non-hazardous ients volatile organic content: 0.00 lb/gl. supp data: occur at typical elevated-temps process cndtns, especially in ing 3: subjected to sudden ingress of air/outside process eqiup operating ing 4: of vapors/mists to atmosphere occurs. any proposed use of prod in ing 5: evaluated to assure that safe operating conditions are established
ITW FLUID PRODUCTS GROUP -- HI-SPOT BLUE BASE 107, 83507
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BXQQB
MSDS NAME: HI-SPOT BLUE BASE 107, 83507
Responsible Party
Name: ITW FLUID PRODUCTS GROUP
Address: 8501 DELPORT DRIVE
City: ST LOUIS MO 63114
Info Phone: 800-443-9536
Emergency Phone Number: 800-424-9300 (CHEMTREC)
Preparer's Name: JAMES A SEPER
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: ITW DYKEM/ DYMON
Address: 805 E OLD 56 HWY
City: OLATHE KS 66061
Phone: 800-443-9536
Name: ITW FLUID PRODUCTS GROUP
Address: 8501 DELPORT DRIVE
City: ST LOUIS MO 63114
Phone: 800-443-9536
=======================================================
Ingredients
=======================================================
Name: NON-HAZARDOUS INGREDIENTS
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
RTECS #: 9999999VO
Name: VOLATILE ORGANIC CONTENT: 0.00 LB/GL.
-----------------------------
Name: SUPP DATA: OCCUR AT TYPICAL ELEVATED-TEMPS PROCESS CNDTNS, ESPECIALLY IN
PROCESSES OPERATING UNDER VACUUM IF
-----------------------------
Name: ING 3: SUBJECTED TO SUDDEN INGRESS OF AIR/OUTSIDE PROCESS EQIUP OPERATING
UNDER ELEVATED PRESS IF SUDDEN ESCAPE
-----------------------------
Name: ING 4: OF VAPORS/MISTS TO ATMOSPHERE OCCURS. ANY PROPOSED USE OF PROD IN
ELEVATED-TEMP PROCESSES SHOULD BE THORO
-----------------------------
Name: ING 5: EVALUATED TO ASSURE THAT SAFE OPERATING CONDITIONS ARE ESTABLISHED
AND MAINTAINED.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: SLIGHT IRRITATION. CHRONIC: EFFECTS NOT KNOWN.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: INHAL: HIGH CONCENTRATIONS OF VAPORS MAY
PRODUCE IRRITATION OF THE RESPIRATORY TRACT, HEADACHE, DIZZINESS &
NAUSEA. SKIN/EYE: SLIGHT IRRITATION. SKIN(ABSORP): SLIGHT IRRITATION.
Medical Cond Aggravated By Exposure: SKIN DISORDERS.
First Aid: EYES: FLUSH WELL W/WATER FOR AT LEAST 15 MINUTES. SEE MD IF IRRIT
PERSISTS. SKIN: WASH W/SOAP & WATER. INHAL: NO EMERGENCY ANTICIPATED
UNDER NORMAL CONDITIONS. REMOVE TO FRESH AIR. SUPPORT BREATHING(G IVE
O*2/ARTF RESP)(F N). INGEST: DO NOTINDUCE VOMITING. CONTACT MD. IF VOMITING
OCCURS, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUIDS INTO LUNGS.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PREVENT SKIN & EYE CONTACT. USE NON-COMBUSTIBLE
MATERIAL TO CONFINE &/ABSORB. ELIMINATE IGNITION SOURCES. VENTILATE AREA.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: REMOVE TO WASTE DISPOSAL FACILITY OPERATING IN
COMPLIANCE WITH W/LOCAL, STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: IF MISTS ARE GENERATED IN USE OF PROD; THEN
FOLLOWING VALUES FOR PETROLEUM OILS APPLY. TLV/TWA: 5 MG/M3/8HR; PEL/TWA: 5
MG/M3/8HR; TLV/STEL: 10 MG/M3.
Other Precautions: 'EMPTY' CNTNRS RETAIN RESIDUE (LIQ &/VAP) & CAN BE
DANGEROUS. DO NOT PRESS, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOSE SUCH
CNTNRS TO HEAT, SPARKS, FLAMES, STATIC ELEC/OTHER SOURCES OF IGNIT. WARNI NG!
MANY HOT ORGANIC CHEMICAL (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 300F,149C
Extinguishing Media: CO*2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT(FP N).
Unusual Fire/Explosion Hazard: NONE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQUIRED UNDER NORMAL HANDLING TEMPERATURS. USE
NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN(FP N).
Ventilation: LOCAL EXHST IS RECOMM FOR CONFINED AREAS. GENL MECHANICAL VENT IS
ADEQUATE FOR NORMAL USE.
Protective Gloves: CHEM RESIST RUBBER/PVC COATED GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGS(FP N).
Other Protective Equipment: EYE BATH & SAFETY SHOWER. PROTECTIVE GEAR AS NEEDED
TO MINIMIZE SKIN CONTACT.
Work Hygienic Practices: FOLLOW CURRENT REGULATIONS.
Supplemental Safety and Health: OTHER PREC: VAPS/MISTS ARE SUSCEPTIBLE TO
SUDDEN SPONT COMBUST WHEN MIXED W/AIR. IGNIT MAY OCCUR AT TEMPS BELOW THOSE
PUBLISHED IN LITERATURE AS "AUTOIGNITION"/"IGNITION" TEMPS. IGNIT TEMPS
DECREASE W /INCREASING VAP VOL & VAP VOL & VAP/AIRCONT TIME & ARE
INFLUENCED BY PRESS CHANGES. IGNIT OF ORG CHEM VAPS MAY
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V1
Vapor Density: >1
Spec Gravity: 0.95 (H*2O=1)
Solubility in Water: INSOLUBLE
Appearance and Odor: BLUE OPAQUE PASTE LIKE SOLID W/PETROLEUM OIL ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: OXIDES OF CARBON.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: HI-SPOT BLUE BASE 107, 83507
Company: ITW FLUID PRODUCTS GROUP
Street: 8501 DELPORT DRIVE
City: ST LOUIS MO
Zipcode: 63114
Health Emergency Phone: 800-424-9300 (CHEMTREC)
Label Required IND: Y
Date Of Label Review: 05/10/1995
Status Code: C
Label Date: 05/10/1995
Origination Code: G
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: SLIGHT IRRITATION. INHAL: HIGH
CONCENTRATIONS OF VAPORS MAY PRODUCE IRRITATION OF THE RESPIRATORY TRACT,
HEADACHE, DIZZINESS & NAUSEA. SKIN/EYE: SLIGHT IRRITATION. SKIN(ABSORB):
SL IGHT IRRITATION. CHRONIC: NONE LISTED BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.