===================== Product Identification =====================
MSDS NAME:AEROSOL, HIGH SOLIDS ENAMEL SERIES, A-4300
NIIN:00N016215
MSDS Number: CFNNT
=== Responsible Party ===
Company:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTRERO AVE
City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Info Phone Num:818-444-9274
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:BOB SYPOWICZ
CAGE:65860
=== Contractor Identification ===
Company:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTERO AVE
Box:City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Phone:818-444-9274 OR 213-283-9335
CAGE:65860
============= Composition/Information on Ingredients =============
Name:DIPROPYLENE GLYCOL METHYL ETHER ACETATE; (DIPROPYLENE
GLYCOL MONOMETHYL ETHER ACETATE). VP:1 @ 20C.
CAS:88917-22-0
Fraction by Wt: 1.1%
OSHA PEL:100 PPM, S
ACGIH TLV:100 PPM, S
Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK) (SARA 313)
(CERCLA). VP:70 @ 20C.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 27.38%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM;300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:XYLENE (SARA 313) (CERCLA). VP:9 @ 20C.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 9.52%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM;150 STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:PROPANE; (PROPANE BLEND). VP:8.6 ATM @ 20C.
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 26.7%
OSHA PEL:1000 PPM
ACGIH TLV:ASPHYXIANT
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:CAN CAUSE IRRITATION AND REDNESS,
TEARING OR BLURRED VISION. SKIN:MODERATE IRRITATION POSSIBLE FROM
PROLONGED EXPOSURE, DEFATTING AND DERMATITIS. INHALATION:NASAL
IRRITATION, HEADACHE, DIZZINESS, NAUSEA, WEAKNESS OR VOMITING,
LOSS OF CONSCIOUSNESS. INGESTION:GASTROINTESTINAL IRRITATION,
HEADACHE, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:DIZZINESS, NAUSEA, WEAKNESS. PROPANE
MAY BE NARCOTIC IN HIGH CONCENTRATIONS. PAINT AND SOLVENTS HAVE
BEEN LINKED TO LIVER ABNORMALITIES, KIDNEY AND LUNG DAMAGE.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER & KIDNEY DISORDERS.
======================= First Aid Measures =======================
Eyes:FLUSH W/WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION IMMEDIATELY. SKIN:WASH EXPOSED AREA W/SOAP & WATER.
REMOVE CONTAMINATED CLOTHING. INHAL:REMOVE TO FRESH AIR. IF
BREATHING IS DIFFICULT , ADMINISTER OXYGEN. IF BREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
INGEST:DO NOT INDUCE VOMITING, KEEP PERSON WARM & QUIET. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-154F,-103C
Lower Limits:1%
Upper Limits:11%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:FLAMMABLE LIQUID-CLASS 1A. CONTAINERS MAY
DEFORM OR EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:REFER TO FIRE & EXPLOSION RISK, HEALTH HAZARD
DATA, REACTIVITY DATA, SPILL/LEAK PROCS & SAFE HANDLING & USE INFO
SECTIONS IN THIS MSDS. ELIMINATE ALL IGNITION SOURCES. ABSORB
LIQUID IN ABSORBANT MATER IAL & PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:FLAMMABLE GAS. SMOKE IN SMOKING AREAS
ONLY.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTIED, SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUALS (VAPOR,
LIQUID &/OR SOLID), ALL HAZARD PRECAUTIONS IN THIS MSDS MUST BE
OBSERVED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF PRODUCT OR ANY COMPONENT IS EXCEEDED,
A NIOSH APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE OF
ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH APPROVED RESPS
UNDER SPECIFIED CNDT NS. (SEE YOUR SAFETY EQUIP SUPPLIER).
Ventilation:PROVIDE SUFFICIENT MECH (GEN &/OR LOC EXHST) VENT TO
MAINTAIN EXPOS BELOW TLV(S). ENGINEERING/ADMIN CONTROLS (SUPDAT)
Protective Gloves:SOLVENT RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . PREVENT RPTD/PRLNG SKIN CONT W/GP PROT HAND CREAM. WEAR
(SUPDAT)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING REST ROOM.
Supplemental Safety and Health
VAP PRESS: CONTAINER PRESSURE:45 PSI @ 68F; 100 PSI @ 130F. VENT:SHOULD
BE IMPLEMENTED TO REDUCE EXPOSURE. OTHER PROT EQUIP:IMPERVIOUS
CLOTHING & CHEMICAL RESISTANT BOOTS.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>-44F,>-42C
Vapor Pres:SUPP DATA
Vapor Density:HVR/AIR
Spec Gravity:0.85
VOC Pounds/Gallon:555
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:81.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:DECOMPOSITION PRODUCTS MAY YIELD
OXIDES OF CARBON & NITROGEN.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF I/A/W APPLICABLE REGULATIONS.
CONTAMINATED ABSORBANT SHOULD BE INCINERATED OR SENT TO AN APPROVED
LANDFILL I/A/W LOCAL, STATE & FEDERAL REGULATIONS.
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|