24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
MATERIAL SAFETY DATA SHEET
SECTION I 鈥? IDENTIFICATION OF SUBSTANCE AND COMPANY
ISSUED BY:
JEEN INTERNATIONAL CORPORATION Chemtrec EMERGENCY TEL#800-424-9300
24 MADISON ROAD Chemtrec INT鈥橪 TEL#703-527-3887(Collect Calls Accepted)
FAIRFIELD, NJ 07004
Tel.# 973-439-1401
TRADE NAME: JEECHEM DOA
CHEMICAL NAME AND SYNONYMS: DIOCTYL ADIPATE
HEXANEDIOIC ACID, BIS (2-ETHYHEXYL) ESTER
CHEMICAL FAMILY: DI-BASIC ACID ESTER
MOLECULAR FORMULA: C22H42O4
EINECS#: 203-090-1
SECTION 2 鈥? INFORMATION ON INGREDIENTS
CHEMICAL NAME CAS #
Diethylhexyl Adipate 103-23-1
SECTION 3 鈥? HAZARD IDENTIFICATION
CLEAR LIQUID; MILD ODOR
Potential Health Effects
Skin Contact: Repeated or prolonged skin contact may cause skin irritation
Eye Contact: May cause slight eye irritation of susceptible persons
Ingestions: Substance may be harmful if swallowed. May irritate mouth, throat and stomach
Inhalation: May cause dizziness
SECTION 4 鈥? FIRST AID MEASURES
Skin Contact: Wash affected skin with soap and water. Seek medical attention if symptoms persist.
Eye Contact: Flush eyes with large amounts of water for at least 15 minutes. If irritation persists,
consult a physician.
Ingestion: Seek medical advice
Inhalation: Person should be moved to a fresh air environment
SECTION 5 鈥? EXPLOSION AND FIRE-FIGHTING MEASURES
Extinguishing Media: CO2, Dry Chemical, Water Fog
Special Fire-Fighting Procedures: A MSHA/NIOSH approved self-contained breathing apparatus should
be worn.
Unusual Fire and Explosion Hazards: Solid stream of water directed at burning liquid may cause frothing.
SECTION 6 鈥? ACCIDENTAL RELEASE / SPILL PROCEDURES
Steps to be Taken in Case Material is Released or Spilled: Dike and contain the spill with inert material
(i.e., sand, earth, sawdust) and transfer liquid and solid diking material to separate containers for recovery or
disposal. Wash floor area with hot water solution. Remove contaminated clothing and wash before reuse.
Wash affected skin area with soap and water. Keep spills out of all sewers and bodies of water.
SECTION 7 鈥? HANDLING AND STORAGE
Any use of this product in an elevated process, should be evaluated to establish and maintain safe operating
procedures. Keep from contact with oxidizing materials. Containers should be kept tightly closed and stored
in a dry well-ventilated place.
JEECHEM DOA Page 1 of 3
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
SECTION 8 鈥? PERSONAL PROTECTION
Hand Protection: Impervious gloves
Eye Protection: Safety glasses
Respiratory Protection: None required for normal operation
Engineering Measures: For normal operation, local exhaust ventilation should suffice. Direct exhaust
when material becomes heated and fumes are given off.
Other: Eyewash facility in vicinity
SECTION 9 鈥? PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point: 417 deg. F
Flash Point (COC): 390 deg. F
Vapor Density (Air=1): 12.9
Vapor Pressure (20 deg. C) N/A
Specific Gravity: 0.923
Evaporation Rate: N/A
Solubility in Water: Negligible
pH: N/A
Appearance and Odor: Clear liquid; mild odor
SECTION 10 鈥? STABILITY AND REACTIVITY
Stability: This product is stable under normal conditions
Conditions to Avoid: Strong oxidizing agents
Hazardous Polymerization: Will not occur under normal circumstances
SECTION 11 鈥? TOXICOLOGICAL INFORMATION
Acute Oral Toxicity: Non-toxic. LD50 > 6 g/kg
Primary Skin Irritation: Not a primary skin irritant. PII 鈥? 0.83
Primary Eye Irritation: Not a primary eye irritant 鈥? Non irritating
Additional Tests: Non sensitizing, nonphotosensitizing, nonmutagenic
SECTION 12 鈥? ECOLOGICAL INFORMATION
Summary: Data for this material have been used to estimate its environmental impact. It has the
following properties: A high potential to affect some aquatic organisms, some potential to
biodegrade with acclimated microorganisms from activated sludge, a low potential to
persist in the environment, and a low potential to bio concentrate.
Acute Aquatic Effects: 96 hour LC50 (fathead minnow): NOEC > 0.78 mg/l
96 hour LC50 (rainbow trout): NOEC > 0.78 mg/l
This product does not contain any ozone depleting compounds (ODC鈥檚).
SECTION 13 鈥? DISPOSAL CONSIDERATIONS
Waste Disposal Methods: Material should be disposed of in accordance to current local and national
regulations. Contacting a waste disposal service is recommended.
SECTION 14 鈥? TRANSPORT INFORMATION
Not classified as hazardous according to the Department of Transportation.
JEECHEM DOA Page 2 of 3
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
SECTION 15 鈥? REGULATORY INFORMATION
Toxic Substances Control Act (TSCA): This product is in compliance with the TSCA regulation of the United
States.
Domestic Substance List (DSL): This product is listed on the DSL inventory of Canada
Australian Inventory of Chemical Substances (AICS): This product is listed on the AICS inventory of
Australia.
European Inventory of Existing Chemical Substances (EINECS): This product is listed on the EINECS
inventory of Europe. Registration #. 203-090-1
Superfund Amendments and Reauthorization Act (SARA): This product has the following hazards as defined
in Section 311/312 of 40 CFR Part 372: Hazards 鈥? None
This product contains the following chemicals subject to the reporting requirements of Section 313 or Title III
of SARA and 40 CFR Part 372: Ingredients 鈥? None
California Proposition 65: This product contains the following substances known to the State of California to
cause cancer, birth defects, or other reproductive harm per the Safe Drinking Water and Toxic Enforcement
Act of 1986: Ingredients - None
SECTION 16 鈥? OTHER INFORMATION
Revision Date: 7/01 Supersedes: 2/00
JEECHEM DOA Page 3 of 3
|