=====================  Product Identification  =====================

MSDS NAME:FP-97 A (M) PENETRANT
NIIN:01-263-8222
Kit Part:Y
MSDS Number: BGWKK
=== Responsible Party ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID ST
City:SANTA MONICA
State:CA
ZIP:90404
Country:US
Info Phone Num:310-450-1111
Emergency Phone Num:310-450-1111/800-424-9300(CHEMTREC)
CAGE:98733
=== Contractor Identification ===
Company:MET-L-CHEK COMPANY
Address:1639 EUCLID ST
Box:00000
City:SANTA MONICA
State:CA
ZIP:90404
Country:US
Phone:310-450-1111/FAX 310452-4046
CAGE:98733

=============  Composition/Information on Ingredients  =============

Name:HYDROTREATED MIDDLE PETROLEUM DISTILLATE/PETROLEUM
    HYDROCARBON
CAS:64742-46-7
RTECS #:JN9379645
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5 MG/M3 AS OIL MIST
ACGIH TLV:5 MG/M3 AS OIL MIST

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:LD50 (ORAL, RAT) IS NOT KNOWN.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
    TRACT. ACUTE- EYES:PRESUMED NON-IRRITATING. SKIN:SLIGHTLY
    IRRITATING. INHALATION:VAPORS OR MIST MAY CAUSE MILD IRRITTION OF
    UPPER RESPIRATORY TRACT. ORAL:MAY CAUS E VOMITING. ASPIRATION
    HAZARD. CHRONIC-UNKNOWN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
    DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
    TO THE EFFECTS OF THIS PRODUCT.

=======================  First Aid Measures  =======================

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
    AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
    MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
    NOT IN DUCE VOMITING. GET MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:COC
Flash Point:210F,99C
Extinguishing Media:WATER FOG, CARBON DIOXIDE, SAND, FOAM/DRY CHEMICAL.
    DO NOT USE DIRECT STREAM OF WATER.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
    WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
    SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:NONE

==================  Accidental Release Measures  ==================

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENT. VENTILATE AREA.
    CONTAIN AND PICK UP SPILL WITH NON-FLAMMABLE ABSORBENT SUCH AS
    SAND, EARTH, VERMICULITE. PREVENT LIQUID FROM ENTERING SEWERS OR
    WATERWAYS.
Neutralizing Agent:NOT RELEVANT

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN COOL PLACE AWAY FROM FLAMES
    AND OXIDIZING MATERIALS.
Other Precautions:WASH THOROUGHLY WITH SOAP AND WATER AFTER HANDLING
    AND BEFORE EATING, DRINKING, SMOKING. KEEP OUT OF REACH OF
    CHILDREN.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NONE NORMALLY REQUIRED. IF TLV IS EXCEEDED OR
    FOR SYMPTOMS OF OVER EXPOSURE, WEAR NIOSH-APPROVED ORGANIC VAPOR
    RESPIRATOR OR AIR-PURIFYING RESPIRATOR. IN EMERGENCY, WEAR A
    NIOSH-APPROVED POSITIVE-PRES SURE SELF-CONTAINED BREATHING
    APPARATUS.
Ventilation:LOCAL EXHAUST IS RECOMMENDED FOR CONFINED AREAS. GENERAL
    MECHANICAL VENTILATION IS ADEQUATE FOR NORMAL USE.
Protective Gloves:RUBBER TO PREVENT CONTACT
Eye Protection:SAFETY GLASSES WITH SIDE SHIELD
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, PROTECTIVE
    CLOTHING
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
    RECOMMENDED PROCEDURES.
Supplemental Safety and Health
NSN FOR KIT OF OF TYPE 1, METHOD B, LEVEL 3 OF MIL-I-25135.PER
    QPL-25135-15, FP-95A(M) PENETRANT AND E-57 EMULSIFIER ARE THE TWO
    PARTS OF THE SET. THIS ENTRY DESCRIBES FP-95A(M) PENETRANT. SEE
    PNIND B  FOR THE EMULSIFIER DATA. KEY1:N1

==================  Physical/Chemical Properties  ==================

HCC:N1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>400F,>204C
Melt/Freeze Pt:M.P/F.P Text:-75F,-59C
Spec Gravity:0.86 (ABOUT)
Solubility in Water:INSOLUBLE
Appearance and Odor:YELLOW-GREENB LIQUID, SLIGHT HYDROCARBON ODOR

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS
Stability Condition to Avoid:OPEN FLAME, HEAT
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE, CARBON
    DIOXIDE AND UNIDENTIFIED ORGANIC COMPOUNDS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE
    AND FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***