===================== Product Identification =====================
MSDS NAME:ZEROSTART STARTING FLUID-CYLINDER
NIIN:01-297-0663
MSDS Number: CGLGD
=== Responsible Party ===
Company:PHILLIPS TEMRO INC DIVISION OF BUDD CO INC
Address:9700 W 74TH ST
City:EDEN PRAIRIE
State:MN
ZIP:55344
Country:US
Info Phone Num:612-941-9700
Emergency Phone Num:612-941-9700
CAGE:6Y402
=== Contractor Identification ===
Company:PHILLIPS TEMRO INC DIVISION OF BUDD CO INC
Address:9700 W 74TH ST
City:EDEN PRAIRIE
State:MN
ZIP:55344
Country:US
CAGE:6Y402
Company:TRAK INTERNATIONAL
Address:369 W WESTERN AVE
Box:City:PORT WASHINGTON
State:WI
ZIP:53074-2233
Country:US
Phone:414-268-8944
CAGE:3Y949
============= Composition/Information on Ingredients =============
Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 10-15%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;94
Name:ETHYL ETHER (SARA III) (DIETHYL ETHER)
CAS:60-29-7
RTECS #:KI5775000
Fraction by Wt: 60-70%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:400 PPM
ACGIH TLV:400PPM/500STEL; 9394
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:N-HEPTANE
CAS:142-82-5
RTECS #:MI7700000
Fraction by Wt: 20-30%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:500 PPM
ACGIH TLV:400 PPM/500STEL;9394
Name:HYDROTREATED LIGHT NAPHTHENIC DISTILLATE PETROLEUM
CAS:64742-53-6
RTECS #:PY8036000
Fraction by Wt: <1%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/CUM (OIL MIST)
ACGIH TLV:5 MG/CUM (OIL MIST)
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN CONTACT-IRRITATION UPON PROLONGED
CONTACT, DEFATTING OF SKIN. EYE CONTACT-IRRITATION.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALATION-DIZZINESS, STRONG ANESTHESIA,
INTOXICATION, UNCONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION-REMOVE TO FRESH AIR. ARTIFICIAL RESPIRATION, GET
IMMEDIATE MEDICAL ATTENTION. SKIN-FLUSH AREA WELL WITH WATER.
REMOVE AND WASH ANY CLOTHING SOAKED WITH PRODUCT. EYE-FLUSH EYE
WELL WITH RUNN ING WATER FOR 15 MIN. INGESTION-CALL PHYSICIAN OR
POISON CONTROL CENTER IMMEDIATELY. PROPER TREATMENT IS DEPENDENT OF
CONDITION OF PATIENT AND AMOUNT INGESTED.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:-56F,-49C
Lower Limits:1.8%
Upper Limits:48%
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE, WATER-FOG OR MIST,
ALCOHOL FOAM.
Fire Fighting Procedures:SELF-CONTAINED BREATHING APPARATUS &
PROTECTIVE CLOTHING SHOULD BE WORN IN FIGHTING FIRES INVOLVING
CHEMICALS.
Unusual Fire/Explosion Hazard:AVOID POSSIBLE BURSTING OF CAN. DO NOT
STORE WHERE TEMPERATURE MAY EXCEED 120F. DO NOT PUNCTURE OR
INCINERATE.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP AWAY FROM HEAT, FIRE, SPARK OR FLAME.
VENTILATE AREA WELL. USE CARBON DIOXIDE AS VAPOR BLANKET. SMALL
AMOUNT MAY BE FLUSHED WITH WATER. AVOID ANY CONTAMINATION OF
GROUNDWATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:DO NOT STORE WHERE TEMPERATURE MAY
EXCEED 120F. DO NOT STORE NEAR HEAT, FIRE, FLAME OR SPARKS.
Other Precautions:DO NOT USE NEAR HEAT, FIRE, FLAME OR SPARKS. AVOID
EXCESSIVE BREATHING OF VAPOR. DO NOT SPRAY IN DIRECTION OF BODY.
USE ONLY IN ACCORDANCE WITH DIRECTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV IS EXCEEDED, WEAR NIOSH APPROVED SELF-
CONTAINED BREATHING DEVICE OR RESPIRATOR.
Ventilation:MUST BE ADEQUATE TO MAINTAIN VAPORS AT LESS THAN 400 PPM,
PARTICULARLY AT FLOOR LEVEL SINCE VAPORS ARE HEAVIER THAN AIR.
Protective Gloves:NITRILE FOR PROLONGED EXPOSURE.
Eye Protection:SAFETY GLASSES OR GOGGLES RECOMMENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER. HMIS- EYE
WASH AVAILABLE.
Work Hygienic Practices:WASH AHNDS AFTER USE AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health
NOTE: THIS PRODUCT IS EXTREMELY FLAMMABLE AT ALL TIMES. AVOID
INADVERTENT IGNITION SOURCES, INCLUDING STATIC SPARK. IF PRODUCT
VAPOR IS ALLOWED TO ACCUMULATE IN AIR, A DANGEROUS FIRE AND
EXPLOSION HAZ ARD EXISTS.
================== Physical/Chemical Properties ==================
HCC:V3
Boiling Pt:B.P. Text:94.0F,34.4C
Vapor Pres:150 PSIG
Vapor Density:2.5
Spec Gravity:0.70
Evaporation Rate & Reference:6 (N-BUTYL ACETATE=1)
Solubility in Water:6%
Appearance and Odor:PALE YELLOW TO CLEAR LIQUID WITH STRONG ETHERAL
ODOR; EVAPORATES QUICKLY.
Percent Volatiles by Volume:86
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:PROLONGED STORAGE WITH EXPOSURE TO AIR AND
LIGHT. GENERALLY STABLE IN SEALED METAL CONTAINERS. HEAT, SPARKS,
FLAMES.
Hazardous Decomposition Products:CARBON MONOXIDE MAY FORM ON
COMBUSTION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF PROPERLY IN SEALED METAL CONTAINERS,
IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|