=====================  Product Identification  =====================

MSDS NAME:SOL ZP (ZIPPO LIGHTER FLUID), 84157
NIIN:00N073571
MSDS Number: CCNWV
=== Responsible Party ===
Company:SHELL OIL CO
Box:4320
City:HOUSTON
State:TX
ZIP:77210
Country:US
Info Phone Num:713-241-4819
Emergency Phone Num:713-473-9461;800-424-9300(CHEMTREC)
Preparer's Name:JC WILLET
CAGE:SHELO
=== Contractor Identification ===
Company:SHELL OIL CO
Box:4320
City:HOUSTON
State:TX
ZIP:77210-5000
Country:US
Phone:713-473-9461/713-241-2252
CAGE:SHELO
Company:SHELL OIL COMPANY
Address:Box:2463
City:HOUSTON
State:TX
ZIP:77210
Country:US
Phone:800-231-6950
CAGE:54527

=============  Composition/Information on Ingredients  =============

Name:VM & P NAPHTHA; (SHELL SOL ZP)
CAS:64742-89-8
Fraction by Wt: 100%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Name:BENZENE (SARA 313) (CERCLA) (< 30 PPM)
CAS:71-43-2
RTECS #:CY1400000
Fraction by Wt: TRACE
OSHA PEL:SEE 1910.1028
ACGIH TLV:10 PPM; A2
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS

Name:VOLATILE ORGANIC CONTENT: 100% @ 6.13 LB/GAL @ 77F
RTECS #:9999999VO
OSHA PEL:N/K 
ACGIH TLV:N/K 

Name:SUP DAT: HIGH VAP CONCS OF SOLVS SIMILAR TO THIS PROD
    SHOWED EVIDENCE OF KIDNEY DMG. THE RELEVANCE OF THIS INFO (ING 5)
RTECS #:9999999ZZ

Name:ING 4: TO MAN IS UNKNOWN. IN ONE STUDY ON A SOLV SIMILAR TO
    THIS PROD, A LOW GRADE ANEMIA WAS ALSO OBSERVED.
RTECS #:9999999ZZ

Name:FIRST AID PROC: IF VOMIT OCCURS SPONT, KEEP HEAD BELOW HIPS
    TO PVNT ASPIR OF LIQ INTO LUNGS. GET MED ATTN. (ING 7)
RTECS #:9999999ZZ

Name:ING 6: NOTE TO MD: IF MORE THAN 2.0 ML/KG HAS BEEN INGESTED
    & VOMIT HAS NOT OCCURRED, EMESIS SHOULD BE INDUCED (ING 8)
RTECS #:9999999ZZ

Name:ING 7: W/SUPERVISION. KEEP VICTIM'S HEAD BELOW HIPS TO PVNT
    ASPIR. IF SYMPS SUCH AS LOSS OF GAG REFLEX, CONVLS/ (ING 9)
RTECS #:9999999ZZ

Name:ING 8: UNCON OCCUR BEFORE EMESIS, GASTRIC LAVAGE USING A
    CUFFED ENDOTRACHEAL TUBE SHOULD BE CONSIDERED.
RTECS #:9999999ZZ

Name:SPILL PROC: IF VAP CLOUD FORMS, WATER FOG MAY BE USED TO
    SUPPRESS; CONTAIN RUN-OFF. REMOVE W/VACUUM TRUCKS/PUMP (ING 11)
RTECS #:9999999ZZ

Name:ING 10: TO STOR/SALVAGE VESSELS. SOAK UP RESIDUE W/ABSORB
    SUCH AS CLAY, SAND/OTHER SUITABLE MATL; PLACE IN NON- (ING 12)
RTECS #:9999999ZZ

Name:ING 11: LEAKING CONTRS FOR PROPER DISP. FLUSH AREA W/WATER
    TO REMOVE TRACE RESIDUE; DISP OF FLUSH SOLNS AS (ING 13)
RTECS #:9999999ZZ

Name:ING 12: ABOVE. SML SPILLS: TAKE UP W/ABSORB MATL & PLACE IN
    NON-LEAKING CONTRS; SEAL TIGHTLY FOR PROPER DISPOSAL.
RTECS #:9999999ZZ

Name:OTHER PREC: USE W/ADEQ VENT. CONTRS, EVEN THOSE THAT HAVE
    BEEN EMPTIED, CAN CONTAIN EXPLO VAPS. DO NOT CUT, (ING 15)
RTECS #:9999999ZZ

Name:ING 14: DRILL, GRIND, WELD/PERFORM SIMILAR OPERATIONS
    ON/NEAR CONTRS. DO NOT PRESSURIZE DRUM CONTRS TO EMPTY (ING 16)
RTECS #:9999999ZZ

Name:ING 15: THEM. STATIC ELEC MAY ACCUM & CREATE FIRE HAZ.
    GROUND FIXED EQUIP. BOND & GROUND TRANSFER CONTRS & (ING 17)
RTECS #:9999999ZZ

Name:ING 16: EQUIP. AVOID CONTACT WITH EYES. AVOID PROLONGED OR
    REPEATED CONTACT WITH SKIN.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:LD50 (ORAL RAT): > 8 ML/KG.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: LIQ IS MILDLY IRRIT TO
    EYES. HIGH VAP CONCS MAY BE IRRIT. SKIN: LIQ IS MILDY IRRIT TO
    SKIN. PRLNG/RPTD LIQ CONT CAN RSLT IN DEFAT & DRYING OF SKIN WHICH
    MAY RSLT IN SKIN IRRIT & DERM. INH AL: VAPS MAY BE IRRIT TO NOSE,
    THROAT &RESP TRACT. HIGH VAP CONCS MAY PRDCE CNS DEPRESS. INGEST:
    (EFTS OF OVEREXPOSURE)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: INGEST OF PROD MAY RSLT IN VOMIT;
    ASPIR (BRTHG) OF VOMITUS INTO LUNGS MUST BE AVOIDED AS EVEN SML
    QTYS MAY RSLT IN ASPIR PNEUMIT. SIGNS & SYMPS: IRRIT AS NOTED
    ABOVE. EARLY TO MOD CNS DEPRES S MAY BE EVIDENCED BY GIDD, HDCH,
    DIZZ & NAUS; IN EXTREME CASES, UNCON & DEATH MAY OCCUR. ASPIR
    PNEUMIT MAY BE (SUP DAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
    RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
    PRODUCT.

=======================  First Aid Measures  =======================

First Aid:EYE: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MIN WHILE
    HOLDING EYELIDS OPEN. GET MED ATTN. SKIN: REMOVE CONTAM
    CLTHG/SHOES. FLUSH SKIN W/WATER. FOLLOW BY WASHING W/SOAP & WATER.
    IF IRRIT OCCURS, GET M ED ATTN. DO NOT REUSE CLTHG UNTIL CLEANED.
    INHAL: REMOVE VICTIM TO FRESH AIR & PROVIDE OXYGEN IF BRTHG IS
    DFCLT. GIVE ARTF RESP IF NOT BRTHG. GET MED ATTN. INGEST: DO NOT
    INDUCE VOMIT. (ING 6)

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:39.0F,3.9C
Lower Limits:1.0%
Upper Limits:7.0%
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEM/CARBON DIOXIDE. DO
    NOT USE DIRECT STREAM OF WATER. PROD WILL FLOAT & CAN BE (SUP DAT)
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
    WARNING. FLAMM. CLEAR FIRE AREA OF UNPROTECTED PERS. COOL
    FIRE-EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:CONTRS EXPOSED TO INTENSE HEAT FROM FIRES
    SHOULD BE COOLED W/WATER TO PVNT VAP PRESS BUILDUP WHICH COULD RSLT
    IN CONTR RUPTURE. CONTR AREAS EXPOSED TO (SUP DAT)

==================  Accidental Release Measures  ==================

Spill Release Procedures:WARNING. FLAMM. ELIM ALL IGNIT SOURCES. HNDLG
    EQUIP MUST BE GROUNDED TO PVNT SPK. LGE SPILLS: EVACUATE HAZ AREA
    OF UNPROTECTED PERS. WEAR APPROP NIOSH APPRVD RESP & PROT CLTHG.
    SHUT OFF SOURCE OF LEAK  ONLY IF SAFE TO DO SO. DIKE & CONTAIN.(ING
    10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP LIQ & VAP AWAY FROM HEAT, SPKS &
    FLAME. SURF THAT ARE SUFFICIENTLY HOT MAY IGNITE EVEN LIQ PROD IN
    ABSENCE OF SPKS/FLAME.
Other Precautions:EXTING PILOT LIGHTS, CIGARETTES & TURN OFF OTHER
    SOURCES OF IGNIT PRIOR TO USE & UNTIL ALL VAPS ARE GONE. VAPS MAY
    ACCUM & TRAVEL TO IGNIT SOURCES DISTANT FROM HNDLG SITE; FLASH-FIRE
    CAN RSLT. KEEP CO NTRS CLSD WHEN NOT IN USE. (ING 14)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:AVOID PROLONGED/REPEATED BREATHING OF VAPORS. IF
    EXPOSURE MAY/DOES EXCEED OCCUP EXPOS LIM USE A NIOSH APPRVD RESP TO
    PVNT OVEREXP. I/A/W 29 CFR 1910.134 USE EITHER AN ATM-SUPPLYING
    RESP/AN AIR-PURIFYI NG RESP FOR ORGANIC VAPORS.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
    VAPOR CONCENTRATIONS.
Protective Gloves:CHEMICAL-RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:EMERGENCY EYEWASH & DELUGE SHOWER MEETING
    ANSI DESIGN CRITERIA . CHEMICAL-RESISTANT CLOTHING TO MINIMIZE
    CONTACT.
Work Hygienic Practices:AIR-DRY CONTAMINATED CLOTHING IN A
    WELL-VENTILATED AREA, THEN LAUNDER BEFORE REUSING.
Supplemental Safety and Health
EXTING MEDIA: REIGNITED ON SURF OF WATER. EXPLO HAZ: DIRECT FLAME CONT
    SHOULD BE COOLED W/LGE QTYS OF WATER AS NEEDED TO PVNT WEAKENING OF
    CONTR STRUCTURE. EFTS OF OVEREXP: EVIDENCED BY COUGHING, LABO RED
    BRTHG & CYANOSIS (BLUISH SKIN); IN SEV CASES DEATH MAY OCCUR. MALE
    RATS EXPOSED BY PRLNG & RPTD INHAL TO (ING 4)

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:>224F,>107C
Vapor Pres:41 @ 100F
Vapor Density:4.0
Spec Gravity:0.744 (H*2O=1)
Evaporation Rate & Reference:2.5 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:COLORLESS LIQUID, WITH HYDROCARBON ODOR

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, SPARKS, FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
    ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
    FEDERAL REGULATIONS .

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***