ITW DEVCON -- 5-MINUTE EPOXY HARDENER, 14210
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CDVCJ
MSDS NAME: 5-MINUTE EPOXY HARDENER, 14210
Responsible Party
Name: ITW DEVCON
Address: 30 ENDICOTT ST
City: DANVERS MA 01923
Info Phone: 508-777-1100
Emergency Phone Number: 800-424-9300(CHEMTREC)
Proprietary Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DEVCON CORP
Address: 30 ENDICOTT ST
City: DANVERS MA 01923-3753
Phone: 1-508-777-1100
Name: ITW DEVCON
Address: 30 ENDICOTT ST
City: DANVERS MA 01923-3712
Phone: 978-777-1100
=======================================================
Ingredients
=======================================================
Name: *** PROPRIETARY ***
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: SEE INGREDIENT 1.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:SKIN:CAN CAUSE SEVERE IRRITATION, ESPECIALLY ON
PROLONGED CONTACT (EVIDENCED BY ITCHING, REDNESS, BURNING SENSATION).
POTENTIAL SENSITIZER. EYES:CAUSES SEVERE IRRITATION WITH POSSIBLE PERMANENT
DAMAGE AND EVEN BLINDNESS. INHALATION:CONSIDERED SLIGHTLY TOXIC. CAN CAUSE
IRRITATION OF RESPIRATORY (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:TRACT. OVEREXP TO FUMES/VAPS MAY
CAUSE DELAYED LUNG INJURY & CHEM PNEUMONIA. INGEST:SLIGHTLY TOXIC. MAY
CAUSE FATIGUE, MUSCLE WEAKNESS, GI IRRIT, NAUSEA, VOMITING & DIARRHEA.
CHRONIC:PRLNG/SE V OVEREXP TO DMP VAP CAN CAUSE DELAYED LUNG DMG & CHEM
PNEUM. PRLNG/RPTD CONT W/THIS MATL MAY CAUSE SKIN SENSIT.
Medical Cond Aggravated By Exposure: MAY AGGRAVATE EXISTING SKIN, EYE &
LUNG CONDITIONS.
First Aid: EYES:FLUSH W/CLEAN WATER FOR AT LST 15 MINS WHILE GENTLY HOLDING
EYELIDS OPEN. GET IMMEDIATE MED ATTN. SKIN:REMOVE CONTAM CLTHG & SHOES.
WASH THORO W/SOAP & WARM WATER. CONSULT MD IF IRRIT DEVELOPS. I
NHAL:REMOVE PATIENT TO FRESH AIR. PROVIDE OXYGEN IF BREATHING IS DIFFICULT.
CONSULT MD IF SYMPTOMS PERSIST. INGEST:DO NOT INDUCE VOMIT. GIVE LG AMTS OF
WATER FOLLOWED BY MILK IF AVAIL. CONSULT MD.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID PERSONAL CONT. ELIM IGNIT SOURCES. VENT AREA.
DIKE, CONTAIN & ABSORB W/CLAY, SAND/OTHER SUITABLE MATL. FOR LG SPILLS,
PUMP TO STOR/SALVAGE VESSELS. SOAK UP RESIDUE W/ABSORB SUCH AS CLAY, SAND/OT
HER SUITABLE MATL & DISP OF PROPERLY. FLUSH AREA W/WATER TO REMOVE TRACE
RESIDUE. PREVENT SPILL FROM ENTERING DRAINAGE/SEWER SYS, WATERWAYS & SURF
WATERS.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: IF THIS MATERIAL BECOMES A WASTE, IT WOULD NOT BE A
HAZARDOUS WASTE BY RCRA CRITERIA (40 CFR 261). DISPOSE OF ACCORDING TO
APPLICABLE FEDERAL, STATE & LOCAL REGULATIONS.
Handling And Storage Precautions: AVOID CONT W/SKIN, EYES/CLTHG. STORE IN COOL,
DRY AREA AWAY FROM HIGH TEMPS & FLAMES. AVOID BRTHG VAPS. DO NOT TAKE
INTERNALLY. USE W/ADEQ VENT.
Other Precautions: HANDLE MIXED RESIN & HARDENER I/A/W POTNTL HAZ OF CURING
AGENT USED. PROVIDE APPROP VENT/NIOSH APPRVD RESP PROT AGAINST DECOMP PRODS
DURING WELDING/FLAME CUTTING OPERATIONS & TO PROT AGAINST NUISANCE DUST
DURING SANDING/GRINDING OF CURED PROD.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: >200F,>93C
Extinguishing Media: WATER, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). COOL CONTAINERS W/WATER SPRAY.
Unusual Fire/Explosion Hazard: TOXIC SMOKE & VAPORS MAY FORM DURING
COMBUSTION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NEEDED IN NORMAL USE W/PROPER VENTILATION. IN
POORLY VENTILATED AREAS OR WHEN CREATING A DUST OR MIST, USE A NIOSH APPROVED
ORGANIC VAPOR RESPIRATOR.
Ventilation: GENERAL MECHANICAL VENTILATION IS ADEQUATE FOR OCCASIONAL USE. FOR
PROLONGED OR REPEATED USE, LOCAL EXHAUST IS REC.
Protective Gloves: CHEM-RESIST RUBBER GLOVES (NEOPRENE, BUTYL RUBBER/NITRILE).
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH FOUNTAIN & DELUGE SHOWER (FP
N). OTHER PROTECTIVE GEAR AS NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices: WASH THORO W/SOAP & WATER AFTER USING & PARTICULARLY
BEFORE EATING, DRINKING, SMOKING, APPLYING COSMETICS/USING TOILET FACILITIES.
LAUNDER CONTAM CLOTHING & PROT GEAR BEFORE REUSE. DISCARD (SUPDAT)
Supplemental Safety and Health: NOTE:USERS OF "L" VERSION SHOULD CONSULT "LR"
VERSION FOR ADDITIONAL INFORMATION (FP N). PH (5% SOLUTION/SLURRY IN WATER):
0.5. HYGIENE PRACTICES: CONTAMINATED LEATHER ARTICLES.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: <1
Spec Gravity: 1.13
PH: SUPDAT
Solubility in Water: NEGLIGIBLE
Appearance and Odor: VISCOUS, AMBER LIQUID W/MERCAPTAN ODOR.
Percent Volatiles by Volume: 0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: OPEN FLAME & EXTREME HEAT.
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: OXIDES OF CARBON, OXIDES OF SULFUR, OXIDES OF
NITROGEN.
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: WHEN THIS HARDENER IS MIXED W/EPOXY RESIN
HEAT IS GENERATED; BE CAREFUL WHEN MIXING MORE THAN AN OUNCE OR SO.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUND:0 G/L
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 5-MINUTE EPOXY HARDENER, 14210
Company: ITW DEVCON
Street: 30 ENDICOTT ST
City: DANVERS MA
Zipcode: 01923-3712
Health Emergency Phone: 800-424-9300(CHEMTREC)
Label Required IND: Y
Date Of Label Review: 05/22/1997
Status Code: C
Label Date: 05/22/1997
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Severe
Fire Hazard: Slight
Reactivity Hazard: Slight
Hazard And Precautions: SEVERE IRRIT. ACUTE:SKIN:CAN CAUSE SEVERE IRRITATION,
ESPECIALLY ON PROLONGED CONTACT (EVIDENCED BY ITCHING, REDNESS, BURNING
SENSATION). POTENTIAL SENSITIZER. EYES:CAUSES SEVERE IRRITATION W/POSSIBLE
PERMANENT DAMAGE & EVEN BLINDNESS. INHAL:CONSIDERED SLIGHTLY TOXIC. CAN
CAUSE IRRITATION OF RESPIRATORY TRACT. OVEREXP TO FUMES/VAPORS MAY CAUSE
DELAYED LUNG INJURY & CHEMICAL PNEUMONITIS. INGEST:SLI GHTLY TOXIC. MAY
CAUSE FATIGUE, MUSCLE WEAKNESS, GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING
& DIARRHEA. CHRONIC:PRLNG/RPTD OVEREXP TO DMP VAPOR CAN CAUSE DELAYED
LUNG DAMAGE & CHEMICAL PNEUMONIA. P RLNG/RPTD CONT W/THIS MATL MAY CAUSE
SKIN SENSIT.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|