24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
MATERIAL SAFETY DATA SHEET
SECTION I - MATERIAL AND MANUFACTURER IDENTIFICATION
Manufacturer's Name: JEEN INTERNATIONAL CORPORATION Chemtrec Emergency Tel. No.: 800-424-9300
24 MADISON ROAD *Chemtrec Int鈥檒 Tel.No.: 703-527-3887
FAIRFIELD, NJ 07004 *(Collect Calls Accepted)
Tel.# 973-439-1401
TRADE NAME: JEECHEM PGDD
GENERIC NAME: FATTY ACID ESTER LAST REVISION DATE: 02/01/2001
SECTION II - INGREDIENTS
OSHA ACGIH
INGREDIENT NAME: CAS#: PEL TLV OTHER %
- 68988-72-7* NONE NONE NONE 100
SECTION 313 SUPPLIER NOTIFICATION
THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF THE
EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986 AND OF 40 CFR 372.
OSHA ACGIH
INGREDIENT NAME: CAS#: PEL TLV OTHER %
***NO CHEMICALS IN THIS SECTION***
SECTION III - CHEMICAL CHARACTERISTICS
BOILING POINT: 204掳C VAPOR DENSITY (AIR=1): N/R
MELTING POINT: -38掳C EVAPORATION RATE (WATER ___)=1: NIL
SPECIFIC GRAVITY (H2O=1): 0.918 SOLUBILITY (IN WATER): INSOLUBLE
VAPOR PRESSURE (mm/Hg): N/R REACTIVITY WITH WATER: NONE
PERCENT VOLATILE BY VOLUME: N/R
APPEARANCE & ODOR: CLEAR, COLORLESS, ESSENTIALLY ODORLESS MOBILE LIQUID
SECTION IV - FIRE AND EXPLOSION HAZARD DATA
FLASH POINT (METHOD USED): 149掳C. (COC)
FLAMMABLE LIMITS IN AIR (%): UPPER = N/R; LOWER = N/R
AUTOIGNITION TEMPERATURE: UNKNOWN
EXTINGUISHING MEDIA: ABC EXTINGUISHER, CARBON DIOXIDE, FORAM, WATER SPRAY
SPECIAL FIRE FIGHTING PROCEDURES:
WATER OR FOAM MAY CAUSE FROTHING WHEN APPLIED TO FLAMMABLE LIQUIDS HAVING FLASH POINTS ABOVE 100oC.
THE FROTHING MAY BE VIOLENT AND COULD ENDANGER THE LIFE OF THE FIREFIGHTER PARTICULARLY WHEN SOLID
STREAMS ARE DIRECTED DIRECTLY INTO THE BURNING LIQUID (NFPA 325M-1984).
UNUSUAL FIRE AND EXPLOSION HAZARDS: ***ADDITIONAL INFORMATION***
WARNING:
HOT ORGANIC CHEMICAL VAPORS OR MISTS ARE SUSCEPTIBLE TO SUDDEN SPONTANEOUS COMBUSTION WHEN MIXED
WITH AIR. IGNITION MAY OCCUR AT TEMPERATURES BELOW THOSE PUBLISHED IN THE LITERATURE AS "AUTOIGNITION"
OR "IGNITION" TEMPERATURES. IGNITION TEMPERATURES DECREASE WITH INCREASING VAPOR VOLUME AND
VAPOR/AIR CONTACT TIME AND ARE INFLUENCED BY PRESSURE CHANGES.
IGNITION MAY OCCUR AT TYPICAL ELEVATED-TEMPERATURE PROCESS CONDITIONS, ESPECIALLY INA PROCESS
OPERATING UNDER VACUUM IF SUBJECTED TO SUDDEN INGRESS OF AIR, OR OUTSIDE PROCESS EQUIPMENT
OPERATING AT ELEVATED PRESSURE IF SUDDEN ESCAPE OF VAPORS OR MISTS TO THE ATMOSPHERE OCCURES. ANY
PROPOSED USE OF THIS PRODUCT IN ELEVATED-TEMPERATURE PROCESSES SHOULD BE THOROUGHLY EVALUATED TO
ASSURE THAT SAFE OPERATING CONDITIONS ARE ESTABLISHED AND MAINTAINED.
Page No. 1 of 2 鈥? MSDS 鈥? JEECHEM PGDD
24 Madison Road, Fairfield, New Jersey 07004, USA
Tel: 800-771-JEEN (5336), Tel: 973-439-1401, Fax: 973-439-1402,
email: info@jeen.com , Website: www.jeen.com
SECTION V - REACTIVITY DATA
IS THIS CHEMICALSTABLE UNDER NORMAL
CONDITIONS OF HANDLING/STORAGE (Y/N)?: Y
CONDITIONS TO AVOID: NONE
INCOMPATIBILITY (MATERIALS TO AVOID): KEEP AWAY FROM HEAT AND FLAMES. AVOID CONTACT WITH
OXIDIZING MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS: NONE
HAZARDOUS POLYMERIZATION POSSIBLE (Y/N)?: N
CONDITIONS TO AVOID: NONE
SECTION VI - HEALTH HAZARDS
ROUTES OF ENTRY: SKIN, EYES
SIGNS AND SYMPTOMS OF:
ACUTE OVEREXPOSURE: NONE KNOWN
CHRONIC OVEREXPOSURE: NONE KNOWN
MEDICAL CONDITIONS GENERALLY
AGGRAVATED BY EXPOSURE: NONE KNOWN
CHEMICAL LISTED AS A CARCINOGEN
OR POTENTIALCARCINOGEN (Y/N)?: NATIONAL TOXICOLOGY PROGRAM: N; IARC MONOGRAPHS: N; OSHA: N
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: IMMEDIATELY REMOVE VICTIM TO FRESH AIR. IF VICTIM HAS STOPPED BREATHING GIVE ARTIFICIAL
RESPIRATION. GET MEDICAL ATTENTION.
EYE CONTACT: FLUSH WITH RUNNING WATER FOR 15 MINUTES. DO NOT LET VICTIM RUB EYES. GET MEDICAL
ATTENTION IMMEDIATELY.
SKIN CONTACT: WASH WITH SOAP AND WATER.
INGESTION: CALL A PHYSICIAN OR POISON CONTROL CENTER PROMPTLY.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:STORE IN TIGHTLY CLOSED ORIGINAL CONTAINERS AT
TEMPERATURES BETWEEN 13o-60oC. TO AVOID CONTAMINATION.
OTHER PRECAUTIONS: STORE BULK LIQUID AT TEMPERATURES BETWEEN 45掳-80掳C. IN STAINLESS STEEL OR
ALUMINUM VESSELS UNDER DRY, INERT ATMOSPHERE.
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: CONTAIN SPILL. TRANSFER TO SECURE
CONTAINERS. WHERE NECESSARY, COLLECT USING ABSORBENT MEDIA. FLUSH AREA WITH HOT WATER AND
DETERGENT.
WASTE DISPOSAL METHODS: FOLLOW FEDERAL, STATE, AND LOCAL REGULATIONS WITH REGARD TO THE DISPOSAL OF
NON-HAZARDOUS ORGANIC MATERIALS.
SECTION VIII - CONTROL MEASURES
RESPIRATORY PROTECTION: NONE REQUIRED OTHER: NONE
VENTILATION REQUIREMENTS: NONE REQUIRED PROTECTIVE GLOVES: NOT REQUIRED
LOCAL EXHAUST: NONE EYE PROTECTION: SAFETY GLASSES
MECHANICAL: NONE OTHER PROTECTIVE
SPECIAL: NONE CLOTHING OR EQUIPMENT: NONE
WORK/HYGENIC PRACTICES: FOR LOW NORMAL HYGIENIC PRACTICES.
Page No. 2 of 2 鈥? MSDS 鈥? JEECHEM PGDD
This information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of JEEN International Corporation. The data on this
sheet relates only to the specific material designated herein. JEEN International Corporation assumes no legal responsibility for use or reliance upon these data.
|