Oate:tUl7195Time: {Xl:02:51 Page I ol 9
From: To: 9ttr1612-65i1-5tz
MATERIAL SAFETY DATA SHEET
19-10
19 00
TEI,EPHONE O .
MANUFACTURER'S NAME EMERGENCY N
DUTCH BOY {276) 566-29L7
P.O. Box 6709
Cleveland, OH 44101
DATN OF PREPARATION INFORMATION TELEPHONE NO.
1?-APR-95 {21_6} 566-2902
I --
Section PRODUCTIDENTTF]CATION
PRODUCTNUMBER HM]S CODES
Health L
19-10 0
Flammability
0
Reactivity
PRODUCT NA}48
DIRT EIGHTER* Exterior Latex G l o s s F i n i s h , W h i t e
PRODUCTCIASS
Latex Paint
===:=:::::::::=:== :::::::= ==:=:==:::=:===:====:====:==:=:::::=
-- HAZARDOUS
S e c t i o n II INGREDIENTS
INGREDTENT ACGTH OSHA
CAS No, *byWT TLV PEL UNITS \TD
2- ( 2-Butoxyethoxy) -ethanol 1 Not Established 0.06
1 1 " 2 - 3 45
-
Cristobalite 0.05 M G / M 3a s R e s p . D u s t
<1 0.05
L4464-46-L
10 1 0 t b ) M G / M 3a s D u s t * * *
Diox:.oe.
lcanium l.-t
- ***
13463-67-1 Dust {Resprrable Fraction)
fsl6l
1 0 ( 5 ) M G / M 3a s l s s l * * *
zta
Zinc Oxi-de
**rr Totaf Dust (Respirable Fraction)
L3L4-L3-2
pH - 9.5
--
Section IIl PHYSICAL DATA
I']EIGHT -- 10.O? Lb.lga]-. RATE ,-
PR,ODUCT EVAPORATTON Slouer than Ether
SPECTFIC GRAVITY -- VAPOR DENSITY .-
L.zL Heavier than Air
BOTLING POINT -_ 2L2_448 E MEITING POrNT -- N.A.
-- SOLUBITTTY IN I{ATER --
VOI,ATTLE VOLUME 6'7 ? N.A.
(Theoretical)
VOC 132 gm.
1,10 lb.
-*_:
]V .-
Section FIRE AT{D EXPLOSION HAZARD DATA
FIASH POINT LE], UEL
N.A. 0.9 J-2.5
FIAMMABILITY CIASST Ff CATION
Not Applicable
EXTINGUISHING MEDIA
Carbon Dioxide, Dry Chemical, Alcohol Foam
UNUSUAI FIRE AND EXPLOSION HAZARDS
CLosed containers may explode (due to the build-up of pressure) when
Lxposed to extreme heat.
U
on page 2
Continued
Dale: {{17195 Time: 09:02:51 Page e ol I
From: To: ttWl612-6*5122
paqe
L9-10 2
SPECIA], FIRE FIGHT]NG PROCEDURES
Fu11 protective equipment including breathing
self-contained apparatus
should be used. Water spray may be ineffective. If water is used, fog
nozzles are preferabLe. Water may be used to cool closed containers to
pressure build-up and possible autoignition or explosion when
-prevent
(}
::=:=::::=::=:====::=::===::==::=::=::=:==:=::=:=======::==::=:==::=::=:=:==
Secti-on V -- HEALTH HAZARD DATA
ROUTESOF EXPOSURE
Exposure may be by INHALATION and/or SKIN or EYE contact. depending on
conditions o f u s e . T o minj,mize exposure, for proper
fo1low reccmmendations
use,, ventilation, a n d personal prolective equipment.
ACUTE Health Hazards
EFFECTS OF OVEREXPOSURE
Irritation o f e y e s , s k i n a n d u p p e r respiratory system. fn a confined
may c a u s e h e a d a c h e , n a u s e a q r d i z z i n e s s ,
area vapors in high concentration
SIGNS AND SYMPTOMS OF OVEREXPOSURE
Redness and itching or burning sensation may indicate eye or excessive
skin exposure.
MEDICAL CONDITIONS AGGRAVATEDBY EXPOSURE
None generally recognized,
EMERGENCY AND FIRST AID PROCEDURES
If INIIALED: ff affected, remove from exposure. Restore breathing.
Keep warm and quiet.
If on SKfN: Wash affected area thoroughly vrrith soap and water.
Remove contaminated clothing and launder before re-use.
ff in EYES: Flush eyes with large amounts of water for 15 minutes.
Get medical attention.
If SWALIOWED: Get medical attention.
RONIC Health Hazards
SiLica (Quartz, Cristobatite)
Crystalline is listed by fARC and NTP.
Long term exposure to high levels of silica dust. which can occur only when
sanding or abrading the dry filmr may cause l u n E d a m a g e ( s i l i c o s i s ) and
possibiy cancer.
Rats exposed to titanium dioxide dust at 250 mg.,/m3 developed lung
cancerr however, such exposure levels are not attainable in the workplace,
--
Section VI REACTMTY DATA
STABILITY -. Stab].e
CONDTTTONS AVOTD
TO
None knor*n.
INCOMPATTBILITY
None known.
HAZARDOUS DECOMPOSITION PRODUCTS
Ey fire: Carbon Dioxide, Carbon Monoxide
HAZARDOUS POIYMERTZATION
Will- not occur
--
Section VII SPILL O R I , E A K PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAI IS REIEASED OR SPII,LED
Remove all sources o f i g n i t i o n . Ventilate a n d remove with inert
absorbenl.
Continued on page 3
Dale:tU17J95
From: To:SW16l2-65+512 Time:09:02:51 Page 3 of 9
page 3
Lv-ru
WASTE DfSPOSA], METHOD
Waste from this product is not hazardous as defined under the Resource
Conservation and Recovery Act TRCRA) 40 CfR 261-.
Incinerate in approved facility. closed container.
Do not incinerate
of in accordance wi.th Federal, State, and Local regulations
-pispose
poi.r-ution.
leoarorng
-- PROTECTIONINFORMATION
Section VIII
PRECAUTIONS TO BE TAKAN IN USE
Use onJ-y t+i-th adeguate ventilation. Avoid breathing vapor and spray
Avoid contact with skin and eyes.
rnist. Wash hands after using.
This coating may contain materials as nuisance particulates
classified
(listed "as Dust" in Section II) which may be present at hazardous l-evels
only during sanding or abrading of the dried film. If no specific dusts
are listed in Section II, the applicable limits for nuisance dusts are
ACGIH TLV 10 mg./m3 (total dust), OSHAPEL 15 mg./rn3 (total dust), 5 mg.lm3
fraction)
{respirable
VENTILATION
Local- exhaust preferable. General exhaust acceptable if the exposure to
materials in Section II is maintained below applicable exposure limits.
R e f e r t o O S H AS t a n d a r d s 1 9 1 0 . 9 4 , L 9 1 A . L O 7 t 1 9 1 0 . 1 0 8 .
RESPIRATORYPROTECTION
If personal exposure cannot be controlLed below applicable limits by
ventilation, wear a properly fitted organic vaporlparticulate respirator
approved by NIOSHIMSHA for protection against materiaLs in Section ff.
When sanding or abrading the dried fiIm, wear a dust/mist respirator
approved by NIOSH/ttlsife for dust which may be generated from this product,
underlying paint, or the abrasive.
PROTECTTVE GIOVES
Wear gloves which are recomnended by glove supplier for protection
1|
materials in Section f f .
Gainst
EYE PROTECTION
Wear safety spectacles with unperforated sideshields.
IX --
Section PRECAUTfONS
DOL STORAGE CATEGORY
3B
PRECAUTIONS TO BE TAKEN TN HANDLTNGAND STORTNG
Keep container closed when not in use. only to approved
Transfer
containers with complete and appropriate Do not take internally.
1abeling.
Keep out of the reach of chiLdren.
X --
Section OTHER REGULATORY
TNFORMATTON
SARA 313 (40 CFR 372,65C) SUPPLIER NOTIFTCATION
CAS No. CHEI,IICAT/COMPOUND tbyWT t El-ement
112-34-5 2- (2-Butoxyethoxy) -ethanol
Zrnc.
Glyco1 Ethers I
CALIFORNIA PROPOSITION 65
This product contains chemical (s) known to the State of California to
cancer.
luse
-
on page 4
Continued
From: To: 9v\r1612-65+5122 Dale:1/'17195
Time:{Xl:02:51 Page I of 9
19- 10 page 4
The above information pertains to this product as currentty formulated,
and is based on the information avai-LabLe at this time. Addilion of
reducers or other additives to this product may substantially alter the
composition and hazards of the product. Since conditions of use are
outside our control, we make no warranties, express or implied, and assume
no riability in connection with any use of this information.
|