===================== Product Identification =====================
MSDS NAME:6776 LO (US PATENT 5387363)
NIIN:00N078912
MSDS Number: CGGRP
=== Responsible Party ===
Company:TURCO PRODUCTS INC
Address:2375 STATE RD
City:CORNWELL HEIGHTS
State:PA
ZIP:19020
Country:US
Info Phone Num:215-245-3128
Emergency Phone Num:202-483-7616;800-424-9300(CHEMTREC)
CAGE:0BYL8
=== Contractor Identification ===
Company:TURCO PRODUCTS DIV
Address:2375 STATE RD
Box:City:CORNWELLS HEIGHTS
State:PA
ZIP:19102
Country:US
Phone:215-245-3128
CAGE:TURCX
Company:TURCO PRODUCTS INC
Address:7300 BOLSA AVE
City:WESTMINSTER
State:CA
ZIP:92684-3600
Country:US
Phone:714-890-3600
CAGE:0BYL8
============= Composition/Information on Ingredients =============
Name:BENZYL ALCOHOL
CAS:100-51-6
RTECS #:DN3150000
Fraction by Wt: 15%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:LINEAR ALKYL BENZENE; (LINEAR ALKYLATED ARYL HYDROCARBON)
CAS:68648-87-3
Fraction by Wt: <5%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:FORMIC ACID (SARA 313) (CERCLA)
CAS:64-18-6
RTECS #:LQ4900000
Fraction by Wt: 5%
OSHA PEL:5 PPM
ACGIH TLV:5 PPM;10 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:FORMIC ACID, BENZYL ESTER; (BENZYL FORMATE)
CAS:104-57-4
RTECS #:LQ5400000
Fraction by Wt: 10%
OSHA PEL:N/K
ACGIH TLV:N/K
Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
OSHA PEL:N/K
ACGIH TLV:N/K
Name:SUPP DATA:GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
RTECS #:9999999ZZ
Name:SPILL PROC:FOR DISP. WASH AREA W/WATER, FOLLOWED BY SODA
ASH SOLN. WASHING CNTNG ONLY RESIDUAL AMTS OF PROD MAY (ING 9)
RTECS #:9999999ZZ
Name:ING 8:BE FLUSHED TO SEWER IF LOCAL REGULATIONS PERMIT. USE
SOLUTION:AS FOR CONCENTRATE, IF APPLICABLE.
RTECS #:9999999ZZ
Name:WASTE DISP METH:WASTE. (3)SM AMTS MAY BE DISSOLVED IN WATER
& TREATED AS DESCRIBED UNDER SPENT SOLN & RINSES. (ING 11)
RTECS #:9999999ZZ
Name:ING 10:CLARIFIED WATER MAY BE RELS TO SEWER IF LOC REGS
PERMIT. SPENT SOLNS & RINSES:DISP PER (1) OR (2) AS (ING 12)
RTECS #:9999999ZZ
Name:ING 11:DESCRIBED UNDER CONCENTRATE, OR HEAVY METALS (IF
PRESENT) MAY BE PRECIPITATED BY PH ADJUSTMENT TO 9.5 - (ING 13)
RTECS #:9999999ZZ
Name:ING 12:10.5; PH OF SEPARATED WATER SHOULD THEN BE
READJUSTED TO PH 7-8. CLARIFIED WATER MAY BE RELS TO SEWER IF (ING
14)
RTECS #:9999999ZZ
Name:ING 13:LOCAL REGULATIONS PERMIT.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYES:CONTACT MAY CAUSE SLIGHT TO
MODERATE IRRITATION. SKIN:CONTACT MAY CAUSE SLIGHT IRRITATION.
INHALATION:INHALATION OF MIST FROM SOLUTION MAY CAUSE MODERATE TO
SEVERE IRRITATION OF RESPIRATORY TRACT. INGESTION:MODERATE TO
SEVERE IRRITATION OF GASTROINTESTINAL TRACT, NAUSEA. CHRONIC:NO
KNOWN (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:CHRONIC EFFECTS THAT DIFFER FROM ACUTE
EFFECTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
Eyes:IMMED BEGIN FLUSHING W/LG VOLS OF WATER. CONTINUE FOR AT
LST 15 MINS. HOLD LIDS APART TO ASSURE CONT W/ALL SURFS. OBTAIN MED
ATTN. SKIN:FLUSH AFFECTED AREA W/LG VOLS OF WATER. CONTINUE
FLUSHING F OR AT LST 15 MINS. IF IRRIT IS EVID/BLISTERING OCCURS,
OBTAIN MED ATTN. INHAL:REMOVE TO FRESH AIR. ADMIN OXYG IF BRTHG IS
DFCLT. OBTAIN MED ATTN IF IRRIT PERSISTS. INGEST:DO NOT INDUCE
VOMIT (SUPDAT)
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:>212F,>100C
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE.
================== Accidental Release Measures ==================
Spill Release Procedures:CONFINE SPILL. STOP LEAK AT SOURCE IF THIS CAN
BE DONE SAFELY. VENT AREA. NONESSNTL PERS SHOULD LEAVE AREA UNTIL
CLEANUP IS COMPLETED. PUMP LIQ INTO DOT-APPRVD DRUMS FOR DISP.
ABSORB REMAINING LIQ ONT O INERT ABSORB & PLACE IN DOT-APPRVD DRUMS
(ING 8)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE IN DRY PROTECTED AREA. OPEN
DRUMS CAREFULLY TO AVOID SPURTING. CORROSIVE MATERIAL.
Other Precautions:REPAIR & MAINTENANCE OF CONTAMINATED
EQUIPMENT:RELIEVE ANY PRESSURE. COVER OPENINGS TO AVOID SPURTING.
CLEAN EXTERIOR & INTERIOR BY FLUSHING W/WATER. COLLECT FLUSHINGS
FOR DISPOSAL. USE PROTECTIVE EQU IPMENT FOR EYES, SKIN &
INHALATION.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:FOR MIST CONDITIONS, A NIOSH APPROVED RESPIRATOR
FOR ACID GASES & MISTS IS ADVISED. IF RESPIRATORS ARE USED, A
FORMAL TRAINING & SCREENING PROGRAM MUST BE INITIATED. SEE 29 CFR
1910.134.
Ventilation:MAINTAIN SUFFICIENT MECHANICAL VENTILATION TO KEEP VAPOR
CONCENTRATION BELOW TLV.
Protective Gloves:ACID RESISTANT GLOVES (VITON, PVC, ETC).
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS &(SUPDAT)
Other Protective Equipment:ANSI APPRVD EYE WASH FOUNTAIN & DELUGE
SHOWER . BOOTS & APRON MADE OF ACID RESIST MATL (VITON, PVC, ETC).
(SUPDAT)
Work Hygienic Practices:WASH HANDS & FACE W/SOAP & WATER BEFORE
SMOKING/EATING. IMMED REMOVE ALL CONTAM CLTHG. LAUNDER SEPARATELY
BEFORE REUSE.
Supplemental Safety and Health
EYE PROT:FULL LGTH FSHLD . OTHER PROT EQUIP:PROT SUIT NOT NORMALLY
REQD, BUT ADVISED IF NEC TO AVOID ANY POSS SKIN CONT/OTHER EXPOS.
FIRST AID PROC:EXCEPT ON ADVICE OF COMPETENT MED PERS. IF VIC TIM
IS CONSCIOUS, DILUTE BY GIVING LG VOLS OF MILK/WATER. OBTAIN IMMED
MED ATTN. NEVER ATTEMPT TO INDUCE VOMIT/ (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:212F,100C
Vapor Pres:15
Vapor Density:<1
Spec Gravity:1.04
VOC Pounds/Gallon:395
pH:2
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:VISCOUS LIGHT GREEN EMULSION; SHARP ODOR.
Percent Volatiles by Volume:98
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
CONTACT W/STRONG ALKALIS, REACTIVE METALS SUCH AS MAGNESIUM OR TIN (NOT
INCLUDING ALUMINUM).
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY PRODUCE
CARBON MONOXIDE, DIOXIDE & OTHER TOXIC VOLATILE ORGANIC COMPOUNDS.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISP MUST BE I/A/W FED, STATE & LOC REGS .
CONCENTRATE:(1)TRANSFER TO RECLAIMING CENTER FOR RECYCLING/REUSE,
IF POSS. (2)TRANSFER TO LICENSED HAZ WASTE TREATMENT/DISP SITE FOR
DISPOSITION UNDER APPLIC LOC, STATE & REGIONAL REGS AS HAZ (ING
10)
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|