1910.1200
HMIS Rating
Scot Laboratories Phone: (440) 543-3033 Health- 3
16841 Park Circle Drive Fax: (440) 543-1825 Fire- 0
Chagrin Falls, OH 44023 Date: September 25, 2000 Reactivity-2
0= minimal, 1= slight, 2= moderate, 3= serious, 4= severe
SECTION I - Product Identification
Product Name: HI BOWL TOILET CLEANER Product Code: 428
SECTION II - Hazardous Ingredients/Identity Information - CAS # OSHA PEL Other
Muriatic Acid 7647-01-0 5 ppm Unknown
SECTION III - Physical/Chemical Characteristics
Physical State: Liquid Vapor Density (AIR = 1): 1.2
Color: Milky white Vapor Pressure (mm Hg): 28
Odor: Acid Solubility in Water: Completely miscible
230o F
Boiling Point: Specific Gravity (H2 O): 1.16
32o F
Melting Point: Evaporation Rate: 1 (Butyl Acetate = 1)
SECTION IV - Fire and Explosion Hazard Data
Flash Point: None Fire Fighting Procedure: Avoid skin and eye contact.
Flammability Limits in Air: None Extinguishing Media: Non-combustible
Unusual Fire or Explosion Hazards: Thermal decomposition will cause acidic vapors.
SECTION V - Reactivity Data
Stability: Stable
Material to Avoid: Do not mix with other materials. Follow directions on label. Avoid strong bases, bleach.
Conditions to Avoid: Heated surfaces.
Hazardous Decomposition or Byproducts: (Hazardous Polymerization will not occur) Thermal decomposition will cause acidic vapors.
SECTION VI - Health Hazard Data
Product hazard classification: Corrosive
Carcinogenic ingredients: NONE
Effects of overexposure: Can cause eye and skin damage. May be harmful to respiratory system. May cause chemical burns. May cause
nausea or skin irritation.
Medical Conditions aggravated by use: Open cuts, respiratory problems.
First Aid Procedures:
INGESTION - Do not induce vomiting. Drink plenty of water. Contact physician immediately.
SKIN AND EYE CONTACT - Flush with water for 15 min. Consult a physician if redness or irritation persists
SECTION VII - Precautions for Safe Handling and Use
In case of Release or Spill: Neutralize spill with lime or bicarbonate of soda.
Waste Disposal Method: Small amounts - down drain or sanitary landfill. Large amounts - Neutralize and obey local ordinances.
Handling and Storing:Keep out of reach of children. Industrial use only. Keep away from heat. Use with adequate ventilation.
Other Precautions: Use protective equipment to prevent eye or skin contact.
SECTION VIII - Control Mea sures
Gloves: Rubber Respirator: None normally needed.
Eye Protection: Face shield Ventilation: Local exhaust is normally adequate.
Other Protection: Chemical Apron Other Precautions: Follow good manufacturing/housekeeping rules.
SECTION IX - Specia l Precautions - NONE
SECTION X - Department of Transportation
Shipping Hazard Classification: corrosive liquid, acidic, inorganic, n.o.s., (hydrochloric acid mixture), 8, UN3264, III
DISCLAIMER
The information contained herein was obtained from current and reliable sources. However, the data is provided without any warranty, expressed
or implied, regarding its correctness or accuracy. Since the conditions for use, handling, storage and disposal of this product are beyond Scot
Laboratories' control, it is the user's responsibility both to determine safe conditions for use of this product and to assume liability for loss, injury,
damage or expense arising from the product's improper use. No warranty, expressed or implied, regarding the product described herein shall be
created by or inferred from any statement or omission in this MSDS. Various government agencies (e.g., DOT, EPA, FDA) may have specific
regulations concerning the transportation, handling, storage, use or disposal of this product which may not be reflected in this MSDS. The user
should review these regulations to ensure full compliance.
|