Material Safety Data Sheet
___________________________________________________
01-JAN-2006
SpecSeal庐 TYPE SSS SEALANT
CHEMICAL PRODUCT/COMPANY IDENTIFICATION
Material Identi铿乧ation
PRODUCT NAME.....................SpecSeal庐 SSS Sealant
CHEMICAL FAMILY...................Mixture
Company Identi铿乧ation
MANUFACTURER/DISTRIBUTOR
Speci铿乪d Technologies, Inc.
200 Evans Way
Somerville, NJ 08876
PHONE NUMBERS
Product Information : 1-908-526-8000
Emergency : 1-800-255-3924
COMPOSITION/INFORMATION ON INGREDIENTS
INGREDIENT NAME CAS NUMBER
Proprietary mixture --------------------
HAZARDS IDENTIFICATION
************EMERGENCY OVERVIEW***********
* Possible skin and eye irritant. Blue paste. *
******************************************************
Potential Health Effects:
EYE: Contact may cause irritation.
SKIN: Contact may cause irritation.
INGESTION: Relatively non-toxic.
INHALATION: Irritation of the nose, throat, and lungs may result from over-exposure to vapors or mist.
CHRONIC (CANCER) INFORMATION: Not classi铿乪d as carcinogenic.
LONG TERM TOXIC EFFECTS: None known.
Page 1 of 3 MSDS - SpecSeal庐 TYPE SSS Sealant FOD-5002
FIRST AID MEASURES
First Aid
INHALATION: Remove to fresh air.
SKIN CONTACT: Wash thoroughly.
EYE CONTACT: Irrigate eyes with running water for at least 15 minutes. Get medical attention if irritation develops.
INGESTION: None applicable.
FIRE FIGHTING MEASURES
Not a 铿乺e hazard.
EXTINGUISHING MEDIA .............................................Dry Chemical; Carbon Dioxide; Foam; Water spray for large 铿乺es.
SPECIAL FIRE FIGHTING PROCEDURES: ................ As for surrounding 铿乺e.
ACCIDENTAL RELEASE MEASURES
Safeguards (Personnel)
NOTE: Review FIRE FIGHTING MEASURES and HANDLING (PERSONNEL) sections before proceeding with clean-up. Use
appropriate PERSONAL PROTECTIVE EQUIPMENT during clean-up.
HANDLING AND STORAGE
Store under ambient conditions. No special handling required.
EXPOSURE CONTROLS/PERSONAL PROTECTION
EYE PROTECTION REQUIREMENTS:....................... Safety glasses/goggles.
SKIN PROTECTION REQUIREMENTS: ..................... Gloves.
RESPIRATOR REQUIREMENTS: ............................... None.
VENTILATION REQUIREMENTS:............................... If needed, use local exhaust ventilation to keep airborne concentrations
below the TLV.
Exposure Guidelines
Exposure Limits
PEL(OSHA) : Particulates (Not Otherwise Classi铿乪d) 15 mg/m3, 8 Hr. TWA, total dust 5 mg/m3, 8 Hr. TWA, respirable dust
TLV (ACGIH) : None Established
PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL FORM .................................................... Red paste with minimal odor
SPECIFIC GRAVITY ................................................ 1.24
PERCENT VOLATILES ............................................ 20
EVAPORATION RATE .............................................. >1
BOILING POINT ....................................................... 100 deg. C
SOLUBILITY IN WATER........................................... In铿乶itely dilutable
STABILITY AND REACTIVITY
STABILITY: ............................................................... This is a stable material.
CONDITIONS TO AVOID ......................................... Storage >55 deg. C
HAZARDOUS POLYMERIZATION: .......................... Will not occur.
INCOMPATIBILITIES:鈥︹?︹?︹?︹?︹?︹?︹?︹?︹?︹??.........None special.
TOXICOLOGICAL INFORMATION
Mixture not tested but based on components:
May be irritating to skin and eyes and may aggravate existing skin and eye conditions.
None of the components are listed as carcinogens.
Page 2 of 3 MSDS - SpecSeal庐 TYPE SSS Sealant FOD-5002
ECOLOGICAL INFORMATION
No data.
DISPOSAL CONSIDERATIONS
Waste Disposal:
Treatment, storage, transportation, and disposal must be in accordance with applicable Federal, State/Provincial, and Local
regulations.
TRANSPORTATION INFORMATION
DOT 鈥? not regulated.
REGULATORY INFORMATION
U.S. Federal Regulations
TSCA Inventory Status: Reported/Included.
Section 313 Supplier Noti铿乧ations.
This product contains no toxic chemicals subject to the reporting requirements of Section 313 of the Emergency Planning and
Community Right-To-Know Act of 1986 and of 40 CFR 372:
OTHER INFORMATION
NPCA-HMIS Rating
Health :1
Flammability : 0
Reactivity :0
Personal Protection rating to be supplied by user depending on use
conditions.
STATE RIGHT-TO-KNOW LAWS
No substances on the state hazardous substances list, for the states indicated below, are used in the manufacture of products on
this Material Safety Data Sheet, with the exceptions indicated. While we do not speci铿乧ally analyze these products, or the raw
materials used in their manufacture, for substances on various state hazardous substances lists, to the best of our knowledge the
products on this Material Safety Data Sheet contain no such substances except for those speci铿乧ally listed below:
SUBSTANCES ON THE NEW JERSEY WORKPLACE HAZARDOUS SUBSTANCE LIST PRESENT AT A CONCENTRATION
OF 1% OR MORE (0.1% FOR SUBSTANCES IDENTIFIED AS CARCINOGENS, MUTAGENS OR TERATOGENS): NJTSRN-
SSS100
WARNING: SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER: Possible traces of formaldehyde,
ethyl acrylate, acetaldehyde, acrylamide and acrylonitrile.
WARNING: SUBSTANCES KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM: None known.
------------------------------------------------------------------
This information relates to the speci铿乧 material designated and may not be valid for such material used in combination with any
other materials or in any process. Such information is to the best of our knowledge and belief accurate and reliable as of the data
compiled. However, no representation, warranty, or guarantee is made as to its accuracy, reliability or completeness. It is the user鈥檚
responsibility to satisfy himself as to the suitability and completeness of such information for his own particular use. We do not
accept liability for any loss or damage that may occur form the use of this information.
Responsibility for MSDS :
Speci铿乪d Technologies, Inc.
200 Evans Way
Somerville, NJ 08876
Page 3 of 3 MSDS - SpecSeal庐 TYPE SSS Sealant FOD-5002
|