MATERIAL SAFETY DATA SHEET
COMPLIES WITH OSHA鈥橲 HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
SECTION I 路 PRODUCT IDENTIFICATION
Product Name: RUSTORE RUST EXTERMINATOR Formula: Proprietary HMIS Rating (Based on Aerosol Conc.):
Product Number: 74185 Date Prepared: 03/25/03 0-Minimal 1- Slight 2- Moderate
Product Type: AEROSOL Emergency Phone: (800) 255-3924 3- Serious 4- Extreme
Distributor's Name: IBS, Inc. Information Phone: (800)678-1906 HEALTH: 1 FIRE: 3 REACTIVITY: 0
Distributor's Address: P.O. Box 1717, Auburn, WA 98071-1717 Personal Protection: B
D.O.T. Hazard Class: CONSUMER COMMODITY 路 ORM-D
SECTION II 路 INGREDIENTS
CHEMICAL NAME CAS # %WT 313/Chem Skin Carcinogen PEL TWA/TLV
Ethyl Alcohol 64-17-5 40-60 NO NO NO 1000 ppm 1000 ppm
Propylene Glycol Monomethyl Ether 107-98-2 01-05 NO NO NO 100 ppm 100 ppm
Tannic Acid 1401-55-4 01-05 NO NO NO N/E N/E
Liquified Petroleum Gas 68476-85-7 20-40 NO NO NO 1000 ppm 1000 ppm
SECTION III 路 PHYSICAL DATA
Data Below Based On Aerosol Concentrate Only:
Boiling Point: ~ 145掳 F
pH: N/A Vapor Density(Air=1): >1
Solubility In Water: Slight Specific Gravity (H2O=1)@75掳F: 0.895
Appearance/Odor: Dark Liquid, Mild Odor
Data Below Based On Total Contents:
Vapor Pressure of can (psig @70掳F): 50
Total VOC %: ~ 75%
SECTION IV 路 FIRE AND EXPLOSION DATA
Flash Point (of Concentrate Only): 42.8 掳F (T.O.C.) Flammability (as per USA Flame Projection Test): Extremely Flammable Spray
Extinguishing Media: Foam, CO2, Dry Media
Special Fire Fighting Procedures: Wear self-contained breathing apparatus and protective clothing. Cool fire exposed containers to prevent rupturing.
Unusual Fire and Explosion Hazards: Exposure to temperature above 120掳 F may cause bursting.
SECTION V 路 REACTIVITY DATA
Stability: Material Stable. Hazardous Polymerization: Will not Occur.
Incompatibility: Avoid contact with strong oxidizing agents,
Hazardous Decomposition Products: Carbon Dioxide, Carbon Monoxide
SECTION VI 路 STORAGE AND HANDLING
KEEP OUT OF REACH OF CHILDREN.
For Industrial and Institutional use only.
Store in a cool, dry area away from heat or open flame.
Do not store at temperatures above 120掳 F. NFPA Code 30B Rating: Level 3 Aerosol.
SECTION VII 路 HEALTH AND FIRST AID
PRIMARY ROUTES OF ENTRY & EFFECTS OF OVER EXPOSURE:
Eyes: May cause slight irritation but does not injure eye tissue.
Skin: Frequent or prolonged contact may cause irritation.
Inhalation: Inhalation of mist can cause irritation of nasal and respiratory passages. Abusive or excessive inhalation may cause irritation to the upper respiratory tract,
dizziness, nausea and other central nervous system effects.
Ingestion: Can cause gastrointestinal irritation, nausea, vomiting and diarrhea. Aspiration of material into the lungs can cause chemical pneumonitis.
FIRST AID PROCEDURES:
Eyes: Flush with large amounts of cool running water for at least 15 minutes while holding upper and lower lids open. If irritation persists get medical attention immediately.
Skin: Wash with soap and water. If irritation persists seek medical attention.
Inhalation: Remove to fresh air. Seek medical attention immediately. If breathing stops give artificial respiration.
Ingestion: Do not induce vomiting. Seek medical attention immediately.
SECTION VIII 路 SPECIAL PROTECTION DATA
Respiratory Protection: None needed for proper use in accordance with label directions.
Ventilation: Provide local exhaust to keep TLV of Section II ingredients below acceptable limits.
Protective Gloves: None needed for proper use in accordance with label directions. Use chemical resistant gloves if hand contact will be made.
Eye Protection: None needed unless it is anticipated that a splash or spray back will occur, then wear safety glasses or chemical proof goggles.
SECTION IX 路 SPILL OR LEAK PROTECTION
STEPS TO BE TAKEN IN CASE OF SPILL OR LEAK: Allow propellant to evaporate. Maintain local exhaust and adequate ventilation. No smoking. Keep sparks, heat
sources and open flame far away from spill or leak. Cover with absorbent material and sweep up. Wash area to prevent slipping. Dispose of soaked absorbent material in
accordance with Federal, State and local laws.
WASTE DISPOSAL METHOD: Aerosol cans, when emptied and depressurized through normal use, pose no disposal hazard and should be recycled. Consult Federal, State
and local authorities for approved procedures.
N/A= NOT APPLICABLE 路 N/E=NOT ESTABLISHED 路 N/D=NOT DETERMINED 路 <=LESS THAN 路 >=MORE THAN
NOTICE: The information contained on this Material Safety Data Sheet is considered accurate as of the date of publication. It is not necessarily all inclusive nor fully adequate in every circumstance. The
suggestions should not be confused with, nor followed in vi olation of applicable laws, regulations, rules or insurance requirements. No warranty, express or implied, of merchantability, fitness, accuracy of
data, or the results to be obtained from the use thereof is made. The vendor assumes no responsibility for injury or damages resulting from the inappropriate use of this product.
|