Material Safety Data Sheet
Revision Date: 10/03/2005 Issue date: 10/03/2005
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product name: X-NMS Clean Up Solvent for Instant Adhesive Item No. : 76820
Product type: Solvent Region: United States
Company address: Contact Information:
Henkel Corporation Telephone: 860.571.5100
1001 Trout Brook Crossing Emergency telephone: 860.571.5100
Rocky Hill, Connecticut 06067 Internet: www.loctite.com
2. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components % ACGIH TLV OSHA PEL OTHER
Nitromethane 60-100 20 ppm TWA 100 ppm TWA None
75-52-5 250 mg/m鲁 TWA
Toluene 5-10 50 ppm TWA 200 ppm TWA None
108-88-3 (skin) 300 ppm Ceiling
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
HMIS:
Physical state: Liquid HEALTH: 2
Color: Clear FLAMMABILITY: 3
Odor: Slight PHYSICAL HAZARD: 1
Personal Protection: See Section 8
WARNING: FLAMMABLE!
POSSIBLE CANCER HAZARD.
MAY CAUSE EYE, SKIN AND RESPIRATORY TRACT IRRITATION.
MAY BE HARMFUL IF SWALLOWED OR INHALED.
Relevant routes of exposure: Skin, Inhalation, Eyes, Ingestion
Potential Health Effects
Inhalation: May cause respiratory tract irritation. Headache, dizziness, nausea, and loss of coordination are
indications of excessive exposure to vapors or spray mists.
Skin contact: May cause skin irritation. Redness.
Eye contact: Moderate eye irritation. Non-irritating. May cause corneal injury.
Ingestion: Not expected under normal conditions of use.
Existing conditions aggravated by None generally recognized.
exposure:
See Section 11 for additional toxicological information.
Item No. : 76820 Product name: X-NMS Clean Up Solvent for Instant Adhesive
1 of 4
4. FIRST AID MEASURES
Inhalation: Remove to fresh air. If symptoms develop and persist, get medical attention.
Skin contact: Wash with soap and water.
Eye contact: Immediately flush eyes with plenty of water for at least 15 minutes. Get medical attention.
Ingestion: Do not induce vomiting. Drink 1 or 2 glasses of water. Obtain medical attention. Never give anything by
mouth to an unconscious person.
5. FIRE-FIGHTING MEASURES
Flash point: 32掳C (95掳F) Closed cup
Autoignition temperature: Not determined
Flammable/Explosive limits-lower %: 7.3
Flammable/Explosive limits-upper %: Not available
Extinguishing media: Carbon dioxide (CO2). Foam. Water spray.
Special fire fighting procedures: Wear self-contained breathing apparatus and protective suite.
Unusual fire or explosion hazards: Closed containers may explode when exposed to extreme heat. Vapors may form explosive mixtures
with air.
Hazardous combustion products: Oxides of carbon. Oxides of nitrogen.
6. ACCIDENTAL RELEASE MEASURES
Environmental precautions: Remove sources of ignition. Contain spill.
Clean-up methods: Soak up with inert absorbent. Store in a closed container until ready for disposal. Rinse spill area with
water.
7. HANDLING AND STORAGE
Handling: Avoid contact with eyes, skin and clothing.
Storage: Keep in a cool, well ventilated area away from heat, sparks and open flame. Keep container tightly
closed until ready for use.
Incompatible products: Not available
For information on product shelf life contact Henkel Customer Service at (800) 243-4874.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering controls: Ensure adequate ventilation. Local exhaust ventilation is recommended when general ventilation is not
sufficient to control airborne contamination below occupational exposure limits.
Respiratory protection: Use NIOSH approved respirator if there is potential to exceed exposure limit(s). Observe OSHA
regulations for respiratory use (29 CFR 1910.134).
Skin protection: Cover as much of the exposed skin area as possible with appropriate clothing.
Eye/face protection: Safety glasses with side-shields. Goggles.
Item No. : 76820 Product name: X-NMS Clean Up Solvent for Instant Adhesive
2 of 4
See Section 2 for exposure limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state: Liquid
Color: Clear
Odor: Slight
Vapor pressure: 25 mmHg @20掳C (68掳 F)
pH: Not applicable
Boiling point/range: Approximately 111掳C (214掳F)
Melting point/range: Not available
Specific gravity: 1.1
Vapor density: 2.1 (air equals 1)
Evaporation rate: Approximately 6 (Ether = 1)
Solubility in water: 9%
Partition coefficient (n-octanol/water): Not available
VOC content: 100%; 1100 grams/liter (EPA Method 24)
10. STABILITY AND REACTIVITY
Stability: Stable at normal conditions
Hazardous polymerization: Will not occur.
Hazardous decomposition products: None
Incompatability: Amines. Alkalis. Acids. Reducing agents. Metal oxides. Combustible materials.
Conditions to avoid: Keep away from open flames, hot surfaces and sources of ignition.
11. TOXICOLOGICAL INFORMATION
Product toxicity data: Acute LD50 (oral): 940 (rat). (estimated).
Carcinogen Status
Hazardous components NTP Carcinogen IARC Carcinogen OSHA Carcinogen
Nitromethane Suspect carcinogen Group 2B Yes
75-52-5
Toluene No No No
108-88-3
Literature Referenced Target Organ & Other Health Effects
Hazardous components Health Effects/Target Organs
Nitromethane Blood, Bone Marrow, Irritant, Kidney, Liver, Nervous System, Reproductive, Some evidence of carcinogenicity
75-52-5
Toluene Behavioral, Cardiac, Central nervous system, Developmental, Ear, Irritant
108-88-3
12. ECOLOGICAL INFORMATION
Ecological information: Not available
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal: Dispose of in accordance with Federal, State and local regulations.
EPA hazardous waste number: D001: Ignitable.
Item No. : 76820 Product name: X-NMS Clean Up Solvent for Instant Adhesive
3 of 4
14. TRANSPORT INFORMATION
U.S. Department of Transportation Ground (49 CFR):
Proper shipping name: Nitromethane
Hazard class or division: 3
Identification number: UN 1261
Packing group: II
Exceptions: Consumer Commodity ORM-D (Not more than 1 Liter)
International Air Transportation (ICAO/IATA):
Proper shipping name: Nitromethane (Forbidden)
Hazard class or division: Forbidden
Identification number: Forbidden
Packing group: Forbidden
WaterTransportation (IMO/IMDG):
Proper shipping name: Nitromethane
Hazard class or division: 3
Identification number: UN1261
Packing group: II
Marine pollutant: None
15. REGULATORY INFORMATION
United States Regulatory Information
TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory.
TSCA 12 (b) Export Notification: None.
CERCLA/SARA Section 302 EHS: None.
CERCLA/SARA Section 311/312: Immediate Health Hazard, Delayed Health Hazard, Fire
CERCLA/SARA 313: Toluene (CAS# 108-88-3).
California Proposition 65: This product contains a chemical known to the State of California to cause cancer and birth defects or
other reproductive harm.
Canada Regulatory Information
CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Domestic Substances List.
WHMIS hazard class: B.2, D.2.A, D.2.B
16. OTHER INFORMATION
This material safety data sheet contains changes from the previous version in sections: 13
Prepared by: C.J. Michaels, Senior Product Safety & Regulatory Affairs Specialist
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation
does not assume responsibility for any results obtained by persons over whose methods Henkel Corporation has no control. It is the
user's responsibility to determine the suitability of Henkel's products or any production methods mentioned herein for a particular
purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be
involved in the handling and use of any of Henkel Corporation's products. In light of the foregoing, Henkel Corporation specifically
disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale
or use of Henkel Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of
any kind, including lost profits.
Item No. : 76820 Product name: X-NMS Clean Up Solvent for Instant Adhesive
4 of 4
|