Static Solutions
331 Boston Post Road
Marlboro, MA 01752 SAFETY INFORMATION
508-480-0700 HEALTH 3
FLAMMABILITY 0
REACTIVITY 0
Material Safety Data Sheet PAGE 1 of 3 CL-5001
SECTION I PRODUCT IDENTITY
PRODUCT TRADE NAME: CL-5001
Distributor: Static Solutions
EFFECTIVE DATE: 2/4/2004
_____________________________________________________________________________
________
SECTION II HAZARDOUS INGREDIENTS
APPROX. WT. % EXPOSURE LIMIT/TOXICITY
(PA,NJ,MA,SARA)Ethylene Glycol Butyl Ether 4-8 25ppm ACGIH/OSHA TWA(skin)
(CAS# 111-76-2) LD50:560-3000 mg/kg (oral-rat)
LC50:500ppm (inhalation-rat) 4 hrs.
(PA,NJ,MA)Monoethanolamine (CAS# 141-43-5) 3-5 3ppm/ACGIH/OSHA TWA,6ppm
ACGIH/OSHA STEL
LD50:2050mg/kg
(PA,NJ,MA) Potassium Hydroxide(CAS#1310-58-3) 2-5 2 mg/m3 ACGIH/OSHA CEILING
LD50:365 mg/mk )oral rat)
_____________________________________________________________________________
_____
SECTION III PHYSICAL DATA
_____________________________________________________________________________
_____
BOILING POINT (DEGREES F.): 212 SPECIFIC GRAVITY: 1.050
VAPOR PRESSURE: = Not determined % VOLATILES BY WEIGHT: 93-96
VAPOR DENSITY: = Not determined EVAPORATION RATE: = To Water
SOLUBILITY IN WATER: Complete pH: 12.0-14.0
APPEARANCE: Thin clear
ODOR: slight solvent
SECTION IV FIRE AND EXPL0SION
_____________________________________________________________________________
________
FLASH POINT (DEGREES F.): None to boiling
FLAMMABLE LIMITS: N/A
EXTINGUISHING MEDIA: Water, CO2, Dry Chemical, Foam
UNUSUAL FIRE AND EXPLOSION HAZARDS: Heated material may liberate irritating fumes
Static Solutions
331 Boston Post Road
Marlboro, MA 01752
508-480-0700
Material Safety Data Sheet Page 2 of 3 CL-5001
_____________________________________________________________________________
________
SECTION V REACTIVITY DATA
STABILITY: Stable
CONDITIONS TO AVOID: None
INCOMPATIBILITY: Strong acids and oxidizers
HAZARDOUS DECOMPOSITION PRODUCTS: Produces normal products of combustion.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None.
SECTION VI HEALTH HAZARD DATA
ROUTES OF ENTRY: Eye Contact. Skin Contact.
EFFECTS OF ACUTE EXPOSURE:
EYE鈥︹?︹?︹?︹?︹??..CORROSIVE: may cause permanent eye damage.
SKIN鈥︹?︹?︹?︹?︹?? CORROSIVE: may cause chemical burns.
INHALATION鈥︹?? May cause: Irritation of the respiratory tract.
INGESTION鈥︹?︹?orrosive to mouth and digestive tract.
MEDICAL CONDITIONS: Persons with pre-existing skin disorders may be more susceptible
to
GENERALLY RECOGNIZED irritating effects.
AS BEING AGGRAVATED
BY EXPOSURE
EMERGENCY AND FIRST AID PROCEDURES:
FOR SKIN: Wash affected area thoroughly with water. If blistering is apparent or irritation
persists, call a
physician.
FOR EYES: Flush with water for at least 15 minutes. Get immediate medical aid.
IF INGESTED: DO NOT INDUCE VOMITING. Give milk, egg white, gelatin, or if none of these
available, give water. Get immediate medical aid.
INHALATION: Remove to fresh air.
LISTED CARCINOGEN, MUTAGEN, TERATOGEN: None.
SECTION VII
SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Recontainerize by mopping,
wet vac or by using a suitable absorbent. All disposal methods must be in compliance with
Federal, State and local laws and regulations. Waste characterizations are the responsibility of
the waste generator.
SECTION VIII
SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: If mists/vapors are not adequately controlled by local ventilation,
use appropriate respiratory protection to prevent overexposure.
VENTILATION: General room ventilation is normally adequate. Substantial amounts of mists/
vapors can be controlled with local exhaust ventilation or respiratory protection.
PROTECTIVE GLOVES: Rubber or latex gloves required.
EYE PROTECTION: Safety glasses or goggles required.
OTHER PROTECTIVE EQUIPMENT: If major exposure is possible to eyes/skin, wear/use
appropriate equipment.
Static Solutions
331 Boston Post Road
Marlboro, MA 01752
508-480-0700
Material Safety Data Sheet Page 3 of 3 CL-5001
_____________________________________________________________________________
________
SECTION IX
HANDLING AND STORAGE
PRECAUTIONARY INFORMATION: WARNING CORROSIVE: Avoid contact. May burn skin and
damage Eyes. Harmful if swallowed, When handling, wear eye protection and rubber gloves.
OTHER HANDLING AND
STORAGE CONDITIONS: Store in a cool dry place with adequate ventilation. Wash thoroughly
after handling. Launder contaminated clothing \ equipment before reuse.
KEEP OUT OF REACH OF CHILDREN
SECTION X REGULATORY INFORMATION
All ingredients of this product are listed or are excluded from listing on the U. S. Toxic Substances
Control Act (TSCA) Chemical Substance Inventory.
These ingredients from Section 2 are subject to the following reporting requirements:
PA- The Pennsylvania Hazardous Substance List
NJ- The New Jersey Right to Know Hazardous Substance List.
MA- The Massachusetts Hazardous Substance List.
SARA-The Superfund Amendments and Reauthorization Act of 1986 Title III, Section 313 and 40
CFR Part 372.
_____________________________________________________________________________
_
Static Solutions, cannot anticipate all conditions of handling and use of this product. Therefore,
Static Solutions, accepts no responsibility for results obtained by the application of this
information or the safety and suitability of our products either alone or in combination with any
other products.
This document has been prepared using resources considered to be technically reliable. It does
not constitute a warranty, express or implied, as to the accuracy of the information contained
herein.
Prepared by Manufacturer鈥檚 Technical Support Group
Revised 2/5/97
Revised 2/4/04
DOT: COMPOUNDS, CLEANING LIQUID. N.O.S. 8, NA1760, PGIII
|