MSDS No.: 021599A
Date: August 2000
Revision: 7
MATERIAL SAFETY DATA SHEET
Manufacturer: Emergency Tel. No.
J. Penner Corporation Infotrac: 1-800-535-5053
17 Welden Drive
Doylestown, PA 18901 Information Tel. No.
215-340-9700
______________________________________________________________________________
Section I - Product Identification
Trade Names/Synonyms: Part No.: 551
Re-Mark-Able Marker Board
Conditioner & Cleaner
Chemical Name:
Ingredients CAS No. % by Weight
Kaopolite 1302-76-7 <25%
Siltech 06314-86-29 <10%
Odorless Mineral Spirits 64741-65-7 <25%
d-Limonene 5989-27-5 <10%
Butylated hydroxy toluene 128-37-0 .1%
Deionized Water 7735-18-5 >50%
Proprietary formula, mixture containing water, unsaturated alicyclic hydrocarbons,
petroleum distillate, clay and aminosiloxane.
_____________________________________________________________________________
Section II - Emergency and First Aid
Eyes: Flush with plenty of water for at least 15 minutes. Get medical attention
immediately.
Skin: Wash skin with mild soap and water. Rinse thoroughly. See a doctor if irritation
persists.
Inhalation: Remove victim to fresh air. If breathing difficulty does not improve rapidly, get
patient to a doctor.
Ingestion: Do not induce vomiting. Obtain medical attention immediately.
No crystalline silica detected using the recommended NIOSH test method 7500.
Route of Entry: Inhalation, Skin, Eye, and Ingestion
Symptoms of Overexposure: N/A
Medical Conditions Generally Aggravated by Exposure: None reported.
Additional Information:
______________________________________________________________________________
Precautionary Labeling
Health - 1
Flammability - 3
Reactivity - 0
Page 2 MSDS No.:021599A
______________________________________________________________________________
Section III - Toxicology and Health Information
This material has been tested and evaluated by J. Penner Corporation. When used as intended, it
does not represent a health or safety hazard.
LC50 ppm LD50 mg/kg
Kaolin OSHA PEL ACGIH TLV (Inhalation, rat) (Oral, rat)
Kaopolite .
5.0 mg/m3 5 mg/m3
Calcined Kaolin Respirable
10.0 mg/m3 10 mg/m3
Clay Al2O32SiO2 Total Dust
Siltech N.E. N. E. N.E. N. E.
Odorless Mineral Spirits 100 PPM 100 PPM 592 PPM/4H 25 ML/KG
d-Limonene N/A N/A N/A N/A
Deionized water N/A N/A N/A N/A
Eye Irritation:
Skin Irritation: Based on information available, this product may cause minor to moderate skin
irritation. Product may be harmful if inhaled or swallowed.
Carcinogens:
Aquatic LC50:
Additional Information: Product is not known to cause allergies.
______________________________________________________________________________
Section IV - Physical Data
Appearance/Odor: Semi-viscous, creamy white Softening Range:
liquid with a petroleum citrus odor
Boiling Point: None available Melting Point: None available
Specific Gravity (at oC): None available
Solubility in Water: Yes, miscible. Product
contains water
Evaporation Rate: None available (H2O=1):
Vapor Density (Air=1): None available Vapor Pressure (mmHg): None available
Volatile: (Wgt.) None available pH: neutral
Viscosity: 8500.0 centipoise
______________________________________________________________________________
Section V - Fire and Explosion Data
Flash Point (Method Used): Tag Closed Cap - 120oF
Extinguishing Media: Not applicable
Special Fire Fighting Procedures: None recommended
Fire and Explosion Hazards: Product contains approximately 25% ingredients with flash point
of 120OF. It will not burn after the water has evaporated, residue
might be a fire hazard.
Page 3 MSDS No.:021599A
______________________________________________________________________________
Section VI - Reactivity Data
Stability: Unstable Hazardous May Occur
Stable X Polymerization: Will Not Occur X
Hazardous Decomposition of Byproducts: Oxides of carbon
Conditions to Avoid: Product may decompose if exposed to extremely high temperatures.
______________________________________________________________________________
Section VII - Special Protection Information
Respiratory Protection: Normally not required
Eye Protection: Chemical splash goggles are recommended
Protective Gloves: Neoprene gloves are recommended
Ventilation: Local or mechanical ventilation recommended.
Work/hygienic practices:Use with adequate ventilation. Prevent contact with eyes, skin, and
clothing. Have eye washing safety shower readily available.
Other: As required by work place standards.
______________________________________________________________________________
Section VIII - Special Precautions
Handling and Storage: Store in cool, dry area.
Conditions to Avoid: Avoid eye or skin contact. Avoid sources of ignition. Protect containers
from physical damage.
______________________________________________________________________________
Section IX - Spill, Leak, and Disposable Procedures
For Spills or Leakage: Use protective equipment to avoid skin contact. Spills can be cleaned up
with vermiculite or other non-flammable absorbent material and
removed to an approved disposal container. Do not
put spills down drains. Move leaking containers to well ventilated
area. Avoid inhalation. Avoid ignition sources.
Waste Disposal Method: Consult federal, state and local regulations for allowed means of
disposal.
______________________________________________________________________________
Section X - Transportation Information
DOT Proper Shipping Name: Petroleum Distillates UN #1268
Hazard Classification: Class 3 Flammable Liquid
|