**** SECTION 2 - COMPOSITION, INFORMATION ON INGREDIENTS ****
+----------------+--------------------------------------+----------+-----------+
| CAS# | Chemical Name | % | EINECS# |
|----------------|--------------------------------------|----------|-----------|
| 2031-67-6 |Methyltriethoxysilane | >98 | 217-983-9 |
+----------------+--------------------------------------+----------+-----------+
Hazard Symbols: None Listed.
Risk Phrases: 10
**** SECTION 3 - HAZARDS IDENTIFICATION ****
EMERGENCY OVERVIEW
Flammable.
Potential Health Effects
Eye:
Causes mild eye irritation. May cause chemical conjunctivitis and
corneal damage.
Skin:
Causes mild skin irritation.
Ingestion:
May cause gastrointestinal irritation with nausea, vomiting and
diarrhea. Ingestion of large amounts may cause CNS depression.
Inhalation:
Causes respiratory tract irritation. Vapors may cause dizziness or
suffocation. Can produce delayed pulmonary edema. May cause burning
sensation in the chest.
Chronic:
Prolonged or repeated skin contact may cause dermatitis. Effects may
be delayed. Ethanol is mainly metabolized in the liver, which is also
one of the primary target organs. While ethanol is well known to
cause cirrhosis of the liver in alcoholics, liver cirrhosis has also
been produced in rabbits exposed by inhalation.
**** SECTION 4 - FIRST AID MEASURES ****
Eyes:
Immediately flush eyes with plenty of water for at least 15 minutes,
occasionally lifting the upper and lower eyelids. Get medical aid.
Skin:
Get medical aid. Flush skin with plenty of water for at least 15
minutes while removing contaminated clothing and shoes. Wash clothing
before reuse.
Ingestion:
If victim is conscious and alert, give 2-4 cupfuls of milk or water.
Never give anything by mouth to an unconscious person. Get medical
aid.
Inhalation:
Remove from exposure and move to fresh air immediately. If not
breathing, give artificial respiration. If breathing is difficult,
give oxygen. Get medical aid.
Notes to Physician:
Treat symptomatically and supportively.
**** SECTION 5 - FIRE FIGHTING MEASURES ****
General Information:
As in any fire, wear a self-contained breathing apparatus in
pressure-demand, MSHA/NIOSH (approved or equivalent), and full
protective gear. Vapors may form an explosive mixture with air.
Vapors can travel to a source of ignition and flash back. During a
fire, irritating and highly toxic gases may be generated by thermal
decomposition or combustion. Flammable liquid and vapor. Vapors may
be heavier than air. They can spread along the ground and collect in
low or confined areas. Contact with water liberates highly flammable
gases.
Extinguishing Media:
Use carbon dioxide or dry chemical. Do NOT get water inside
containers.
**** SECTION 6 - ACCIDENTAL RELEASE MEASURES ****
General Information: Use proper personal protective equipment as indicated
in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth),
then place in suitable container. Clean up spills immediately,
observing precautions in the Protective Equipment section. Remove all
sources of ignition. Use a spark-proof tool. Provide ventilation. Do
not get water inside containers. A vapor suppressing foam may be
used to reduce vapors.
**** SECTION 7 - HANDLING and STORAGE ****
Handling:
Ground and bond containers when transferring material. Use
spark-proof tools and explosion proof equipment. Avoid contact with
eyes, skin, and clothing. Empty containers retain product residue,
(liquid and/or vapor), and can be dangerous. Keep container tightly
closed. Keep away from heat, sparks and flame. Avoid ingestion and
inhalation. Do not allow contact with water. Do not pressurize, cut,
weld, braze, solder, drill, grind, or expose empty containers to
heat, sparks or open flames. Keep from contact with moist air and
steam.
Storage:
Keep away from heat, sparks, and flame. Keep away from sources of
ignition. Store in a tightly closed container. Store in a cool, dry,
well-ventilated area away from incompatible substances.
Flammables-area. Store protected from moisture.
**** SECTION 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION ****
Engineering Controls:
Facilities storing or utilizing this material should be equipped
with an eyewash facility and a safety shower. Use adequate general or
local explosion-proof ventilation to keep airborne levels to
acceptable levels.
Exposure Limits
CAS# 2031-67-6:
Personal Protective Equipment
Eyes:
Wear chemical splash goggles.
Skin:
Wear appropriate protective gloves to prevent skin
exposure.
Clothing:
Wear appropriate protective clothing to prevent skin
exposure.
Respirators:
A respiratory protection program that meets OSHA's 29
CFR 1910.134 and ANSI Z88.2 requirements or European
Standard EN 149 must be followed whenever workplace
conditions warrant respirator use.
**** SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES ****
Physical State: Liquid
Color: clear, colorless
Odor: None reported.
pH: Not available.
Vapor Pressure: 11 mm Hg @ 20 deg C
Viscosity: Not available.
Boiling Point: 141-143 deg C @ 760 mmHg
Freezing/Melting Point: Not available.
Autoignition Temperature: 220 deg C ( 428.00 deg F)
Flash Point: 23 deg C ( 73.40 deg F)
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature:
Solubility in water: Reacts.
Specific Gravity/Density: 0.8900 g/ml
Molecular Formula: C7H18O3Si
Molecular Weight: 178.30
**** SECTION 10 - STABILITY AND REACTIVITY ****
Chemical Stability:
Stable under normal temperatures and pressures. Material generates
ethanol on contact with water.
Conditions to Avoid:
Ignition sources, moisture, excess heat.
Incompatibilities with Other Materials:
Water, strong oxidizing agents, strong acids.
Hazardous Decomposition Products:
Carbon monoxide, carbon dioxide, silicon dioxide, ethanol.
Hazardous Polymerization: Has not been reported
**** SECTION 11 - TOXICOLOGICAL INFORMATION ****
RTECS#:
CAS# 2031-67-6: VV4640000
LD50/LC50:
CAS# 2031-67-6: Draize test, rabbit, eye: 100 uL Mild; Draize test,
rabbit, skin: 500 mg/24H Mild; Oral, rat: LD50 = 8570 uL/kg; Skin,
rabbit: LD50 = 13300 uL/kg.
Carcinogenicity:
Methyltriethoxysilane -
Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.
**** SECTION 12 - ECOLOGICAL INFORMATION ****
**** SECTION 13 - DISPOSAL CONSIDERATIONS ****
Dispose of in a manner consistent with federal, state, and local regulations.
**** SECTION 14 - TRANSPORT INFORMATION ****
IATA
Shipping Name: FLAMMABLE LIQUID, N.O.S.*
Hazard Class: 3
UN Number: 1993
Packing Group: III
IMO
Shipping Name: FLAMMABLE LIQUID, N.O.S.
Hazard Class: 3.3
UN Number: 1993
Packing Group: III
RID/ADR
Shipping Name: FLAMMABLE LIQUID, N.O.S.
Hazard Class: 3
UN Number: 1993
Packing group: III
**** SECTION 15 - REGULATORY INFORMATION ****
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: Not available.
Risk Phrases:
R 10 Flammable.
Safety Phrases:
S 16 Keep away from sources of ignition - No
smoking.
WGK (Water Danger/Protection)
CAS# 2031-67-6: No information available.
Canada
CAS# 2031-67-6 is listed on Canada's DSL List.
CAS# 2031-67-6 is listed on Canada's Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 2031-67-6 is listed on the TSCA inventory.
**** SECTION 16 - ADDITIONAL INFORMATION ****
MSDS Creation Date: 9/02/1997 Revision #7 Date: 7/09/2004
The information above is believed to be accurate and represents the best
information currently available to us. However, we make no warranty of
merchantability or any other warranty, express or implied, with respect to
such information, and we assume no liability resulting from its use. Users
should make their own investigations to determine the suitability of the
information for their particular purposes. In no way shall the company be
liable for any claims, losses, or damages of any third party or for lost
profits or any special, indirect, incidental, consequential or exemplary
damages, howsoever arising, even if the company has been advised of
the possibility of such damages.
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
|
|
|
| ALL MSDS PAGES IN THIS GROUP
| | NAME | CAS |
|
Poly(diallyl phthalate), average m.w. 65000 (gpc)
| 25053-15-0 |
|
Suberoyl chloride, 97%
| 10027-07-3 |
|
4,4'-Di-Tert.-Butylbiphenyl, 99+%
| 1625-91-8 |
|
1,1,2,2,-Tetrachloroethane, 99% (gc)
| 79-34-5 |
|
4-Nitroimidazole, 98%
| 3034-38-6 |
|
Isobutyl cyanoacetate, 99+%
| 13361-31-4 |
|
1,1,2,2-Tetrachloroethane-d2, 99 atom % d
| 33685-54-0 |
|
p-Phenylenediamine, 99% (uv-vis)
| 106-50-3 |
|
3-Fluoro-2-methylaniline, 97%
| 443-86-7 |
|
Propionitrile, 99%
| 107-12-0 |
|
Manganese(II) carbonate hydrate, 90%
| 598-62-9 |
|
1-Methoxy-1,4-cyclohexadiene, tech., 75%
| 2886-59-1 |
|
Hemin, 99% (uv-vis)
| 16009-13-5 |
|
L-Asparagine, Monohydrate, 99% (Titr.)
| 5794-13-8 |
|
2,6-Dimethylphenol, 99%
| 576-26-1 |
|
Isopropyl(S)-(-)-lactate, 99%
| 63697-00-7 |
|
Vinyltoluene, stabilized with 10 to 15 ppm p-tert-Butylcatechol
| 25013-15-4 |
|
1-Benzylpiperazine, 97+%
| 2759-28-6 |
|
4-Phenylazobenzoyl Chloride
| 104-24-5 |
|
Ethyl Indole-2-Carboxylate, 97%
| 3770-50-1 |
|
2-Chloro-6-Methylbenzonitrile, 97%
| 6575-09-3 |
|
DL-3-Hydroxy-4-Methoxymandelic Acid, 99%
| 3695-24-7 |
|
2,4-Difluorobenzoyl chloride
| 72482-64-5 |
|
2-Methylcyclohexylamine, 98%, mixture of cis and trans
| 7003-32-9 |
|
Manganese Phthalocyanine
| 14325-24-7 |
|
Diethyl Sulfate, 95% (GC)
| 64-67-5 |
|
L-(-)-Perillic Acid, 95%
| 7694-45-3 |
|
m-Phenylenediamine, 99+%
| 108-45-2 |
|
Trimethyl Orthoformate, 99%
| 149-73-5 |
|
5-Methyl-2-nitrophenol, 97%
| 700-38-9 |
|
N-(4-nitrobenzoyl)-l-glutamic acid diethyl ester, 98%
| |
|
5,5-Diphenyl-2-Thiohydantoin, 99%
| 21083-47-6 |
|
Propionic acid-d6, 98.5+ atom% d
| 19448-61-4 |
|
2-Amino-6-methylmercaptopurine
| 1198-47-6 |
|
Manganese(II) bromide, anhydrous, 99%
| 13446-03-2 |
|
2-Methylthiophene, 98%
| 554-14-3 |
|
Cyclohexyl Mercaptan, 99+%
| 1569-69-3 |
|
Trans-4-Octyl-Alpha-Chloro-4'- Ethoxystilbene, 99+%
| 33468-15-4 |
|
2,5-Dihydroxybenzaldehyde, 99%
| 1194-98-5 |
|
Cyclopentyl Bromide, 98%
| 137-43-9 |
|
3,5-Diiodosalicylic Acid, 99% (Titr.)
| 133-91-5 |
|
Tris-(3-(Trifluoromethylhydroxymethylene)- D-Camphorato), YB(III)
| 38054-03-4 |
|
4-Chloro-O-Tolylhydrazine Hydrochloride
| 19690-59-6 |
|
Methyltriethoxysilane, 98+%
| 2031-67-6 |
|
Thorin I, Indicator Grade
| 132-33-2 |
|
2-Amino-6-Chlorobenzothiazole, 99%
| 95-24-9 |
|
10-Undecenoyl chloride, 98%
| 38460-95-6 |
|
D(-)-p-Hydroxyphenylglycine, 98+%
| 22818-40-2 |
|
Methyl 2-Isothiocyanatobenzoate, 98%
| 16024-82-1 |
|
Ethyl 2-oxocyclopentanecarboxylate, tech., 90%
| 611-10-9 |
|
|