Friday, January 25, 2008
Page 1 of 4
MSDS - Material Safety Data Sheet
Product Name: DUNK ENGINE DEGREASER
MSDS No.: D1C
I. Basic Information:
Manufacturer: RADIATOR SPECIALTY COMPANY
2
Address: 600 RADIATOR ROAD
City, ST Zip: INDIAN TRAIL, NC 28079
2 0
Emergency Contact: Rocky Mountain Poision Control Center
Emergency Telephone Number: 303-623-5716
Contact: Robert Geer
Information Telephone Number: 704-684-1811
2
2
Last Update: 01/14/2008 Expiration Date:
0
X Liquid Gas Solid
Chemical State:
H
Pure Mixture
Chemical Type: X
II. Ingredients:
Trade Secret
EHS IARC SARA
313 OSHA ACGIH Other
% Range NTP SUB Z PEL TLV Limits
CAS No. Chemical Name
X
95-63-6 1,2,4-Trimethylbenzene 0.1 - 1.0 N/E 25 ppm
X
111-76-2 2-Butoxyethanol 0.1 - 1.0 25 ppm 25 ppm
64741-44-2 Aliphatic Petroleum Distillate 1.0 - 5.0 N/E N/E 5 mg/m3
9016-45-9 Ethoxylated Nonyl Phenol 0.10 - 1.0 N/D N/D
8008-20-6 Kerosene 60.0 - 100.0 N/AV 100 ppm
68476-34-6 Petroleum distillate, Aliphatic 3.0 - 7.0 N/E 100 ppm N/E
26264-05-1 Surfactant 0.1 - 1.0 N/E N/E
III. Hazardous Identification:
Hazard Category:
X Acute Chronic X Fire Pressure Reactive
Hazardous Identification Information:
Harmful or Fatal if Swallowed. Eye and Skin Irritant. Combustible.
IV. First Aid Measures:
Route(s) of Entry:
Absorption, Eye, Inhalation, and Ingestion.
Health Hazards (Acute and Chronic):
See signs and symptoms below
Signs and Symptoms:
Eye Contact: Irritant. Prolonged contact may cause conjunctivitis.
Skin Contact: Irritant. Defatting of tissue, dermatitis may occur.
Inhalation: Irritant to mucous membranes. Repeated exposure may cause narcosis..
Ingestion: HARMFUL OR FATAL IF SWALLOWED.
Friday, January 25, 2008
Page 2 of 4
MSDS - Material Safety Data Sheet
Product Name: DUNK ENGINE DEGREASER
MSDS No.: D1C
Medical Conditions Generally Aggravated by Exposure:
None known
Emergency and First Aid Procedures:
Eye Contact: Flush eyes with clean water for 15 minutes while lifting eyelids. Get prompt medical attention.
Skin Contact: Wash with soap and water thoroughly. If adverse effects persist, get prompt medical attention. Launder
contaminated clothing before reuse.
Inhalation: Remove to fresh air. If breathing becomes difficult get prompt medical attention.
Ingestion: DO NOT INDUCE VOMITING! Call Poison Control Center, physician, or hospital emergency room immediately.
Aspiration of vomitus into the lungs can cause pneumonitis, which can be fatal.
Other Health Warnings:
Vomiting and subsequent aspiration into the lungs may lead to chemical pneumonia and pulmonary edema which is a potentially
fatal condition.
V. Fire Fighting Measures:
Flash Point: 120掳F Lower Explosive Limit: N/E Upper Explosive Limit: N/E
F.P. Method: TCC
Fire Extinguishing Media: Water Fog, Foam, Carbon Dioxide, Dry Chemical
Special Fire Fighting Procedures:
Wear self-contained positive pressure breathing apparatus and protective clothes. Cool containers with a water fog. Do not use
forced water stream as this could cause the fire to spread.
Unusual Fire and Explosion:
None Known
VI. Accidental Release Measures:
Steps to be Taken in Case Material is Released or Spilled:
Eliminate all ignition sources. Persons not wearing protective equipment should be excluded from area of spill until clean-up has
been completed. Dike or contain spill and absorb with inert materials (sand, sawdust, absorbent sweeping compounds, rags,
etc). Using a non-metalic scoop, place contaminated material into an approved chemical waste container. Where possible,
vacuum spilled liquid using an explosion proof vacuum to recover material. Prevent run-off to sewers, streams, or other bodies of
water. If run-off occurs, notify proper authorities as required that a spill has occured.
VII. Handling and Storage:
Precautions to be Taken:
Handling: Use with adequate ventilation and proper protective equipment.
Do not use near fire, sparks, or flame. Store in cool, well ventilated area below 120掳F away from heat sources and oxidizers.
Other Precautions:
Avoid contact with eyes. Avoid prolonged or repeated breathing of vapors. If exposure may or does exceed occupational
exposure limits, use a NIOSH approved respirator to prevent over-exposure.
VIII. Exposure Controls/Personal Protection:
Ventilation Requirements:
See Section 2 for applicable exposure limits. Use with adequate ventilation. If TLV is exceeded, wear NIOSH approved respirator.
Personal Protective Equipment:
See Section 2 for applicable exposure limits. For prolonged exposure wear protective safety glasses, gloves, and apron.
Friday, January 25, 2008
Page 3 of 4
MSDS - Material Safety Data Sheet
Product Name: DUNK ENGINE DEGREASER
MSDS No.: D1C
IX. Physical and Chemical Properties:
Boiling Point: >300掳F Melting Point: N/A
Evaporation Rate (Butyl Acetate = 1): N/D Vapor Pressure (mm Hg.): N/D
Specific Gravity (H20 = 1): 0.81200 Vapor Density (AIR = 1): N/D
Solubility In Water: Emulifies Appearance and Odor:
Clear orange-brown liquid with petroleum odor
Other Information: N/D
X. Stability and Reactivity:
Stability:
Stable
Incompatibility (Materials to Avoid):
Strong oxidizing agents.
Decomposition/By Products:
High temperatures and ignition sources produce products of combustion: carbon monoxide, sulfur-like smoke.
Hazardous Polymerization:
Will not occur.
XI. Toxicological Information:
N/D
XII. Ecological Information:
N/D
XIII. Disposal Considerations:
DISPOSAL: This container may be recycled in a recycling centers when empty. Before offering for recycling, empty the can or
bottle by using the product according to the label. If recycling is not available, wrap the container and discard in the trash. Dispose
of unused product in accordance with all local, state government and federal laws and regulations
XIV. Transport Information:
Friday, January 25, 2008
Page 4 of 4
MSDS - Material Safety Data Sheet
Product Name: DUNK ENGINE DEGREASER
MSDS No.: D1C
DOT Shipping Name: Not DOT regulated.
DOT Hazard Class: None
The above DOT description is provided to assist in the proper shipping classification of this product by ground and may not be
suitable for all shipping purposes.
ICAO/IATA (US)
Shipping name: Petroleum Product, n.o.s. (Kerosene 8008-20-6)
Class: 3
UN Number: UN1268
Packaging Group: III
International:
ICAO/IATA
UN number: UN1268
Shipping name: Petroleum Product, n.o.s. (Kerosene 8008-20-6)
Class: 3
Packaging Group: III
IMDG
UN number: UN1268
Shipping name: Petroleum Product, n.o.s. (Kerosene 8008-20-6)
Class: 3
Packaging Group: III
XV. Regulatory Information:
See Section 2 for SARA Reportable Chemicals.
USA TSCA: All components of this material are listed on the US TSCA Inventory.
Warning: This product contains a chemical(s) known to the State of California to cause cancer or birth defects or other reproductive
harm.
XVI. Other Information:
Do not used in confined area without proper ventilation. Contact lenses may cause further damage in case of splash into eye.
KEEP AWAY FROM CHILDREN AND ANIMALS!
N/E: Not Established
N/D: Not Determined
N/A: Not Applicable
N/AV: Not Available
While Radiator Specialty Company believes this data is accurate as of the revision date, we make no warranty with respect to the
data and we expressly disclaim all liability for reliance thereon. The data is offered solely for information, investigation, and
verification. Various government agencies may have specific regulations regarding the transportation, handling, storage, use, or
disposal of this product which may not be covered by this MSDS. The user is responsible for full compliance.
|