MATERIAL SAFETY DATA SHEET: COMPLIES WITH USDL SAFETY AND HEALTH REGULATIONS
MSDS NO. AS825 DATE: 5/24/2005 PAGE 1 of 2
ABATEMENT TECHNOLOGIES, INC. PHONE: (678) 889-4200
605 SATELLITE BLVD., SUITE 300 FAX: (678) 889-4201
SUWANEE, GA 30024
24 HOUR TRANSPORATION EMERGENCY NO.:CHEM-TREC (800)424-9300/(703)527-3887 (INTL)
SECTION #1: PRODUCT IDENTIFICATION
Product Name: LEMON CITRUS II, AS825
Description: MASTIC REMOVER Rating Scale
Appearance and Odor: CLEAR LIQUID, WITH MILD ODOR 0 = Minimal
Use: REMOVING MASTIC 1 = Slight
2 = Moderate
Hazard Rating (NFPA): Health = 1 Reactivity = 0 3 = Serious
Fire = 2 Special = NONE 4 = Severe
Hazard Rating (HMIS): Health = 1 Flammability = 2 Reactivity = 0
SECTION #2: HAZARDOUS INGREDIENT INFORMATION
COMMON CHEMICAL NAME CAS # ACGIH / TLV OSHA / PEL
HYDROCARBON MIXTURE 64742-88-7 NE NE
P-MENTHA-1,8-DIENE 5989-27-5 NE NE
DIPROPYLENE GLYCOL 34590-94-85 110 PPM 150 PPM
MONOMETHYL ETHER
(RECOMMENDED PEL IS 525MG / M3 FOR 8-HOUR TWA EXPOSURE LIMITS FOR PETROLEUM
DISTILLATE 鈥? STODDARD SOLVENT.)
NE = NONE ESTABILSHED AT THIS TIME.
SECTION #3: PHYSICAL DATA
Boiling Range: >300F
Vapor Pressure (MM HG): <2
Vapor Density (Air=1): >1
Solubility in Water: EMULSIFIES
Appearance and Odor: CLEAR LIQUID, WITH MILD ODOR
Specific Gravity (WATER=1): .8077
Evaporation Rate (BUTYLACETATE=1): <1
Percent Volatile: 93-99
SECTION #4: FIRE/EXPLOSION INFORMATION
Flash Point: 142-150F(C.C.)
Flammable Limits: N/D
Extinguishing Media: CO2; WATER FOG; DRY CHEMICAL; CHEMICAL FOAM
Fire Fighting Procedures: WEAR SELF CONTAINED BREATHING APPARATUS WITH A FULL
FACEPIECE AND TOTAL PROTECTIVE CLOTHING.
Unusual Fire and Explosion Hazards: VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL
ALONG THE GROUND OR BE MOVED BY VENTILATION AND IGNITED BY HEAT, PILOT LIGHTS,
FLAMES AND OTHER IGNITION SOURCES.
SECTION #5: REACTIVITY DATA
Stability: STABLE
Materials to Avoid: STRONG ACIDS/STRONG OXIDIZERS
Hazardous Decomposition: THERMAL DECOMPOSITION MAY YIELD CO; CO2; AND VARIOUS
HYDROCARBONS
Hazardous Polymerization: WILL NOT OCCUR
SECTION #6: HUMAN HEALTH HAZARD INFORMATION
SIGNS AND SYMPTOMS OF EXPOSURE:
Inhalation: PROLONGED EXPOSURE MAY RESULT IN IRRITATION OF RESPIRATORY TRACT.
Skin: PROLONGED EXPOSURE MAY CAUSE MILD SKIN IRRITATION. SYMPTOMS MAY INCLUDE
REDNESS, DRYING AND CRACKING.
Eyes: EXPOSURE MAY CAUSE IRRITATION. SYMPTOMS MAY INCLUDE STINGING, TEARING, AND
REDNESS.
Ingestion: MAY CAUSE DIARRHEA, GASTRIC PAIN, AND VOMITTING. MATERIAL CAN ENTER
THE LUNGS DURING SWALLOWING OR VOMITING AND CAUSE LUNG INFLAMMATION AND/OR DAMAGE.
Health Hazards (Acute and Chronic): HEADACHE, DIZZINESS, AND NAUSEA.
Carcinogenicity: NTP: NO IARC Monographs: NO OSHA Regulated: NO
Medical Conditions Generally Aggravated by Exposure: NONE KNOWN
EMERGENCY FIRST AID PROCEDURES:
Inhalation: MOVE INDIVIDUAL AWAY FROM EXPOSURE AND INTO FRESH AIR. PROVIDE
OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED. SEEK MEDICAL ATTENTION.
Ingestion: DO NOT INDUCE VOMITING. THIS MATERIAL IS AN ASPIRATION HAZARD. IF
SPONTANEOUS VOMITING OCCURS, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID
INTO THE LUNGS. SEEK MEDICAL ATTENTION.
Eye Contact: FLUSH EYES WITH WATER HOLDING EYELIDS APART FOR 15 MINUTES. IF
IRRITATION PERSISTS SEEK MEDICAL ATTENTION.
Skin Contact: REMOVE CONTAMINATED CLOTHING. FLUSH AREA WITH WATER FOR 15
MINUTES. IF IRRITATION PERSISTS SEEK MEDICAL ATTENTION.
SECTION #7: PRECAUTIONS FOR DISPOSAL, SAFE HANDLING, AND USE
Small Spills: ABSORB WITH VERMICULITE OR OTHER ABSORBENT.
Large Spills: ELIMINATE ALL IGNITION SOURCES. STOP SPILL AT SOURCE. PREVENT FROM
ENTERING DRAINS, SEWERS, AND STREAMS. PUMP INTO APPROVED CONTAINERS, ABSORB
UNRECOVERABLE PRODUCT AND DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS.
Non-Reclaimable Spills: FOLLOW STATE AND LOCAL REGULATIONS FOR DISPOSAL OF
LARGE NON-RECLAIMABLE SPILLS.
Waste Disposal Method: DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS.
Precautions To Be Taken In Handling and Storage: KEEP CONTAINER CLOSED WHEN NOT IN
USE. PROTECT CONTAINERS FROM ABUSE AND EXTREME TEMPERATURES.
Other Precautions: EMPTIED CONTAINERS CONTAIN PRODUCT RESIDUES AND ALL PRECAUTIONS
WITHIN THIS MSDS STILL APPLY AND SHOULD BE FOLLOWED.
SECTION #8: CONTROL MEASURES
Respiratory Protection: IF WORKPLACE EXPOSURE LIMITS OF PRODUCT OR ANY COMPONENT IS
EXCEEDED, A NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE OF
PROPER ENVIRONMENTAL CONTROL. OSHA REGULATIONS ALSO PERMIT OTHER NIOSH/MSHA
RESPIRATORS (NEGATIVE PRESSURE TYPE) UNDER SPECIFIED CONDITIONS.
Ventilation: MECHANICAL VENTILATION TO MAINTAIN EXPOSURE BELOW TLV'S.
Skin Protection: NEOPRENE OR RUBBER PROTECTIVE GLOVES.
Eye Protection: CHEMICAL GOGGLES WITH SIDE SHIELDS.
Work/Hygienic Practices: EXHIBIT NORMAL SAFE WORKPLACE HABITS.
SECTION 9: TRANSPORTATION
DOT Shipping Name: COMBUSTIBLE LIQUID, (CONTAINS HYDROCARBON MIXTURE)
Placarding: PLACARDING EXEMPTION 173.150 (F)
Hazard Class: 3
Identification No.: NA1993
Packing Group: III
RQ (Reportable Quantity): NA
SECTION 10: REGULATORY INFORMATION
SARA Title III: 313: N/A
CERCLA RQ: N/A
Special Precautions/Other Comments: THE INFORMATION CONTAINED HEREIN IS BELIEVED
TO BE ACCURATE BUT IS NOT WARRANTED TO BE SO. USERS ARE ADVISED TO CONFIRM IN
ADVANCE OF NEED THAT INFORMATION IS CURRENT, APPLICABLE AND SUITED TO THE
CIRCUMSTANCES OF USE. VENDOR ASSUMES NO RESPONSIBILITY FOR INJURY TO VENDEE OR
THIRD PERSONS PROXIMATELY CAUSED BY THE MATERIAL IF REASONABLE SAFETY PROCEDURES
ARE NOT ADHERED TO AS STIPULATED IN THE DATA SHEET. FURTHERMORE, VENDOR ASSUMES NO
RESPONSIBILITY FOR INJURY CAUSED BY ABNORMAL USE OF THIS MATERIAL EVEN IF
REASONABLE SAFETY PROCEDURES ARE FOLLOWED.
MSDS NO. AS825 DATE: 5/24/2005 PAGE 2 of 2
|