MATERIAL SAFETY DATA SHEET
HMIS HAZARD RATINGS
OSHA - Meets 29 CFR 1910.1200 Standards
HEALTH 0 = INSIGNIFICANT 3 = HIGH
1
FLAMMABILITY 1 = SLIGHT 4 = EXTREME
1
REACTIVITY 2 = MODERATE
0
TRANSPORTATION INFORMATION
PROPER SHIPPING NAME: Not Regulated
HAZARD CLASS / PKG GRP: Not regulated Not Applicable
REF:
IDENTIFICATION NUMBER: None None Required
LABEL:
SECTION 1 - PRODUCT / COMPANY IDENTIFICATION
IDENTITY (AS USED ON LABEL AND LIST)
Page 1 of 2
SPARKLE
MANUFACTURER'S NAME EMERGENCY TELEPHONE NUMBER
Gator Chemical CHEM 鈥? TEL (800) 255-3924 Outside USA (813) 248-0585
ADDRESS (NUMBER, STREET, P.O. BOX) TELEPHONE NUMBER FOR INFORMATION
P.O. Box 1990 (727) 584-5174
(CITY, STATE AND ZIP CODE) DATE PREPARED: March 11, 2003
Largo, FL 33779 SUPERSEDES: New
SECTION 2 - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
OSHA PEL ACGIH TWA
HAZARDOUS COMPONENTS % SARA RQ
CAS #
MG/M3 MG/M3 TITLE III LBS
(OPTIONAL)
(SPECIFIC CHEMICAL IDENTITY; COMMON NAME(S)) PPM PPM
Petroleum distillate, aliphatic 64742-06-9 15 - 40 500 2000
SECTION 3 - HEALTH HAZARD DATA
ROUTES OF ENTRY - SIGNS AND SYMPTOMS OF EXPOSURE EMERGENCY AND FIRST AID PROCEDURES
INHALATION: High concentrations are irritating to the respiratory tract; may Remove affected person to fresh air; provide oxygen if breathing is difficult; if
cause headache, dizziness, nausea, vomiting and malaise. affected person is not breathing, administer CPR and seek emergency
medical attention.
SKIN: Brief contact may cause slight irritation; prolonged contact may cause Remove contaminated clothing; wash affected area with soap and water;
moderate irritation or dermatitis. launder contaminated clothing before reuse; if irritation persists, seek medical
attention.
EYES: High vapor concentration or contact may cause irritation and discomfort. Remove contact lenses. Flush eyes with clear running water for 15 minutes
while holding eyelids open; if irritation persists, seek medical attention.
INGESTION: May result in vomiting; aspiration of vomitus into the lungs must DO NOT induce vomiting; if vomiting occurs spontaneously, keep head below
be avoided; DO NOT induce vomiting. Minute amounts aspirated into the lungs hips to prevent aspiration of liquid into lungs; seek immediate medical
can produce severe lung injury, chemical pneumonitis, pulmonary edema or attention. Vomiting may be induced only under the supervision of a physician.
death.
CARCINOGENICITY No No No
NTP? IARC MONOGRAPHS? OSHA REGULATED?
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Preexisting skin, eye, or respiratory disorders may become aggravated through
prolonged exposure.
Form revised 09 / 01
MATERIAL SAFETY DATA SHEET
IDENTITY (AS USED ON LABEL AND LIST) Page 2 of 2
SPARKLE Date: March 11, 2003
SECTION 4 - FIRE FIGHTING MEASURES
FLASH POINT (METHOD USED) NFPA RATING FLAMMABLE LIMITS
265掳 F (129.4潞 C) (COC) LEL: Not applicable UEL: Not applicable
IIIB
EXTINGUISHING MEDIA
Carbon dioxide, water fog, dry chemical, chemical foam
SPECIAL FIRE FIGHTING PROCEDURES
Self - contained respiratory equipment; cool containers to prevent pressure buildup and possible explosion when exposed to extreme heat. Caution - material
will support combustion!
UNUSUAL FIRE AND EXPLOSION HAZARDS
Closed containers can explode due to buildup of pressure when exposed to extreme heat.
SECTION 5 - ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: WILL SUPPORT COMBUSTION. Do not wash to sanitary sewer. All spills - confine
spill, soak up with approved absorbent, shovel product into approved container for disposal. Flush area with water, recover flush for proper disposal.
SECTION 6 - HANDLING AND STORAGE
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Keep container closed when not in use; protect containers from abuse; protect from extreme
temperatures, open flames. This material will support combustion. Keep this and other chemicals out of reach of children.
SECTION 7 - EXPOSURE CONTROLS / PERSONAL PROTECTION
RESPIRATORY PROTECTION (SPECIFY TYPE): None required while threshold limits (Section 2) are kept below maximum allowable concentrations; if TWA
exceeds limits, NIOSH approved respirator must be worn. Refer to 29 CFR 1910.134 or European Standard EN 149 for complete regulations.
VENTILATION LOCAL EXHAUST: Required SPECIAL: To maintain minimum TWA and STEL levels.
MECHANICAL (GENERAL): Yes OTHER: Engineering and work controls as required.
PROTECTIVE GLOVES: Neoprene or rubber gloves with cuffs. EYE PROTECTION: Protective eyeglasses or chemical safety goggles.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Safety eyebath nearby
WORK / HYGIENIC PRACTICES: Practice safe workplace habits. Minimize body contact with this, as well as all chemicals in general.
SECTION 8 - PHYSICAL / CHEMICAL PROPERTIES
BOILING POINT SPECIFIC GRAVITY (WATER = 1)
212掳 F 0.940
VAPOR PRESSURE (MM Hg) pH
17 mm Hg @ 20 掳 C 8.0
VAPOR DENSITY (AIR = 1) EVAPORATION RATE (WATER = 1)
>1 <1
SOLUBILITY IN WATER % VOLATILE (BY WEIGHT)
Emulsifies 96%
APPEARANCE AND ODOR
White emulsion, characteristic oily odor
SECTION 9 - STABILITY AND REACTIVITY
CONDITIONS TO AVOID: Extreme temperatures, open flames
STABILITY UNSTABLE:
STABLE: XXX
INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidizers, strong acids
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: Decomposition will not occur if handled and stored properly. In case of a fire, oxides of carbon,
hydrocarbons, fumes, and smoke may be produced.
HAZARDOUS POLYMERIZATION MAY OCCUR: CONDITIONS TO AVOID:
WILL NOT OCCUR: XXX None
SECTION 10 - DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD: Dispose of in accordance with Local, State, and Federal Regulations. This product may produce hazardous vapors or fumes in a
closed disposal container creating a dangerous environment. Refer to "40 CFR Protection of Environment Parts 260 - 299" for complete waste disposal
regulations. Consult your local, state, or Federal Environmental Protection Agency before disposing of any chemicals. Do not flush to sanitary sewer or
waterway.
The information contained herein is believed to be accurate but is not warranted to be so. Data and calculations are based on information furnished by the
manufacturer of the product and manufacturers of the components of the product. Users are advised to confirm in advance of need that information is current,
applicable and suited to the circumstances of use. Vendor assumes no responsibility for injury to vendee or third persons proximately caused by the material if
reasonable safety procedures are not adhered to as stipulated in the data sheet. Furthermore, vendor assumes no responsibility for injury caused by abnormal use
of this material even if reasonable safety procedures are followed. Any questions regarding this product should be directed to the manufacturer of the product as
described in Section 1.
MSDS PREPARED BY: CDB, Inc., P.O. Box 5604, Lakeland, FL 33807 (863) 644 - 3298 www.compdatabase.com
|