EC-Safety Data Sheet
Material Safety Data Sheet
AEP-200 /AEP-200G
Section 1: Product and Company Identification
Product name: AEP-200 and AEP-200G
Material Use: Bio-Solvent
Manufacturer/Suppler:
Chimista, LLC Chimista Europe
P.O. Box 1240 7 rue Marie-Th茅r猫se
Jasper, GA 30143 USA 3257 Bettembourg LUXEMBOURG
Technical Tel: 678-452-2085 Technical Tel: +352 26 20 01 64聽
Emergency Telephone Numbers: +352 26 20 01 64 (In Europe)
678-452-2085 (During business hours)
770-608-4006 (After business hours)
Section 2: Composition / Information on ingredients
Diester鈥檚 CAS# 627-93-0; 1119-40-0; and 60-70%
106-65-0
Lactones CAS# 97-64-3 Xi, R36, R37 30-40%
Section 3: Hazardous Identification
Most important hazards
Irritating to eyes.
Irritating to respiratory system
Potential health effects:
Eyes: Irritating to eyes
Skin: May dry and defat the skin
Ingestion: Ingestion in large amounts may cause gastrointestinal disturbances.
Inhalation: Irritating to respiratory system.
Section 4: First Aid Measures
Eyes: Irrigate eyes with plenty of running water for at least 15 minutes. If necessary, see a
medical doctor.
Skin: Wash area with soap and water. If irritation persists get medical attention. Wash clothes
before reuse.
AEP-200 Page 1 of 4
EC-Safety Data Sheet
Inhalation: Remove to fresh air. If symptoms continue seek medical attention.
Ingestion: DO NOT induce vomiting and seek medical attention immediately.
Section 5: Fire Fighting Measures
Flammable Properties: Non Flammable
Degree of Fire and Explosion Hazard: Moderate. Rags soaked with any solvent can
present a fire hazard and should be stored in appropriate covered container. Improperly
stored rags, under certain conditions can lead to spontaneous combustion. Not an explosion
hazard.
Flash Point: 70掳C / 158掳F
Extinguishing Media: Foam, dry chemical, and CO2. Water spray (only by trained personnel)
Fire Fighting Instructions: Keep personnel upwind of fire. Wear self contained breathing
apparatus. Wear full protective equipment. Cool tank / container with water spray. Fight fire
from a distance, heat may rupture containers.
Section 6: Accidental Release Measures
Safeguards (Personnel)
Note: Review sections 5, 7 and 8 prior to proceeding with clean-up. Use appropriate
protective equipment for personnel during clean-up operations.
Spill Clean-Up: soak up with sand, oil dry, or other absorbent non-combustible material.
Contaminated surfaces may become slippery, clean contaminated areas with soap and water.
Prevent product from entering drains.
Section 7: Handling and Storage
Handling (Personnel): Avoid contact with eyes and skin. Avoid breathing vapors. Use with
adequate ventilation.
Storage: Store away from heat and ignition sources in a cool dry area. Keep containers
tightly closed. 鈥淓mpty鈥? containers may contain flammable vapors, which may ignite or
explode.
Section 8: Exposure Controls / Personal Protection
Engineering Controls: Ensure adequate ventilation, especially in confined areas.
Personal Protective Equipment:
Respiratory Protection: in case of insufficient ventilation wear suitable respiratory
equipment. Breathing apparatus with filter (DIN 141 or Filter A)
Hand Protection: Solvent-resistant gloves (PVA / H4)
Eye Protection: Tightly fitting safety goggles
Skin Protection: Apron and protective work clothing
AEP-200 Page 2 of 4
EC-Safety Data Sheet
Section 9: Physical and Chemical Properties
Form: Liquid
Color: Clear to straw
Solubility in Water: Mostly soluble
Odor Threshold: 0.18(ppm)
Flash Point: 70掳C / >158掳F
Boiling Point: 151掳C-225掳C / 309掳F-437掳F
Specific Gravity: 1.08 - 1.09 @25掳C
pH: 6.5(10% solution)
Vapor Density: 4.07(air=1)
Evaporation Rate: 0.115(butyl acetate=1)
Vapor Pressure: 0.78(mmHg) @ 20掳C
Section 10: Stability and Reactivity
Chemical Stability: Normally stable
Conditions to Avoid: Intense heat sparks and open flame.
Material to Avoid: Strong oxidizing agents.
Hazardous decomposition products: Carbon oxides
Polymerization: Will not occur.
Section 11: Toxicology Information
Mixture not tested but based on component toxicities: High vapor concentrations may
irritate the eyes and respiratory tract and may cause headaches, dizziness, anesthesia,
drowsiness, unconsciousness and other central nervous system effects.
Components of this product are not listed as a carcinogenic.
Components of this product are listed as non-mutagenic.
Section 12: Ecological Information
Ecotoxicity: None known or expected; degrades to naturally occurring compounds.
Environmental Fate: 100% biodegradable degrades to naturally occurring compounds.
Section 13: Disposal Considerations
Waste Disposal: Dispose of in accordance with all municipal, provincial and federal
regulations.
Hazardous Waste Classification: Non-Hazardous in neat condition.
AEP-200 Page 3 of 4
EC-Safety Data Sheet
Section 14: Transportation Information
ADR: Not regulated
Section 15: Regulatory Information
European Regulatory Information: EU Labeling according Dir 67/548 EEC
EU Risk Phrases: R36: Irritating to eyes
R37: Irritating to respiratory system
S24/25: Avoid contact with skin and eyes
S26: In case of contact with eyes rinse immediately with plenty of water
and seek medical attention.
S39: Wear eye / face protection
EU Symbol(s): Irritant Xi
German Water Hazard Class: WGK 1: Slightly hazardous for water (self assessment
according to German VwVwS 鈥? 17/05/1999)
Swiss Ordinance on incentive taxes on volatile organic compounds: exempt
Section 16: Other Information
The information herein is given in good faith and is believed to be accurate and correct but no warranty, expressed or
implied, is made. Chimista, LLC assumes no responsibility for personal injury or property damage that may arise from
use of this material, since the conditions of handling and use are beyond our control. It is the responsibility of the user
to comply with all Federal, State and local laws and regulations regarding use of this product. Vendees or users
assume all risks associated with the use of this material.
MSDS Prepared By: Chimista, LLC
7 rue Marie-Th茅r猫se
3257 Bettembourg
LUXEMBOURG
Reviewed on 1 Oct 2007
AEP-200 Page 4 of 4
|