MSDS
Product: SR 1147
Rev # 1 Dated 22/4/02
Page 1 of 4
MATERIAL SAFETY DATA SHEET
1. CHEMICAL PRODUCT AND COMPANY INFORMATION
Product Name: SR 1147
2. COMPOSITION / INFORMATION ON INGREDIENTS
Component Name CAS # % Range
ethylene glycol 000107-21-1 < 55%
diethylene glycol 000111-46-6 < 10%
3. HAZARDS IDENTIFICATION
Effects of Overexposure
Eye Contact: can cause irritation and conjunctivitis. Permanent damage may result if not promptly treated.
Skin Contact: can cause irritation, sensitization and dermatitis. Absorption through skin may cause damage to kidneys and
depression of central nervous system.
Inhalation: can irritate the nose, throat and lungs. May cause coughing, shortness of breath, nausea, vomiting, headache, dizziness,
intoxication, nystagmus, and irregular eye movements. Prolonged and repeated overexposure to vapors may cause damage to
kidneys, liver, lungs, blood or central nervous system.
Ingestion: can cause abdominal discomfort or pain, nausea, vomiting, dizziness, drowsiness, malaise, blurring of vision, irritability,
lumbar pain, oliguria, uremia, irregular eye movements, convulsions, coma, cardiac failure, pulmonary edema and kidney damage
which may be fatal.
Medical Conditions Aggravated by Exposure: preexisting skin, eye, respiratory, kidney and liver disorders may be aggravated by
exposure.
Other Information: Components of this product were reacted using ethylene oxide (EtO) .EtO may accumulate in the headspace of
drums and bulk containers. However, the concentration of EtO in the headspace should not cause the OSHA 0.5 ppm action level for
EtO exposure to be exceeded. EtO is listed as a potential carcinogen by OSHA, NTP and IARC. If the product is handled as
recommended in this MSDS, the trace amounts of EtO are not expected to result in acute or chronic hazards. EtO is a substance
known to the State of California to cause cancer and/or reproductive toxicity. EtO is regulated under the Safe Drinking Water and
Toxics Enforcement Act of 1986 (Proposition 65).
4. FIRST AID MEASURES
Emergency and First Aid Procedures
SKIN: Wash with soap and water. Remove contaminated clothing and launder contaminated clothing before reuse. Get medical
attention if redness or irritation develops.
EYES: Flush eyes immediately with large amounts of water for at least 15 minutes. Lift lower and upper lids occasionally. Get
medical attention.
INHALATION: Remove victim to fresh air. Give artificial respiration if not breathing. If breathing is difficult, administer oxygen. Keep
person warm, quiet and get medical attention.
INGESTION: Call a physician immediately. Give victim a glass of water. Do NOT induce vomiting unless instructed by a physician or
poison control center. Never give anything by mouth to an unconscious person.
5. FIRE FIGHTING MEASURES
Flash Point {Test Method) : > 200 Deg. F TCC
Extinguishing Media: This material is non-combustible. If this material is involved in a fire, use an extinguishing agent appropriate to
surrounding materials. Water spray may be used to cool containers of this material exposed to a fire. Fire extinguishing materials
should be collected for determination of proper disposal.
Special Fire Fighting Procedures: Fire fighters should wear self-contained breathing apparatus
with a full face-piece operated in the pressure-demand or positive-pressure mode.
Unusual Fire and Explosion Hazards: None
6. ACCIDENTAL RELEASE MEASURES
Steps to be Taken if Material is Released or Spilled: Persons not wearing suitable personal protective equipment should be
excluded from area of spill until clean-up has been completed. Shut off source of spill if possible to do so without hazard. Prevent
material from entering sewers or watercourses. Provide adequate ventilation. Contain spilled material with sand or earth. Recovered
undamaged or minimally contaminated material for reuse or reclamation. Place all collected material and spill absorbents into DOT
approved containers.
MSDS
Product: SR 1147
Rev # 1 Dated 22/4/02
Page 2 of 4
7. HANDLING AND STORAGE
Precautions to be Taken in Handling and Storing: Avoid contact with eyes, skin or clothing. Avoid breathing vapors or mist.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Respiratory Protection: If workplace exposure limit(s) of product or any component is exceeded, an NIOSH/MSHA approved air
supplied respirator is advised in absence of proper environmental control. OSHA regulations also permit other NIOSH/MSHA
respirators (negative pressure organic vapor type) under specified conditions. Engineering or administrative controls should be
implemented to reduce exposure.
Ventilation: The use of mechanical dilution ventilation is recommended whenever this product is used in confined spaces, is heated
above ambient temperatures or is agitated. When applicable, sufficient local ventilation should be provided to maintain employee
exposures below safe working limits (TWA's).
Protective Gloves: Neoprene, nitrile, polyvinyl alcohol (PVA), polyvinyl chloride (PVC)
Eye Protection: Chemical splash goggles or face shield in compliance with OSHA regulations is advised; however OSHA
regulations also permits safety glasses under certain conditions. The use of contact lenses is not recommended.
Other Protective Equipment: Eye wash and safety shower.
9. PHYSICAL AND CHEMICAL PROPERTIES
These data do not represent technical or sales specification
Appearance : Clear yellow liquid
Sp. Gr. @ 15.6EC: 1.00 鈥? 1.15
KV @ 40 EC: 2.0 鈥? 8.0 cSt
Pour Point: Below -18EC
pH : 6 -11
Abbreviations: N.D. 鈥? Not Determined
N.A. - Not Applicable
10. STABILITY
Stable (Y=Yes/N=No): Yes
Stability - Conditions to Avoid: None known.
Incompatibility (Materials to Avoid): Avoid contact with strong oxidizing agents, strong alkalies, and strong mineral acids.
Hazardous Decomposition Products: Smoke, carbon dioxide, carbon monoxide, oxides of nitrogen.
Hazardous Polymerization May Occur(Y=Yes/N=No) : N
Hazardous Polymerization --Conditions to Avoid: None
11. TOXICOLOGICAL INFORMATION
Toxicological Data: RTECS: ND Carcinogenicity: ND
12. ECOLOGICAL INFORMATION
Mobility: ND Biodegradation: ND
Bioaccumulation: ND Aquatic toxicity: ND Further information: None
13. DISPOSAL CONSIDERATIONS
Waste Disposal Method: Treatment, storage, transportation and disposal must be in accordance with EPA or State regulations
under authority of the Resource Conservation and Recovery Act (40 CFR 260-271).
14. TRANSPORT INFORMATION
Proper shipping name : ND IMDG Code Page : ND
UN-No. : ND Class : ND
Packing : ND EMS No. : ND
MBPT Category : ND
MSDS
Product: SR 1147
Rev # 1 Dated 22/4/02
Page 3 of 4
15. REGULATORY INFORMATION
Superfund Amendments and Reauthorization Act of 1.986 (SARA) Title III
Section 302/304-Extremelv Hazardous Substances (40 CFR 355): SARA requires emergency planning based on Threshold
Planning Quantities (TPQs) and release reporting based on Reportable Quantities (RQs) in 40 CFR 355 (used for SARA 302, 304,
311 and 312).These values are subject to change and the regulations should be consulted to verify current statutory requirements.
Components present in this product at a level which could require reporting under the statute are:
Component Name % Range
**NONE**
Section 31.1./31.2 Chemical Inventory Reporting Requirements {40 CFR 370): The Superfund Amendments and Reauthorization
Act (SARA} may. require submission of reports (chemical list, MSDS, Tier I & Tier II) to the State Emergency Response Commission,
Local Emergency Response Committee and the local fire department. The SARA physical and health hazards related to this product
are:
X Acute Health Hazard Sudden Release of Pressure Fire
X Chronic Health Hazard Reactive
Section 31.3-List of Toxic Chemicals {40 CFR 372): This product contains the following toxic chemicals subject to the reporting
requirements of Section 313 of the Emergency Planning and Community Right-to-Know Act of 1986 (40 CFR 372}. This information
should be included in all MSDS that are copied and distributed for this material.
Component Name CAS # % Range
ethylene glycol 000107-21-1 < 55%
CERCLA, 40 CFR 261. AND 302: The Comprehensive Environmental Response, Compensation, and Liability Act of 1980
(CERCLA} requires notification of the National Response Center 1-800-424-8802 of any release of a Hazardous Substances equal to
or greater than the reportable quantities (RQs} listed in 40CFR 302.4. Values are given in pounds for the component and not the
mixture, if applicable. (These values are subject to change and the regulations should be consulted to verify current statutory levels.)
Component Name CAS # CERCLA RQ
ethylene glycol 000107-21-1 5000
OSHA Exposure Limits
Component Name
ethylene glycol Ceiling ppm: 50.0 Ceiling MG/M3 125.0
National Fire Protection Agency
2 Health 0 Fire 0 Reactive Other
Department of Transportation Shipping Information
Proper Shipping Name: Non-regulated material
Hazardous substance RQ: 9091# Emergency Response Guide Number: 171
Labels: None
Toxic Substances control Act (TSCA) , 40 CFR 261.
This product, or components if product is a mixture, is/are listed on the Toxic substances control Act (TSCA) inventory. Section 10
information is to remain attached to the material safety data sheet for this product.
While Dorf Ketal believes that the above data is correct, Dorf Ketal expressly disclaims liability for any loss or injury arising out of the
use of this information or the use of any materials designated.
16. OTHER INFORMATION
For additional information concerning this product, contact the following:
PRODUCT EMERGENCIES
Dorf Ketal Chemicals (I) Pvt. Ltd. Dorf Ketal LLC
#1 DORF KETAL TOWERS. 3727 Greenbriar
D鈥橫onte Street, Marve Road. Suite 114,
Malad (W).Bombay 64. Stafford, TX 77477
Tel: +91-22-28813654 / +91-22-28828374. Tel : 281 491 3700
Fax: +91-22-28882366 Fax : 281 491 3700
The data and recommendations presented in this data sheet concerning the use of our product and the materials contain there in are believed to be
accurate and are based on information which is considered reliable as of the date hereof. However, the customer should determine the suitability of
such material for his purpose before adopting them on a commercial scale. Since the use our products by others is beyond our control, no guarantee,
express or implied, is made and no responsibility assumed for the use of this material or the results to be obtained there from. Information on this form
is furnished for the purpose of compliance with Government Health and Safety Regulations and shall not be used for any other purposes. Moreover,
the recommendations contained in this data sheet are not to be constructed as a license to operate under, or a recommendation to infringe, any
existing patents, nor should they be confused with state, municipal or insurance requirements, or with national safety codes.
END OF MSDS
|