===================== Product Identification =====================
MSDS NAME:CRS-2, ASPHALT EMULSION ANIONIC/CATIONIC (SUPDAT)
NIIN:00N011355
MSDS Number: CFNNM
=== Responsible Party ===
Company:REED & GRAHAM INC
Address:690 SUNOL STREET
City:SAN JOSE
State:CA
ZIP:95126
Country:US
Info Phone Num:408-287-1400
Emergency Phone Num:408-287-1400
CAGE:5W738
=== Contractor Identification ===
Company:REED & GRAHAM, INC
Address:690 SUNOL ST
Box:City:SAN JOSE
State:CA
ZIP:95126
Country:US
Phone:408-287-1400
CAGE:5W738
============= Composition/Information on Ingredients =============
Name:ING 4:PNEUMONITIS, & ABSCESS FORMATION. ASPHALT FUME
CONDENSATES HAVE BEEN SHOWN TO PRDCE TUMOROGENIC RESPONSE (ING 6)
RTECS #:9999999ZZ
Name:ING 5:WHEN REPEATEDLY APPLIED TO SKIN OF EXPERIMENTAL
ANIMALS. REVELANCE OF DATA TO HUMANS IS NOT KNOWN AT THIS TIME.
RTECS #:9999999ZZ
Name:ASPHALT (PETROLEUM)
CAS:8052-42-4
RTECS #:CI9900000
Fraction by Wt: 25-69%
OSHA PEL:N/K
ACGIH TLV:5 MG/M3; (FUME)
Name:SUPDAT:AS MAY OCCUR W/ROAD WORK, CAN INCR SENSITIVITY TO
SUNBURN. LAUNDER CONTAMD CLTHG. OBSERVE GOOD PERSONAL (ING 3)
RTECS #:9999999ZZ
Name:ING 2:HYGIENE. WASH THOROUGHLY AFTER WORKING W/ASPHALT &
BEFORE EATING. BRTHG ASPHALT AEROSOL/ASPHALT SMOKE (ING 4)
RTECS #:9999999ZZ
Name:ING 3:FOR PROTRACTED PERIODS OF TIME HAS PRODUCED DMG TO
LUNGS OF MICE. AMONG CHANGES OBSERVED WERE BRONCHITIS, (ING 5)
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: IRRITATION. SKIN: MILD
IRRITATION. REPEATED CONTACT CAN CAUSE DERMATITIS. INHALATION:
RESPIRATORY IRRITATION, NAUSEA, DIZZINESS, HEADACHE. INGESTION:
STOMACH IRRITATION, NAUSEA, AND VOMIT ING.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
Eyes: FLUSH W/LG AMTS OF WATER WHILE HOLDING EYELIDS OPEN FOR
AT LST 15 MINS. GET MED ATTN IF CNDTN PERSISTS. SKIN: WASH W/SOAP &
WATER OR USE WATERLESS HANDCLEANER. INHAL: REMOVE TO FRESH AIR. IF
BRT HG IS DFCLT, GIVE OXYG; IF BRTHG HAS STOPPED, GIVE ARTF RESP.
GET MED ATTN. INGEST: IF VICTIM IS CONSCIOUS, GIVE LIQUIDS. CALL
PHYSICIAN.
===================== Fire Fighting Measures =====================
Flash Point Method:CC
Flash Point:NONE
Extinguishing Media:DRY CHEMICAL, WATER FOG, FOAM CO*2.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:MAY FOAM IF HEATED TO 212F OR IF MIXED
WITH MATERIALS IN EXCESS OF 212F.
================== Accidental Release Measures ==================
Spill Release Procedures:CONTAIN SPILL IMMEDIATELY IN SMALLEST AREA
POSSIBLE. RECOVER AS MUCH OF PRODUCT AS POSSIBLE. RESIDUAL FLUID
SHOULD BE SOAKED UP BY USE OF AN ABSORB MATERIAL. SWEEP UP &
DISPOSE OF IN ACCORDANCE WITH F EDERAL, STATE, AND LOCAL
REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE >180F/USE HEATING SURF
>200F @ SEA LEVEL. SKIN CONT SHOULD BE MINIMIZED.
Other Precautions:REFER TO FOLLOWING PUBLICATION ENTITLED "SAFE STORAGE
& HANDLING OF HOT ASPHALT", THE ASPHALT INSTITUTE, INFO SERIES NO.
180, AUGUST 1981. WHEN ASPHALT PRODS ARE HEATED, THEY OFTEN GIVE
OFF SM AMTS OF HYDROGEN SULFIDE. HYDROGEN (SUPDAT)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NONE REQUIRED FOR NORMAL CONDITIONS OF USE. IF
OPERATING CONDITIONS CAUSE HIGH VAPOR CONCENTRATIONS OR TLV IS
EXCEEDED, USE SUPPLIED AIR RESPIRATOR APPROVED BY NIOSH.
Ventilation:NORMAL VENT UNLESS VAPORS ARE HIGH, THEN MECHANICAL
VENTILATION SHOULD BE USED.
Protective Gloves:IMPERVIOUS GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
COMPLETE PROTECTIVE CLOTHING IF MATL IS BEING HANDLED HOT.
Work Hygienic Practices:CLEAN EXPOSED SKIN W/SOAP & WATER/WATERLESS
HAND CLEANER. LAUNDER/DISCARD CONTAMD CLTHG. DISCARD CONTAMD
LEATHER MATL.
Supplemental Safety and Health
MFR TRADE NAME/PART NO:EMULSIONS. SPEC GRAV:SLIGHTLY >1 (WATER =1).
OTHER PREC:SULFIDE IS EXTREMELY FLAMM, HIGHLY TOX GAS. BRTHG
HYDROGEN SULFIDE MUST BE AVOIDED. MINIMIZE BRTHG OF VAPS,
FUMES/MIST; W HEN POSS, USE VENT/WORK UPWIND OF SOURCE OF VAPS,
FUMES/MIST. EXPOSING SKIN TO ASPHALT FUMES, MIST/VAPS, (ING 2)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Spec Gravity:SUPDAT
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:DILUTES WITH WATER
Appearance and Odor:BROWN TO BLACK LIQUID OR SEMISOLID.
Percent Volatiles by Volume:>1
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:HEAT, FLAME OR SPARK. DO NOT HEAT TO
BOILING POINT - 212F.
Hazardous Decomposition Products:HAZARDOUS GASES/VAPS PRDCED ARE CO*2,
CO, SULFUR DIOXIDE, ALDEHYDES, AND OTHER UNIDENTIFIED CMPDS MAY
FORM UPON COMBUST.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE AS MUCH OF RECOVERABLE PROD AS POSS.
DISPOSE OF NONRECYCLABLE MATL BY SUCH METHS AS CONTROLLED
INCIN/BLENDING W/AGGREGATE & USED FOR PATCHING & OTHER MAINTENANCE
USE. DISPOSAL MUST BE I/A/W FE DERAL, STATE & LOCAL REGULATIONS .
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|