CONSUMER MATERIAL SAFETY DATA SHEET
NAME OF PRODUCT: Adhesive Remover
MSDS DATE: 12/20/2002
SECTION 1: PRODUCT AND COMPANY IDENTIFICATION
PRODUCT NAME: Adhesive Remover
PRODUCT CODES: 00-01650, 00-01650-01
SUPPLIER: Henkel Consumer Adhesives.
ADDRESS: 32150 Just Imagine Drive
Avon, Ohio 44011
MANUFACTURER: Apollo Industries Inc.
ADDRESS: 1850 South Cobb Industrial Boulevard
Smyrna, Georgia, 30082
DOMESTIC EMERGENCY PHONE: Chemtrec 1-800-424-9300
In Canada Canutec 613-996-6666
OTHER CALLS: Regulatory Affairs 905-459-1140
FAX PHONE: Regulatory Affairs 905-459-8031
CHEMICAL FAMILY: Petroleum distillate
PRODUCT USE: Consumer Product; General Purpose Adhesive Remover
PREPARED BY: S. Dhalla
MSDS PREPARATION DATE: 12/20/02
SECTION 1 NOTES: Adhesive Remover. Removes Adhesives, Residue, Tape & more
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
INGREDIENT: CAS NO. OSHA PEL ACGIH TLV OTHER
Petroleum Distillate 64742-47-8 550ppm Not established N/A
SECTION 3: HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW: DANGER: HARMFUL OR FATAL IF SWALLOWED.
COMBUSTIBLE. EYE AND SKIN IRRITANT
ROUTES OF ENTRY: oral, dermal, inhalation
POTENTIAL HEALTH EFFECTS
EYES: Eye irritation with tearing, discomfort and blurring vision.
SKIN: Product may cause irritation with rash and discomfort.
INGESTION: May cause irritation, nausea and vomiting. Aspiration into lungs
may cause pulmonary edema.
INHALATION: High concentrations or vapors may irritate nose, throat and
Cause headache, dizziness and nausea
SECTION 4: FIRST AID MEASURES
EYES: Immediately flush eyes with water for atleast 15 minutes. Get medical attention if irritation
persists.
SKIN: Remove contaminated clothing and wash skin with soap and water. Get medical attention if
irritation persists.
INGESTION: Do not induce vomiting. Immediately give 2 glasses of water. Never give anything by
mouth to an unconscious person. Get medical attention immediately. NOTE TO PHYSICIAN:
Activated charcoal mixture may be administered. To prepare mixture, suspend 50 grams activated
charcoal in 400ml water and mix thoroughly. Administer 5ml/kg or 350ml for an average adult.
INHALATION: Remove victim to fresh air. Apply artificial respiration if needed. Seek medical
attention.
SECTION 5: FIRE-FIGHTING MEASURES
NFPA HAZARD CLASSIFICATION
HEALTH: FLAMMABILITY: REACTIVITY: <1,1,0>
EXTINGUISHING MEDIA: Foam, CO2, Dry chemical
UNUSUAL FIRE AND EXPLOSION HAZARDS: Product considered combustible. Containers
exposed to intense heat from fires should be cooled with water to prevent vapor pressure buildup,
which could result in container rupture.
SPECIAL FIREFIGHTING PROCEDURES: Keep containers cool using water spray. If a leak or spill
has not ignited, use water spray to disperse the vapors and to provide protection for personnel
attempting to stop a leak.
HAZARDOUS DECOMPOSITION PRODUCTS: Oxides of carbon at high temperatures.
SECTION 6: ACCIDENTAL RELEASE MEASURES
ACCIDENTAL RELEASE MEASURES: Absorb spill with inert material then place in a chemical
waste container. Dispose of spill material in accordance with regulations.
SECTION 7: HANDLING AND STORAGE
HANDLING AND STORAGE: Use with adequate ventilation. Do not use or store near fire,
sparks or flame.
See label on product for use directions.
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION
ENGINEERING CONTROLS: Maintain adequate ventilation.
RESPIRATORY PROTECTION: Use respirator only as a last resort to control exposure
when engineering controls are not possible.
EYE PROTECTION: Wear Safety glasses or Goggles to prevent eye contact.
SKIN PROTECTION: Wear chemical resistant gloves if repeated skin contact
occurs or causes irritation.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE: Orange colored clear liquid.
ODOR: Citrus (orange) odor
PHYSICAL STATE: Liquid
pH AS SUPPLIED: Not established.
SPECIFIC GRAVITY (H2O = 1): 0.78-0.82
SOLUBILITY IN WATER: Insoluble
EVAPORATION RATE: <1 (Butyl acetate=1)
BOILING POINT: >200 F
% VOC 5%
SECTION 10: STABILITY AND REACTIVITY
STABILITY: Stable
CONDITIONS TO AVOID: Do not use or store near fire, sparks or flame.
HAZARDOUS POLYMERIZATION: Will not occur
INCOMPATIBILITY: Strong oxidizers
SECTION 11: TOXICOLOGICAL INFORMATION
TOXICOLOGICAL INFORMATION: See Section 3 Hazard Identifications.
SECTION 11 NOTES: Contact Regulatory Affairs if further information is required.
SECTION 12: ECOLOGICAL INFORMATION
ECOLOGICAL INFORMATION: No data available.
SECTION 13: DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD: Dispose in accordance with applicable regulations.
SECTION 14: TRANSPORT INFORMATION
U.S. DEPARTMENT OF TRANSPORTATION
PROPER SHIPPING NAME: COMBUSTIBLE LIQUID N.O.S (PETROLEUM DISTILLATES)
HAZARD CLASS: 3
UN NUMBER: NA1993
PACKING GROUP: III
NOTE: This product classifies as a Consumer Commodity due to its size and intended use. ORM-D
SECTION 15: REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS
This product has been labeled according to the Federal Hazardous Substances Act and the
associated Consumer Product Safety Regulations.
SECTION 16: OTHER INFORMATION
OTHER INFORMATION: Information provided in this MSDS is intended to provide supplementary
information for consumer uses of this product. This product is not intended for industrial uses.
HAZARD WARNING STATEMENT ON PRODUCT LABEL.
DANGER: HARMFUL OR FATAL IF SWALLOWED. COMBUSTIBLE. EYE AND SKIN IRRITANT.
Contains petroleum distillates. Avoid contact with eyes and prolonged contact with skin. Do not
breathe vapors. Keep away from heat, sparks and open flame. If swallowed do not induce vomiting,
call a physician immediately. For eye contact flush with water for 15 minutes, call a physician. For
skin contact wash thoroughly with soap and water. If overcome by vapors get fresh air. KEEP OUT
OF REACH OF CHILDREN.
Contact Regulatory Affairs for additional information
PREPARATION INFORMATION: Created and approved on 12/20/2002 by S.Dhalla
DISCLAIMER: The information appearing herein is furnished without express or implied warranty
and is based upon tests and data believed to be accurate to the best knowledge of Manco Inc.. It is
the user鈥檚 responsibility to ensure that the product is handled safely and that the instructions for
use are properly communicated and followed. Manco Inc. assumes no legal responsibility or liability
for any use not in accordance with the use described in this MSDS or in the product labeling.
|