IPS CORP -- WELD-ON 2711 PVC PIPE CEMENT
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BXRNG
MSDS NAME: WELD-ON 2711 PVC PIPE CEMENT
Responsible Party
Name: IPS CORP
Address: 17109 SOUTH MAIN ST
Box: 379
City: GARDENA CA 90248
Info Phone: 310-366-3300
Emergency Phone Number: 800-424-9300 (CHEMTREC)
Preparer's Name: GEORGE BLANCO
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: IPS CORP
Address: 17109 S MAIN
Box: 379
City: GARDENA CA 90248-5000
Phone: 213-321-6515/213484-5151
Name: IPS CORPORATION
Address: 17109 S. MAIN ST.,
Box: 379
City: GARDENA CA 90248
Phone: 310-898-3300
=======================================================
Ingredients
=======================================================
Cas: 9002-86-2
RTECS #: KV0350000
Name: ETHYLENE, CHLORO-, POLYMER; (POLYVINYL CHLORIDE RESIN) (PVC)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 109-99-9
RTECS #: LU5950000
Name: FURAN, TETRAHYDRO-; (TETRAHYDROFURAN) (THF) (CERCLA)
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM/250STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 78-93-3
RTECS #: EL6475000
Name: 2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313) (CERCLA)
% Wt: 17
OSHA PEL: 200 PPM
ACGIH TLV: 200 PPM/300STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 108-94-1
RTECS #: GW1050000
Name: CYCLOHEXANONE (CERCLA)
OSHA PEL: 50 PPM, S
ACGIH TLV: 25 PPM, S
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 872-50-4
RTECS #: UY5790000
Name: 2-PYRROLIDINONE, 1-METHYL-; (N-METHYLPYRROLIDONE)
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
RTECS #: 9999999VO
Name: VOLATILE ORGANIC CONTENT: 695 GM/L MAXIMUM VOC EMISSION PER SCAQMD RULE
1168. TEST METHOD 318A; 450 GM/L.
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: RESP PROT: LIMITED. USE IT ONLY FOR A SINGLE SHORT-TERM EXPOSURE. FOR
EMERGENCY AND OTHER CONDITIONS WHERE SHORT
-----------------------------
Name: ING 7: TERM EXPOSURE GUIDELINES MAY BE EXCEEDED, USE AN APPROVED POSITIVE
PRESSURE SCBA.
-----------------------------
Name: VENT: BELOW APPLICABLE EXPOSURE LIMITS SET IN INGREDIENTS SECTION. USE
ONLY EXPLOSION-PROOF EQUIPMENT.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: INHAL: SEV OVEREXP MAY RSLT IN NAUS, DIZZ, HDCH.
CAN CAUSE DROW, IRRIT OF EYES & NASAL PASSAGES. SKIN: IRRIT. LIQ CONT MAY
REMOVE NATURAL SKIN OILS RSLTG IN SKIN IRRIT. DERM MAY OCCUR W/PRLNG C ONT.
SKIN ABSORPTION: PRLNG/WIDESPREAD EXPOS MAY RSLT IN ABSORPTION OF HARMFUL
AMTS OF MATL. EYES: (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: OVEREXP MAY RSLT IN SEV EYE
INJURY W/CORNEAL/CONJUNCTIVAL INFLAMM ON CONT W/LIQ. VAPS SLIGHTLY
UNCOMFORTABLE. INGEST: MOD TOX. MAY CAUSE NAUS, VOMIT, DIARR. MAY CAUSE
MENTAL SLUGGISHNESS. CH RONIC: SYMP OF RESP TRACT IRRIT & DMG TO RESP
EPITHELIUM WERE REPORTED IN RATS EXPOS TO 5000PPM THF FOR 90 (SUP DAT).
Medical Cond Aggravated By Exposure: INDIVIDUALS WITH PREEXISTING DISEASES OF
THE EYES, SKIN OR RESPIRATORY SYSTEM MAY HAVE INCREASED SUSCEPTIBILITY TO THE
TOXICITY OF EXCESSIVE EXPOSURE.
First Aid: INHAL: REMOVE TO FRESH AIR & IF BRTHG STOPPED, GIVE ARTF RESP.
IF BRTHG IS DFCLT, GIVE OXYGEN. CALL MD. EYES: FLUSH W/PLENTY OF WATER FOR AT
LEAST 15 MIN & CALL MD. SKIN: REMOVE CONTAM CLTHG & SHOES. WASH SKIN
W/PLENTY OF WATER FOR AT LEAST 15 MIN. IF IRRIT DEVELOPS, GET MEDICAL ATTN.
INGEST: GIVE 1 0R 2 GLASSES OF WATER/MILK. DO NOT INDUCE VOMIT. CALL MD/POIS
CTL CTR IMMED.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ELIMINATE ALL IGNIT SOURCES. AVOID BRTHG OF VAPS.
KEEP LIQ OUT OF EYES. FLUSH W/LARGE AMTS OF WATER. CONTAIN LIQ W/SAND/EARTH.
ABSORB W/SAND/NON-FLAMM ABSORB MATL & TRANSFER INTO STEEL DRUMS FOR RECOV
ERY/DISP. PREVENT LIQ FROM ENTERING DRAINS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: FOLLOW LOC, STATE & FED REGS. CONSULT DISP EXPERT.
CAN BE DISP OF BY INCIN. EXCESS QTYS SHOULD NOT BE PERMITTED TO ENTER DRAINS.
EMPTY CONTRS SHOULD BE AIR-DRIED BEFORE DISP. HAZARDOUS WASTE CODE: 214 .
Handling And Storage Precautions: STORE IN SHADE BETWEEN 40F-110F. KEEP AWAY
FROM HEAT, SPARKS, OPEN FLAME & OTHER SOURCES OF IGNIT. AVOID PRLNG BRTHG
OF VAP. USE W/ADEQ VENT.
Other Precautions: AVOID CONT W/EYES, SKIN & CLTHG. TRAIN EMPLOYEES ON ALL
SPECIAL HNDLG PROC BEFORE THEY WORK W/THIS PROD. FOLLOW ALL PREC INFO GIVEN
ON CONTR LABEL, PROD BULLETINS & MFR SOLV CEMENTING LITERATURE. ALL
HNDLG EQUIP SHOULD BE ELEC GROUNDED.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 6F,-14C
Lower Limits: 2.0%
Upper Limits: 11.8%
Extinguishing Media: ANSUL "PURPLE K" POTASSIUM BICARBONATE, DRY CHEM, CARBON
DIOXIDE. NATIONAL AER-O-FOAM UNIVERSAL ALCOHOL (SUP DAT)
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). EVACUATE ENCLSD AREAS, STAY UPWIND. USE WATER SPRAY TO COOL CONTRS, TO
FLUSH SPILLS FROM SOURCE (SUP DAT)
Unusual Fire/Explosion Hazard: FIRE HAZARD BECAUSE OF LOW FLASH POINT AND HIGH
VOLATILITY. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL TO SOURCE OF IGNITION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: ATM LEVELS SHOULD BE MAINTAINED BELOW ESTABLISHED EXPOS
LIM CONTAINED IN INGRED SECTION. IF AIRBORNE CONCS EXCEED THOSE LIM, USE
NIOSH/MSHA APPRVD ORG VAP CARTRIDGE RESP W/FULL FACE-PIECE REC. EFFECTI
VENESS OF AIR-PURIFYING RESP IS
Ventilation: USE ONLY WITH ADEQUATE VENTILATION. PROVIDE SUFFICIENT VENTILATION
IN VOLUME AND PATTERN TO KEEP CONTAMINANTS
Protective Gloves: PVA COATED GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGS (FP N).
Other Protective Equipment: IMPERVIOUS APRON AND A SOURCE OF RUNNING WATER TO
FLUSH THE EYES AND SKIN IN CASE OF CONTACT.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: SOL IN H*2O: SOLVENT PORTION COMPLETELY SOLUBLE
IN WATER. RESIN PORTION SEPARATES OUT. EXTING MEDIA: RESISTANT FOAM, WATER
SPRAY. FIRE FIGHT PROC: OF IGNIT & TO DISPERSE VAPS. EFTS OF OVEREXP:
DAYS. E LEVATION OF SGPT SUGGESTS DISTURBANCE IN LIVER FUNCTION. NOEL WAS
REPORTED TO BE 200PPM.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: 151F,66C
Vapor Pres: 143 @ 20C
Vapor Density: 2.49
Spec Gravity: 0.985 +/- 0.040
Evaporation Rate & Reference: >1.0 (BUTYL ACETATE=1)
Solubility in Water: (SUP DAT)
Appearance and Odor: GRAY, MEDIUM SYRUPY LIQUID WITH ETHEREAL ODOR
Percent Volatiles by Volume: 85-75%
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME AND OTHER
SOURCES OF IGNITION.
Materials To Avoid: CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS,
STRONG OXIDIZERS AND ISOCYANATES.
Hazardous Decomposition Products: WHEN FORCED TO BURN, THIS PRODUCT GIVES OUT
CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE AND SMOKE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: WELD-ON 2711 PVC PIPE CEMENT
Assigned IND: Y
Company: IPS CORP
Street: 17109 S MAIN
PO Box: 379
City: GARDENA CA
Zipcode: 90248-5000
Health Emergency Phone: 800-424-9300 (CHEMTREC)
Label Required IND: Y
Date Of Label Review: 05/24/1995
Status Code: C
Label Date: 05/24/1995
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE. ACUTE: INHAL: SEVERE OVEREXP MAY RESULT IN
NAUSEA, DIZZINESS, HEADACHE. CAN CAUSE DROWSINESS, IRRIT OF EYES & NASAL
PASSAGES. SKIN: IRRIT. LIQ CONT MAY REMOVE NATURAL SKIN OILS RESULTING IN
SKIN IRRIT. DERMATITIS MAY OCCUR W/PROLONGED CONT. SKIN ABSORPTION:
PROLONGED/WIDESPREAD EXPOS MAY RESULT IN ABSORPTION OF HARMFUL AMOUNTS OF
MATERIAL. EYES: OVEREXP MAY RESULT IN SEVERE EYE INJURY W
/CORNEAL/CONJUNCTIVAL INFLAMMATION ON CONT W/LIQ. VAPORS SLIGHTLY
UNCOMFORTABLE. INGEST: MODERATE TOXICITY. MAY CAUSE NAUSEA, VOMITING,
DIARRHEA. MAY CAUSE MENTAL SLUGGISHNESS. CHRONIC: ANIMAL STUDIES SHOW LIVER
EFFECTS, RESP TRACT IRRIT & DAMAGE.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
DRYLOK CLEAR ACRYLIC MASONRY TREATMENT, 133
| |
|
CLP-200, PESTICIDES MATRIX SPIKING SOLUTION IN(SUPDAT)
| 67-56-1
309-00-2
58-89-9
50-29-3
60-57-1
72-20-8
76-44-8 |
|
HYLAC SILICONIZED POLISH, 82708
| 8032-32-4
64475-85-0
71-55-6
74-98-6
106-97-8 |
|
CITRUS LOTION HAND CLEANER W/PUMICE 1717, AB7A128
| |
|
8110 PART A
| |
|
US-101, BASE/NEUTRALS MIX #2 AT 2000 UG/ML IN(SUPDAT)
| 75-09-2
103-33-3
91-58-7
95-50-1
541-73-1
106-46-7
121-14-2
606-20-2
118-74-1
87-68-3
77-47-4
67-72-1
78-59-1
98-95-3
120-82-1 |
|
S-5 SUPER CLEAN
| |
|
HI-SPOT BLUE BASE 107, 83107
| |
|
HI-SPOT BLUE BASE 107, 83307
| |
|
HI-SPOT BLUE BASE 107, 83507
| |
|
CFR-1 CLEANER
| 67-64-1
67-63-0
106-97-8
74-98-6 |
|
2240, SILICA STANDARD, 10 PPM TO 1000 PPM (SUPDAT)
| 13517-24-3
7732-18-5 |
|
2239, SILICA STANDARD, 10 PPM TO 1000 PPM (SUPDAT)
| 13517-24-3
7732-18-5 |
|
GPU6, SILICA STANDARD, 10 PPM TO 1000 PPM (SUPDAT)
| 13517-24-3
7732-18-5 |
|
PRITT GLUE STICK
| |
|
BIO T BRAKE CLEANER
| |
|
TRIM SC 210
| |
|
PERMATEX GASKET REMOVER, 80646
| 75-09-2
67-63-0
1330-20-7
75-28-5
74-98-6
100-41-4
8052-41-3
9004-65-3
141-43-5
7732-18-5 |
|
AMPULE 4 (COLORLESS), HYDROCHLOR Q4000 (SUPP DATA)
| |
|
GUARDEX CHLORINATING CONCENTRATE FOR SPAS
| 2893-78-9 |
|
HYDROTECH GRANULAR CONCENTRATE
| 2893-78-9 |
|
SUPER BONDER 409 INDUST GRADE GEL INST ADH, 40945
| 7085-85-0
9011-14-7
112945-52-5
123-31-9 |
|
DURALUM DURATRED
| |
|
DURALUM NIAGARA BLAST
| |
|
DURALUM LT P&C
| |
|
DURALUM G82
| |
|
DURALUM G52E
| |
|
DURALUM RF D/C FINES
| |
|
DURALUM RF
| |
|
DURALUM POLISHING GRAINS & POWDERS
| |
|
DURALUM MICROGRITS
| |
|
FORMULA 909 DECK AND AIRCRAFT CLEANER
| |
|
POLYLITE 32-737-00, 32-737-00
| |
|
PHILLYBOND TA-30 HARDENER
| |
|
BOD NUTRIENT BUFFER PILLOWS, 14862
| 7758-11-4
7558-79-4
7487-88-9
10043-52-4
7778-77-0
12125-02-9
10025-77-1
7732-18-5 |
|
TAPMATIC DUAL ACTION AQUACUT CUTTING FLUID, 01216
| 107-21-1
67-63-0 |
|
ANTISTATIC SCREEN CLEANER, AX1261
| |
|
STM-380, INTERNAL STANDARD MIXTURE AT 2000 (SUPDAT)
| 67-56-1
460-00-4
3855-82-1 |
|
EVERLUBE 13-620 RTA (10-245)
| |
|
CC410EP EPOXY SKIDPROOFAR, PART A
| 25068-38-6
112-57-2
107-15-3
4067-16-7
7732-18-5
107-98-2
64-19-7
8052-41-3
104-78-9
111-76-2
57-55-6
108-65-6
13463-67-7
12001-26-2
1333-86-4 |
|
CC410EP EPOXY SKIDPROOFAR, PART B
| 25068-38-6
68609-97-2 |
|
4860A ACCELERATOR
| |
|
DIRECTIGEN INFLUENZA A, 0286616
| 71-36-3 |
|
PHILLYCLAD 1025 SAFETY YELLOW RESIN, 2725RC
| |
|
PHILLYCLAD 101 WHITE RESIN, 2701RC
| |
|
75-3465-8033-7, SCOTCHCAL BRAND SCREEN (SUPP DATA)
| 108-65-6
763-69-9
9011-14-7
9010-88-2
147-14-8
1317-65-3
80-62-6
108-88-3
140-88-5 |
|
SODIUM HYPOCHLORITE 10%+CL2, 11626
| 7681-52-9
1310-73-2 |
|
CLEANER/DEGREASER, 404-00-00001-0-001
| |
|
WELD-ON 2711 PVC PIPE CEMENT
| 9002-86-2
109-99-9
78-93-3
108-94-1
872-50-4 |
|
PS543
| 70900-21-9 |
|
|