MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
South Plainfield, NJ 07080
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
: GCP50XZ4
Trade Name
INCI Name : Zinc Oxide (And) Caprylic/Capric Triglyceride (And) Polyhydroxystearic Acid
(And) Methicone
Chemical Name : Zinc Oxide (And) Caprylic/Capric Triglyceride (And) Polyhydroxystearic Acid
(And) Methicone
SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS
Chemical Name CAS # EINECS #
Zinc Oxide 1314-13-2 215-222-5
Caprylic/Capric Triglyceride 65381-09-1 265-724-3
Polyhydroxystearic acid 27924-99-8 Polymer
Methicone 9004-73-3 Polymer
SECTION 3: HAZARD IDENTIFICATION
No particular danger.
SECTION 4: FIRST AID MEASURES
Effects and Symptoms:
Primary Route(s) of Entry : Skin and eye contact.
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Ingestion : None needed for small amounts. For large amounts, if conscious, give water
and call physician.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : N/A
Flammable Limits LEL/UEL % : N/A
Extinguishing Media : Dry Chemical, Foam, CO2, and water spray
Special Fire Fighting Procedures : Self-contained breathing apparatus and protective clothing.
Unusual Fire And Explosion Hazards : Foam or water can cause frothing.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Eye contact and excessive skin contact.
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage
systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves,
goggles, and lab coat. Carefully contain spilled material . Deposit spilled
material in appropriate waste container. Wash spill area with soap and water.
SECTION 7: HANDLING AND STORAGE
Handling : Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling
and before mealtimes. Follow all MSDS and label precautions even after container is
emptied since it may contain residual material.
Page 1 of 3
KOBO Products, Inc.
GCP50XZ4
Storage : Store containers closed in ambient location.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
15 mg/m3 10mg/m3
ZnO (Total Dust)
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : N/A Percent Volatile By Vol. (%) : N/A
Freezing Point (掳C) : N/A Vapor Density (Air=1) : Not determined
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : Not determined
Vapor Pressure (mm hg) : N/A Solubility In Water : Insoluble
Appearance & Odor : White slurry, slight Odor
SECTION 10: STABILITY AND REACTIVITY
Stable :
Yes
Hazardous Polymerization :
Will not occur
Conditions To Avoid :
Open flames and sparks, extreme heat, oxidizing materials
Incompatibility :
Strong oxidizing materials such as peroxide, bromine and chromic acid,
strong acids, dehydrating agents, hydrogen peroxide can cause a reaction.
Hazardous Decomposition Products : CO2
SECTION 11: TOXICOLOGICAL INFORMATION
Zinc Oxide
Skin Irritation : None when 0.5 mL/patch of 50 % water dispersion
Primary Eye Irritation : Slight stimulus, Draize Score= 6.67
Acute Oral Toxicity : Non-toxic, LD50 > 2 g/kg (rat)
Acute Skin Toxicity : Non-toxic, LD50 > 2 g/kg (rat)
Mutagenicity : Negative (Ames test)
Chronic Effects on CARCINOGENIC EFFECTS: Classified None. By NIOSH [Zinc Oxide].
Classified A4 (not
Humans classifiable for human or animal.) by ACGIH, 3 (not classifiable for human.) by IARC
[Zinc Oxide]. Classified None.
MUTAGENIC EFFECTS: Not available.
SECTION 12: ECOLOGICAL INFORMATION
Not available
SECTION 13: DISPOSAL CONSIDERATIONS
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material
may be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
DOT Classification : Not Regulated
Page 2 of 3
KOBO Products, Inc.
GCP50XZ4
SECTION 15: REGULATORY INFORMATION
No information available
SECTION 16: OTHER INFORMATION
Hazardous Material Information System [Ratings Key: 4= Highest hazard, 0= Lowest hazard]
(U.S.A.)
Health 0
Fire Hazard 1
Reactivity 0
Personal Protection C
EU Phrases : S25/36- avoid contact with eyes and wear suitable protective clothing.
Date Prepared : January 13, 2005
By Eric Smith
Note:
The statements made here are intended to describe the product with regard to necessary safety precautions. They do
not guarantee special characteristics. This information is furnished without warranty, expressed or implied, except
that it is accurate to the best of our current knowledge.
Page 3 of 3
|