**** SECTION 2 - COMPOSITION, INFORMATION ON INGREDIENTS ****
+----------------+--------------------------------------+----------+-----------+
| CAS# | Chemical Name | % | EINECS# |
|----------------|--------------------------------------|----------|-----------|
| 7440-47-3 |Chromium | 1.0-3.0% | 231-157-5 |
|----------------|--------------------------------------|----------|-----------|
| 7697-37-2 |Nitric acid | 5-10.0% | 231-714-2 |
|----------------|--------------------------------------|----------|-----------|
| 7732-18-5 |Water | Balance | 231-791-2 |
+----------------+--------------------------------------+----------+-----------+
Hazard Symbols: T C
Risk Phrases: 34 43 49
**** SECTION 3 - HAZARDS IDENTIFICATION ****
EMERGENCY OVERVIEW
Causes burns. May cause sensitization by skin contact. May cause
cancer by inhalation.Corrosive.
Potential Health Effects
Eye:
Causes severe eye burns. May cause irreversible eye injury.
Skin:
Causes skin burns. May cause skin sensitization, an allergic
reaction, which becomes evident upon re-exposure to this material.
May cause deep, penetrating ulcers of the skin.
Ingestion:
Causes gastrointestinal tract burns. May cause perforation of the
digestive tract.
Inhalation:
May be fatal if inhaled. Effects may be delayed. May cause
irritation of the respiratory tract with burning pain in the nose and
throat, coughing, wheezing, shortness of breath and pulmonary edema.
Chronic:
Repeated inhalation may cause chronic bronchitis. Repeated exposure
may cause erosion of teeth. May cause cancer in humans.
**** SECTION 4 - FIRST AID MEASURES ****
Eyes:
Flush eyes with plenty of water for at least 15 minutes,
occasionally lifting the upper and lower eyelids. Get medical aid
immediately. Do NOT allow victim to rub or keep eyes closed.
Skin:
Get medical aid immediately. Flush skin with plenty of soap and
water for at least 15 minutes while removing contaminated clothing
and shoes. Wash clothing before reuse.
Ingestion:
Do NOT induce vomiting. If victim is conscious and alert, give 2-4
cupfuls of milk or water. Never give anything by mouth to an
unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure to fresh air
immediately. If not breathing, give artificial respiration. If
breathing is difficult, give oxygen.
Notes to Physician:
**** SECTION 5 - FIRE FIGHTING MEASURES ****
General Information:
As in any fire, wear a self-contained breathing apparatus in
pressure-demand, MSHA/NIOSH (approved or equivalent), and full
protective gear. Use water spray to keep fire-exposed containers
cool. Substance is noncombustible.
Extinguishing Media:
Substance is noncombustible; use agent most appropriate to
extinguish surrounding fire.
**** SECTION 6 - ACCIDENTAL RELEASE MEASURES ****
General Information: Use proper personal protective equipment as indicated
in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth),
then place in suitable container. Wear a self contained breathing
apparatus and appropriate Personal protection. (See Exposure
Controls, Personal Protection section). Neutralize spill with sodium
bicarbonate. Use water spray to disperse the gas/vapor.
**** SECTION 7 - HANDLING and STORAGE ****
Handling:
Wash thoroughly after handling. Remove contaminated clothing and
wash before reuse. Use with adequate ventilation. Do not get on skin
or in eyes. Do not ingest or inhale. Discard contaminated shoes.
Storage:
Store in a cool, dry, well-ventilated area away from incompatible
substances.
**** SECTION 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION ****
Engineering Controls:
Use adequate general or local exhaust ventilation to keep airborne
concentrations below the permissible exposure limits.
Personal Protective Equipment
Eyes:
Wear appropriate protective eyeglasses or chemical
safety goggles as described by OSHA's eye and face
protection regulations in 29 CFR 1910.133 or European
Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin
exposure.
Clothing:
Wear appropriate protective clothing to prevent skin
exposure.
Respirators:
A respiratory protection program that meets OSHA's 29
CFR ??1910.134 and ANSI Z88.2 requirements or European
Standard EN 149 must be followed whenever workplace
conditions warrant a respirator's use.
**** SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES ****
Physical State: Liquid
Appearance: orange
Odor: Not available.
pH: Not available.
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: Not available.
Freezing/Melting Point: Not available.
Autoignition Temperature: Not available.
Flash Point: Not available.
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature: Not available.
Solubility in water: Soluble in water.
Specific Gravity/Density: 1.0
Molecular Formula: Solution
Molecular Weight: 0
**** SECTION 10 - STABILITY AND REACTIVITY ****
Chemical Stability:
Stable at room temperature in closed containers under normal storage
and handling conditions.
Conditions to Avoid:
None reported.
Incompatibilities with Other Materials:
Nitric acid reacts with over 150 chemical combinations. Refer to NFPA
Fire Protection Guide for specifics. Reacts explosively with organic
materials and combustibles.
Hazardous Decomposition Products:
Nitrogen oxides.
Hazardous Polymerization: Has not been reported
**** SECTION 11 - TOXICOLOGICAL INFORMATION ****
RTECS#:
CAS# 7440-47-3: GB4200000
CAS# 7697-37-2: QU5775000 QU5900000
CAS# 7732-18-5: ZC0110000
LD50/LC50:
Not available.
CAS# 7697-37-2: Inhalation, rat: LC50 = 67 ppm(NO2)/4H.
CAS# 7732-18-5: Oral, rat: LD50 = >90 mL/kg.
Carcinogenicity:
Chromium -
ACGIH: A4 - Not Classifiable as a Human Carcinogen
IARC: Group 3 carcinogen
Nitric acid -
Not listed by ACGIH, IARC, NIOSH, NTP, or OSHA.
Water -
Not listed by ACGIH, IARC, NIOSH, NTP, or OSHA.
Other:
See actual entry in RTECS for complete information.
**** SECTION 12 - ECOLOGICAL INFORMATION ****
Ecotoxicity:
Nitric Acid: Mosquito fish: TLm=72 ppm/96H (fresh water) Cockle:
LC50=330-1000 ppm/48H (salt water)
**** SECTION 13 - DISPOSAL CONSIDERATIONS ****
Products which are considered hazardous for supply are classified as Special
Waste and the disposal of such chemicals is covered by regulations which may
vary according to location. Contact a specialist disposal company or the local
waste regulator for advice. Empty containers must be decontaminated before
returning for recycling.
**** SECTION 14 - TRANSPORT INFORMATION ****
IATA
Shipping Name: Corrosive liquid, toxic, n.o.s(chromium (VI) oxide in n
in nitric acid)
Hazard Class: 8
UN Number: 2922
Packing Group: III
IMO
Shipping Name: CORROSIVE LIQUID, TOXIC, N.O.S(chromium (VI) oxide in n
in nitric acid)
Hazard Class: 8
UN Number: 2922
Packing Group: III
RID/ADR
Shipping Name: CORROSIVE LIQUID, TOXIC, N.O.S. (chromium (VI) oxide in
de in nitric acid)
Dangerous Goods Code: 8(76C)
UN Number: 2922
**** SECTION 15 - REGULATORY INFORMATION ****
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: T C
Risk Phrases:
R 34 Causes burns.
R 43 May cause sensitization by skin contact.
R 49 May cause cancer by inhalation.
Safety Phrases:
S 23 Do not inhale gas/fumes/vapour/spray.
S 26 In case of contact with eyes, rinse immediately
with plenty of water and seek medical advice.
S 36 Wear suitable protective clothing.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 7440-47-3: No information available.
CAS# 7697-37-2: 1
CAS# 7732-18-5: No information available.
United Kingdom Occupational Exposure Limits
CAS# 7440-47-3: OES-United Kingdom, TWA 0.5 mg/m3 TWA
CAS# 7697-37-2: OES-United Kingdom, TWA 2 ppm TWA; 5.2 mg/m3 TWA
CAS# 7697-37-2: OES-United Kingdom, STEL 4 ppm STEL; 10 mg/m3 STEL
CAS# 7697-37-2: OES-United Kingdom, STEL 4 ppm STEL; 10 mg/m3 STEL
Canada
CAS# 7440-47-3 is listed on Canada's DSL List.
CAS# 7697-37-2 is listed on Canada's DSL List.
CAS# 7732-18-5 is listed on Canada's DSL List.
CAS# 7440-47-3 is listed on Canada's Ingredient Disclosure List.
CAS# 7697-37-2 is listed on Canada's Ingredient Disclosure List.
CAS# 7732-18-5 is not listed on Canada's Ingredient Disclosure List.
Exposure Limits
CAS# 7440-47-3: OEL-ARAB Republic of Egypt:TWA 0.05 mg/m3
OEL-AUSTRALIA:TWA 0.05 mg/m3
OEL-BELGIUM:TWA 0.5 mg/m3
OEL-DENMARK:TWA 0.5 mg/m3
OEL-FINLAND:TWA 0.01 mg/m3
OEL-FRANCE:TWA 0.5 mg/m3
OEL-JAPAN:TWA 0.5 mg/m3
OEL-THE NETHERLANDS:TWA 0.5 mg/m3
OEL-THE PHILIPPINES:TWA 1 mg/m3
OEL-SWEDEN:TWA 0.5 mg/m3
OEL-UNITED KINGDOM:TWA 0.5 mg/m3
OEL IN BULGARIA, COLOMBIA, JORDAN, KOREA check ACGIH TLV
OEL IN NEW ZEALAND, SINGAPORE, VIETNAM check ACGI TLV
CAS# 7697-37-2: OEL-ARAB Republic of Egypt:TWA 2 ppm (5 mg/m3)
OEL-AUSTRALIA:TWA 2 ppm (5 mg/m3);STEL 4 ppm (10 mg/m3)
OEL-BELGIUM:TWA 2 ppm (5.2 mg/m3);STEL 4 ppm (10 mg/m3)
OEL-CZECHOSLOVAKIA:TWA 2.5 mg/m3;STEL 5 mg/m3
OEL-DENMARK:TWA 2 ppm (5 mg/m3)
OEL-FINLAND:TWA 2 ppm (5 mg/m3);STEL 5 ppm (13 mg/m3);Skin
OEL-FRANCE:TWA 2 ppm (5 mg/m3);STEL 4 ppm (10 mg/m3)
OEL-GERMANY:TWA 10 ppm (25 mg/m3)
OEL-HUNGARY:STEL 5 mg/m3
OEL-JAPAN:TWA 2 ppm (5.2 mg/m3)
OEL-THE PHILIPPINES:TWA 2 ppm (5 mg/m3)
OEL-POLAND:TWA 10 mg/m3
OEL-RUSSIA:TWA 2 ppm;STEL 2 mg/m3;Skin
OEL-SWEDEN:TWA 2 ppm (5 mg/m3);STEL 5 ppm (13 mg/m3)
OEL-SWITZERLAND:TWA 2 ppm (5 mg/m3);STEL 4 ppm (1 mg/m3)
OEL-THAILAND:TWA 2 ppm (5 mg/m3)
OEL-TURKEY:TWA 2 ppm (5 mg/m3)
OEL-UNITED KINGDOM:TWA 2 ppm (5 mg/m3);STEL 4 ppm (10 mg/m3)
OEL IN BULGARIA, COLOMBIA, JORDAN, KOREA check ACGIH TLV
OEL IN NEW ZEALAND, SINGAPORE, VIETNAM check ACGI TLV
US FEDERAL
TSCA
CAS# 7440-47-3 is listed on the TSCA inventory.
CAS# 7697-37-2 is listed on the TSCA inventory.
CAS# 7732-18-5 is listed on the TSCA inventory.
**** SECTION 16 - ADDITIONAL INFORMATION ****
MSDS Creation Date: 12/12/1997 Revision #6 Date: 8/15/2000
The information above is believed to be accurate and represents the best
information currently available to us. However, we make no warranty of
merchantability or any other warranty, express or implied, with respect to
such information, and we assume no liability resulting from its use. Users
should make their own investigations to determine the suitability of the
information for their particular purposes. In no way shall the company be
liable for any claims, losses, or damages of any third party or for lost
profits or any special, indirect, incidental, consequential or exemplary
damages, howsoever arising, even if the company has been advised of
the possibility of such damages.
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
|
|
|