===================== Product Identification =====================
MSDS NAME:PLIOBOND 20
NIIN:01-023-1114
MSDS Number: CGDTH
=== Responsible Party ===
Company:JOHN CRANE INC
Address:6400 OAKTON ST
City:MORTON GROVE
State:IL
ZIP:60053
Country:US
Info Phone Num:708-967-2400
Emergency Phone Num:708-967-2400
CAGE:5F893
=== Contractor Identification ===
Company:JOHN CRANE INC.
Address:RT. 51 AND PAYNE DRIVE
Box:City:VANDALIA
State:IL
ZIP:62471-9330
Country:US
Phone:618-283-4700
CAGE:5F893
Company:JOHN CRANE-HOUDAILLE INC MARINE & GOVERNMENT GROUP
Address:6400 OAKTON ST ; FORMERLY PACKING CO
Box:City:MORTON GROVE
State:IL
ZIP:60053-2725
Country:US
Phone:708-967-2400/2879
CAGE:71724
============= Composition/Information on Ingredients =============
Name:NITRILE RUBBER
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:ALKYLPHENOLIC RESIN
Fraction by Wt: 5-10%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:CALCIUM CARBONATE
CAS:471-34-1
RTECS #:FF9335000
Fraction by Wt: 1-5%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)
Name:2-BUTANONE; (METHYL ETHYL KETONE) (SARA 313) (CERCLA)
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 79%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM/300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:FORMALDEHYDE (SARA 302/313) (CERCLA)
CAS:50-00-0
RTECS #:LP8925000
Fraction by Wt: 0-0.1%
OSHA PEL:SEE 1910.1048
ACGIH TLV:C 0.3 PPM, A2
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:EXPLAN OF CARCIN: CARCINS, 1994: ANTICIPATED TO BE
CARCINOGEN. OSHA REGULATED: CFR 29 1910.1048. ANIMAL: NASAL TUMORS.
RTECS #:9999999ZZ
Name:FIRST AID PROC: INGEST: DO NOT INDUCE VOMIT. KEEP PERS
WARM, QUIET & GET MED ATTN. ASPIR OF MATL INTO LUNGS DUE (ING 8)
RTECS #:9999999ZZ
Name:ING 7: TO VOMIT CAN CAUSE CHEM PNEUMIT WHICH CAN BE FATAL.
INHAL: REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN (ING 9)
RTECS #:9999999ZZ
Name:ING 8: OXYGEN. IF BREATHING HAS STOPPED, GIVE ARTIFICIAL
RESPIRATION. KEEP PERSON WARM, QUIET & GET MEDICAL ATTENTION.
RTECS #:9999999ZZ
Name:SPILL PROC: EXCLUDED FROM AREA OF SPILL UNTIL CLEAN UP HAS
BEEN COMPLETED. STOP SPILL AT SOURCE, PVNT FROM (ING 11)
RTECS #:9999999ZZ
Name:ING 10: ENTERING DRAINS, SEWERS OR OTHER BODIES OF WATER.
PREVENT FROM SPREADING.
RTECS #:9999999ZZ
Name:RESP PROT: SEE YOUR SAFETY EQUIP SUPPLIER.
ENGINEERING/ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
EXPOSURE.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACUTE: EXPOS TO LIQ/VAP MAY CAUSE MILD
EYE IRRIT. SYMPS MAY INCL BURNING, TEARING & REDNESS. EXPOS MAY
CAUSE SKIN IRRIT. PRLNG/RPTD EXPOS MAY DRY SKIN, SYMPS MAY INCL
REDNESS, BURNING, DRYING & CRACKI NG, SKIN BURNS & SKIN DMG. RPTD
CONT MAY CAUSE SENSIT. EXCESS INHAL OF VAPS CAN CAUSE NASAL & RESP
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:FORMALDEHYDE: IARC MONOGRAPHS,
SUPPLEMENT, VOLUME 62, PAGE 217, 1995: GROUP 2A. NTP 7TH ANNUAL
REPORT ON (ING 6)
Effects of Overexposure:HLTH HAZ: IRRIT & CNS EFTS INCL DIZZ, WEAK,
FATG, NAUS, HDCH & POSS UNCON. SWALLOWING CAN CAUSE GI IRRIT, NAUS,
VOMIT & DIARR. ASPIR OF MATL INTO LUNGS CAN CAUSE CHEM PNEUMIT
WHICH CAN BE FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:SKIN: REMOVE CONTAM CLTHG. FLUSH SKIN W/LGE AMTS OF WATER. IF
DAMAGED, APPLY CLEAN DRESSING & SEEK IMMED MED ATTN. IF SKIN IS NOT
DAMAGED, WASH EXPOSED AREA W/SOAP & WATER. LAUNDER CONTAM CLTHG
BEFORE REUSE. IF SYMPS PERSIST, SEEK MED ATTN. EYES: MOVE AWAY
FROM EXPOS & INTO FRESH AIR. FLUSH EYES W/CLEAN WATER, HOLDING
EYELIDS APART FOR AT LEAST 15 MIN. IF SYMPS PERSIST, SEEK MED ATTN.
(ING 7)
===================== Fire Fighting Measures =====================
Flash Point:23.0F,-5.0C
Lower Limits:2.0%
Upper Limits:12.0%
Extinguishing Media:REGULAR FOAM, WATER FOG, CARBON DIOXIDE OR DRY
CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS ARE HEAVIER THAN AIR & MAY TRAVEL
ALONG GROUND/MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER
FLAMES, SPKS, HEATERS, SMKNG, ELEC MOTORS, (SUP DAT)
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM ALL SOURCES OF IGNIT, SUCH AS FLARES,
FLAMES, INCL PILOT LIGHTS & ELEC SPKS. IF RUN OFF OCCURS, NOTIFY
AUTH AS REQUIRED. ABSORB LIQ ON VERMICULITE, FLOOR ABSORB/OTHER
ABSORB MATL & TRANSFER TO HO OD. PERS NOT WEARING PROT EQUIP SHOULD
BE (ING 10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:ALL FIVE GALLON PAILS AND LARGER METAL
CONTAINERS, INCLUDING TANK CARS AND TANK TRUCKS, SHOULD BE GROUNDED
AND/OR BONDED WHEN MATERIAL IS TRANSFERRED.
Other Precautions:NEVER USE WELDING OR CUTTING TORCH ON OR NEAR DRUM,
EVEN IF EMPTY, BECAUSE PRODUCT, EVEN JUST RESIDUE, CAN IGNITE
EXPLOSIVELY.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF WORK PLACE EXPOS LIMIT IS EXCEEDED, A NIOSH
APPROVED AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF PROPER ENVIRON
CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH APPROVED RESPS (NEGATIVE
PRESSURE TYPE) UND ER SPECIFIED CONDITIONS. (ING 12)
Ventilation:LOC EXHAUST/MECHANICAL (GEN): PROVIDE SUFFICIENT LOCAL
EXHAUST & MECHANICAL VENT TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:RESISTANT, SUCH AS NATURAL RUBBER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
TO PVNT RPTD/PRLNG SKIN CONT WEAR IMPERVIOUS CLOTHING & BOOTS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EXPLO HAZ: STATIC DISCHARGE/OTHER IGNIT SOURCES AT LOCATIONS DISTANT
FROM MATL HNDLG POINT. NEVER USE WELDING/CUTTING TORCH ON/NEAR DRUM
(EVEN EMPTY) BECAUSE PROD CAN IGNITE EXPLO. ALL FIVE GALLON PAI LS
ARE LARGER METAL CONTRS INCL TANK CARS & TANK TRUCKS SHOULD BE
GROUNDED &/OR BONDED WHEN MATL IS TRANSFERRED.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:176F,80C
Vapor Pres:71
Vapor Density:2.5
Spec Gravity:0.862 (H*2O=1)
Appearance and Odor:TAN COLORED LIQUID
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE,
VARIOUS HYDROCARBONS, NITROGEN COMPOUNDS, PHENYLS, HYDROGEN
CYANIDE, ETC.
==================== Disposal Considerations ====================
Waste Disposal Methods:SMALL SPILL: DISPOSE OF IN ACCORDANCE WITH ALL
LOCAL, STATE AND FEDERAL REGULATIONS. LARGE SPILL: DESTROY BY
LIQUID INCINERATION IN ACCORDANCE WITH APPLICABLE REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|