methacrylic acid, polymer with ethylene; (ethylene metacrylic acid red pigment zinc stearate; (zinc compound) supp data:gases assoc w/poorly ventilated combustion. carbon monoxide ing 4:organic acids, aldehydes & alcohols. first aid proc:lids. seek med attn if irrit occurs. skin:flush all ing 6:mins. remove & clean any contam clthg & shoes. seek med ing 7:seek medical attention if respiratory irritation occurs or if
PFS THERMOPLASTIC POWDER COATI -- POLYARMOR HIGH FLOW, S101 SAFETY RED
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CHXYC
MSDS NAME: POLYARMOR HIGH FLOW, S101 SAFETY RED
Responsible Party
Name: PFS THERMOPLASTIC POWDER COATING
Address: 3400 WEST 7TH ST
City: BIG SPRING TX 79720
Info Phone: 915-263-5263
Emergency Phone Number: 800-753-5263
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: PLASTIC FLAMECOAT(R) SYSTEMS, INC.
Address: 3400 WEST 7TH
City: BIG SPRING TX 79720
Phone: 800-753-5263
=======================================================
Ingredients
=======================================================
Cas: 25053-53-6
Name: METHACRYLIC ACID, POLYMER WITH ETHYLENE; (ETHYLENE METACRYLIC ACID
COPOLYMER)
% Wt: 0-100
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: RED PIGMENT
% Wt: 0-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 557-05-1
RTECS #: ZH5200000
Name: ZINC STEARATE; (ZINC COMPOUND)
% Wt: 0.30
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: N/K (FP N)
------------------------------
Name: SUPP DATA:GASES ASSOC W/POORLY VENTILATED COMBUSTION. CARBON MONOXIDE
& HYDROCARBON OXIDATION PRODUCTS INCLUDING
-----------------------------
Name: ING 4:ORGANIC ACIDS, ALDEHYDES & ALCOHOLS.
-----------------------------
Name: FIRST AID PROC:LIDS. SEEK MED ATTN IF IRRIT OCCURS. SKIN:FLUSH ALL
AFFECTED AREAS W/PLENTY OF WATER FOR SEVERAL
-----------------------------
Name: ING 6:MINS. REMOVE & CLEAN ANY CONTAM CLTHG & SHOES. SEEK MED
ATTN IF IRRIT OCCURS. INHAL:REMOVE TO FRESH AIR.
-----------------------------
Name: ING 7:SEEK MEDICAL ATTENTION IF RESPIRATORY IRRITATION OCCURS OR IF
BREATHING BECOMES DIFFICULT.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL:MAY CAUSE IRRIT TO UPPER RESP TRACT. SKIN:MAY CAUSE
IRRIT & ALLERGIC RXN. INGEST:NOT LIKELY. MAY CAUSE IRRIT TO GI TRACT.
EYES:MAY CAUSE IRRIT. NUISANCE DUSTS ARE NOT EXPECTED TO CAUSE SIGNIFICA NT
ORG DISEASE/TOX EFTS WHEN EXPOS ARE CONTROLLED TO LIMS STATED. ACGIH SUGGESTS
THAT EXCESS CONCS OF (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:NUISANCE PARTICULATES IN
WORKPLACE "MAY SERIOUSLY REDUCE VISIBILITY, MAY CAUSE UNPLEASANT DEPOSITS IN
EYES & NASAL PASSAGES/CAUSE INJURY TO SKIN/MUC MEMBS BY CHEM/MECH ACTION
PER SE/BY RIGORO US SKIN CLEANSING PROCS NEC FOR THEIR REMOVAL," MFR SUGGESTS
PEL (OSHA) EXPOS LIMS OF 15 MG/M3, 8 HR TWA, TDUST;(SUPDAT)
Medical Cond Aggravated By Exposure: NO MEDICAL CONDITIONS ARE GENERALLY KNOWN
TO BE AGGRAVATED BY EXPOSURE.
First Aid: IF ADVERSE RXN OCCURS AFTER EXPOS, PROMPTLY START REC PROCS. SEEK
MED ATTN IF FURTHER TREATMENT IS REQD. INGEST:IF LG AMT OF THIS MATL IS
SWALLOWED, GIVE SEVERAL GLASSES OF WATER. CONT MED PERS FOR FU RTHER
ASSISTANCE. IF UNCON/CONVULSING, DO NOT GIVE ANYTHING BY MOUTH. EYES:FLUSH
W/PLENTY OF RUNNING WATER FOR AT LST 15 MINS. HOLD LIDS APART DURING FLUSHING
TO ENSURE RINSING OF ENTIRE EYE &
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NOTE:REVIEW FIREFIGHTING MEASURES & HANDLING
(PERSONNEL) SECTIONS BEFORE PROCEEDING W/CLEANUP, USE APPROPRIATE PERSONAL
PROTECTIVE EQUIPMENT DURING CLEANUP. SWEEP UP TO AVOID SLIPPING HAZARD.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: PREF OPTIONS FOR DISP ARE (1)RECYCLING, (2)INCIN
W/ENERGY RECOVERY & (3)LANDFILL. HIGH FUEL VALUE OF THIS PROD MAKES
OPTION 2 VERY DESIRABLE FOR MATL THAT CANNOT BE RECYCLED. TREATMENT, STORAGE,
TRANS PORTATION & DISP MUST BE I/A/W APPLIC FED,(SUPDAT)
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE. KEEP CONTAINERS
CLOSED TO PREVENT CONTAMINATION & ACCUMULATION OF MOISTURE.
Other Precautions: ECOLOGICAL INFO:TOXICITY IS EXPECTED TO LOW BASED ON
NEGLIGIBLE WATER SOLUBILITY.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Lower Limits: 30 GMS/CM
Extinguishing Media: WATER, FOAM, CARBON DIOXIDE, DRY CHEMICALS.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). PRODUCTS OF COMBUSTION MAY BE TOXIC; AVOID BREATHING FUMES.
COOL FIRE-EXPOSED CONTAINERS W/WATER.
Unusual Fire/Explosion Hazard: DUST CAN FORM AN EXPLOSIVE MIXTURE W/AIR.
ELIMINATION OF SOURCES OF IGNITION IS ESSENTIAL.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE A NIOSH APPROVED RESPIRATOR EQUIPPED W/APPROPRIATE
FILTER FOR PARTICULATE DUST EXPOSURE.
Ventilation: LOCAL VENTILATION SHOULD BE USED OVER PROCESSING EQUIPMENT.
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS (FP N).
Other Protective Equipment: ANSI APPRVD EYE WASH FOUNTAIN & DELUGE SHOWER (FP
N). LONG SLEEVE COTTON SHIRT & LONG PANTS ARE REC TO PVNT SKIN(SUPDAT)
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: EFTS OF OVEREXP:5 MG/M3, 8 HR TWA RESPIRABLE
DUST. WASTE DISP METH:STATE, PROVINCIAL & LOC REGS. OTHER PROT EQUIP:CONT
W/HOT MOLTEN POLYMER. HAZ DECOMP PROD:EXPECTED PRODS OF COMBUST IN PRESENCE
OF LG AMTS OF AIR. PRODS OF POORLY VENTED COMBUST ARE UNCHARACT MIXT OF ORG
CMPDS. MIXT WILL BE AS HAZ AS NORMAL FIRE
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: >176F,>80C
Spec Gravity: >0.03
Solubility in Water: NEGLIGIBLE
Appearance and Odor: FINELY DIVIDED POWDER, SAFETY RED COLOR; MILD METHACRYLIC
ACID ODOR.
Percent Volatiles by Volume: NEGLIG
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: TEMPERATURES ABOVE 325C (617F).
Materials To Avoid: STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MATLS ARE NORMALLY STABLE & DECOMPOSE ONLY IN
EXTREME CASES SUCH AS FIRE. OXIDES OF NITROGEN & CARBON ARE THE (SUPDAT)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: POLYARMOR HIGH FLOW, S101 SAFETY RED
Company: PLASTIC FLAMECOAT(R) SYSTEMS, INC.
Street: 3400 WEST 7TH
City: BIG SPRING TX
Zipcode: 79720
Health Emergency Phone: 800-753-5263
Label Required IND: Y
Date Of Label Review: 10/26/1998
Status Code: C
Label Date: 10/26/1998
Origination
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:INHALATION:MAY CAUSE IRRITATION TO UPPER
RESPIRATORY TRACT. SKIN:MAY CAUSE IRRITATION AND ALLERGIC REACTION.
INGESTION:NOT LIKELY. MAY CAUSE IRRITATION TO GASTROINTESTINAL TRACT.
EYES:MAY CAUSE IRRITATION. NUISANCE DUSTS ARE NOT EXPECTED TO CAUSE
SIGNIFICANT ORGANIC DISEASE OR TOXIC EFFECTS WHEN EXPOSURES ARE CONTROLLED TO
LIMITS STATED. CHRONIC:NONE LISTED BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.