===================== Product Identification =====================
MSDS NAME:E -58D EMULSIFIER (SEE SUPP DATA)
NIIN:01-263-8231
Kit Part:Y
MSDS Number: BGWKP
=== Responsible Party ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID STREET
Box:SANTA
City:MONICA STREET
State:CA
ZIP:90404-3770
Country:US
Info Phone Num:213-450-1111
Emergency Phone Num:213-450-1111
CAGE:98733
=== Contractor Identification ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID ST
Box:00000
City:SANTA MONICA
State:CA
ZIP:90404
Country:US
Phone:310-450-1111/FAX 310452-4046
CAGE:98733
============= Composition/Information on Ingredients =============
Name:ETHYLENE GLYCOL (SARA III)
CAS:107-21-1
RTECS #:KW2975000
Fraction by Wt: 50.0%
OSHA PEL:C 50 PPM
ACGIH TLV:C 50 PPM,VAPOR; 9192
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY CAUSE SLIGHT SKIN
IRRITATION;VAPORS OR OIL MIST MAY CAUSE MILD IRRITATION OF UPPER
RESPIRATORY TRACT.
Effects of Overexposure:EYES:PRESUMED NON-IRRITATING;SKIN:SLIGHT
IRRITATION ON LIQUID CONTACT;INHALATION: VAPORS OR OIL MIST MAY
CAUSE MILD IRRITATION OF UPPER RESPIRATORY TRACT;INGESTION:MAY
RESULT IN VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN AND RESPIRATORY
DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
======================= First Aid Measures =======================
First Aid:EYES :FLUSH WITH WATER.GET MEDICAL HELP IF IRRITATION OCCURS
OR PERSISTS;SKIN:FLUSH WITH WATER.WASH WITH WATER & SOAP.GET ATTN
FOR PERSISTING IRRITATION; INHALATION:REMOVE TO FRESH AIR.PROVIDE
OXYGEN IF BREATHING IS DIFFICULT GET MED ATTN IF NEEDED;
INGESTION: INDUCE VOMITING.GET MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:232F/111.1C
Lower Limits:3.2
Extinguishing Media:WATER FOG,DRY CHEMICAL,CARBON DIOXIDE OR FOAM; DO
NOT USE DIRECT STREAM OR WATER.
Fire Fighting Procedures:IN CONFINED AREA,DO NOT ENTER WITHOUT A FULL
BUNKER GEAR INCLUDING A POSITIVE PRESSURE NIOSH APPROVED
SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:CONTAINERS MAY BURST/RUPTURE IN INTENSE
OF HEAT.PER MFR,WILL IGNITE IN AIR AT ABOUT 7775F.
================== Accidental Release Measures ==================
Spill Release Procedures:ELIM IGNITION SOURCES. WEAR APPROPRIATE
PROTECTIVE CLOTHING & RESPIRATOR.DIKE & TRANSFER LIQ TO A SALVAGE
TANK.SOAK UP RESIDUE WITH ABSORBENT CLAY,SAND OR OTHR MATL.PLACE
RAGS & ABSORBED WASTE MATERL IN COVERED NON-LEAKING CONTAINERS.
====================== Handling and Storage ======================
Handling and Storage Precautions:0001KEEP AWAY FROM HEAT/IGNITION
SOURCES. STORE IN DRY,COOL,& VENTILATED LOCATION.DO NOT STORE NEAR
OXIDIZING MATERIAL. AVOID PHYSICAL DAMAGE TO CANS.
Other Precautions:MINIMIZE SKIN CONTACT.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NEEDED IN NORMAL CONDITIONS OR USES. USE AN
ORGANIC VAPOR CHEMICAL CARTRIDGE OR CANISTER WHEN TLV IS EXCEEDED.
Ventilation:LOCAL EXHAUST OR MECHANICAL(GENERAL) AS REQUIRED TO
MAINTAIN TLV OR BELOW TLV.
Protective Gloves:CHEMICAL RESISTANT
Eye Protection:SPLASHPROOF GOGGLES/SAFETY GLASSES
Other Protective Equipment:A=RON TO PREVENT CLOTHIN/SKIN CONTACT.
Work Hygienic Practices:WASH HANDS WITH SOAP AND WATER BEFORE
ESTING,SMOKING OR USING TOILET FACILITIES;DONT EAT/DRINK IN VAPOR
CONTMNTD AREA.
Supplemental Safety and Health
NSN FOR A 2 PART KIT OF TYPE I,METHOD D,LVL 3 OF MIL-I-252435D;PER
QPL-25135-15,THE SET MAY CONSIST OF FP-95A(M) PENETRANT AND E-58A
OR E-58D EMULSIFIER.THE MFR MAY SUPPLY EITHER E-58A OR E-58D EMULSI
FIER WITH FP-95A(M) PENETRANT UNDER THIS NSN;KEY1:N1;THIS DATA
ENTRY DESCRIBES: E-58D EMULSIFIER;SEE PNI-A FOR PENETRNT.
================== Physical/Chemical Properties ==================
HCC:N1
Boiling Pt:B.P. Text:380F(193.3C
Spec Gravity:ABOUT 1.2
Solubility in Water:COMPLETE
Appearance and Odor:LIGHT REDDISH PINK LIQUID.PRACTICALLY ODORLESS.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL
Stability Condition to Avoid:SOURCE OF HEAT/IGNITION
Hazardous Decomposition Products:CARBON MONOXIDE,CARBON DIOXIDE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE
#D001,IGNITIABLE WASTE.PLACE WASTE MATERIAL IN AN APPROPRIATE
DISPOSAL FACILITY,OR DISPOSE OF IN COMPLIANCE WITH FEDERAL,STATE $
LOCAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|