Material Safety Data Sheet
Section 1 鈥? Identification
Product Trade Name: Wilson Jones Paper Shredder Oil
Revision Date: 01/13/99
Information/Emergency Phone Number: (901) 658 -9050
Fax Number: (901) 658 -3591
For Chemical Emergency
Spill, Leak, Fire, Exposure, or Accident
Call CHEMTREC-day or night (800) 424-9300
Toll-Free in the continental U.S.
*add long-distance access number if required
483-7616 in District of Columbia
for calls originating outside the continental U.S.:
(202) 483-7616 Washington, DC, collect
All Calls Are Recorded
Chemical Family: Petroleum Lubricating Oil
Note: Petroleum lubricating oils with a flashpoint above 200 degrees F,
are not regulated by D.O.T. standards.
Section 2- Hazardous Ingredients
Name CAS# APPR REG AGEN EXP LIMIT
Base Oil Performance 64742-54-7 >90 OSHA/ACGIH 5mg/m3 Mis
Additive Proprietary <1 OSHA/ACGIH 5mg/m3 Mis
Silicone Defoamer Non -Hazardous <1 OSHA/ACGIH 10mg/m3 Mis
Health 1, Flammability 1, Reactivity 1,
HMIS/NFPA Code:
Protective Equipment C or D
See Section 6, Chronic Effects, for potential over -exposure hazard.
Section 3- Physical Data
Vapor Pressure(mmHg): <1
Specific Gravity: .93
Water Solubility: Negligible
Boiling Point: 600+ degrees F
Vapor Density: 1+
Evaporation Rate(BUAC=1): <1
Odor: Hydrocarbon Odor
Appearance: Light Amber Color
Viscosity at 100 degrees C: 4.4 CST
Section 4- Fire and Explosion Hazards
Flash Point: 385 degrees F
Fire Point: 430 degrees F
Extinguishing Media(s): Water, Fog, Chemical Foam,
Dry Chemical Powder, CO2
Special Firefighting
Procedures: Cool exposed containers with water spray.
Avoid breathing fumes.
Unusual Fire &
Explosion Hazards: Pressure increases in over heated closed containers.
Cool containers with water spray.
Section 5-Reactivity Data
Stability: Stable
Incompatibility: Avoid strong oxidants
Polymerization: Will not occur
Thermal Decomposition: Partial burning produces fumes, smoke and
carbon monoxide
Section 6-Health Hazard Data
Inhalation: Inhalation of fumes may result in dizziness, headache,
and respiratory irritation.
Eye Contact: Contact with eyes may cause minimal irritation.
Skin Contact: Mild irritation may occur with prolonged or repeated
contact.
Ingestion: Slightly toxic. Pulmonary aspiration hazard if vomiting
occurs.
Pre-Existing Medical
Conditions & Complications: None known
TLV: 5mg/m3 as mint. ACGIH 1984 -85
Chronic Effects: Product has a low order of acute oral toxicity. Ingredients
of this product are not listed as potential carcinogens in
N.T.P. Annual Report on Carcinogens, I.A.R.C.
Mopographs or by OSHA HCS (g) (2) (vii).
All ingredients in this product are listed on the TSCA
inventory.
Emergency First Aid Procedures
Skin: Wash skin with soap and warm water. Wash clothing
before re-use.
Eye: If splashed into eyes flush eyes with clear water for five (5)
minutes.
Inhalation: If overcome by fumes remove from exposure immediately.
Oral: If ingested, do not induce vomiting. Call a physician.
Section 7- Special Protection Information
Ventilation Procedure: Ventilate as needed to comply with exposure limit.
Gloves Protection: Use impervious gloves to avoid repeated/prolonged
skin contact.
Eye Protection: Use goggles/faces shield to avoid eye contact.
Work/Hygienic Practices: If clothing becomes contaminated, change to fresh clean
clothing. Do not wear until thoroughly laundered.
Section 8- Spill or Leak Procedures
Spill Procedures: Remove ignition sources. Recover liquid. Add absorbent
to spill area. Ventilate confined spaces. Advise authorities
if product enter sewers, etc.
Waste Disposal: Assure conformity with applicable disposal regulations.
Dispose of absorbed material at approved waste site.
Section 9- Special Precautions
Handling and Storage
Precautions: Keep containers closed when not in use. Do not handle or
store near heat or flames. Use chemical resistant gloves and
apron.
The Data presented herein is based upon tests and information which we believe to be
reliable. However, users should make their own investigations to determine the
suitability of the information for their particular purpose.
|