RED LINE SYNTHETIC OIL CORPORATION
6100 Egret Court
Benicia, CA 94510
(707)745-6100
MATERIAL SAFETY DATA SHEET
___________________________________________________________________________________________________
PRODUCT TRADE NAME: RED LINE SI-2
PRODUCT TYPE: Gasoline fuel injector cleaner and valve detergent
REVISION DATE: July 11, 2005
CHEMICAL NAME: Mixture
NFPA CODE: Health: 2 Fire: 2 Reactivity: 0
___________________________________________________________________________________________________
SECTION 1 - HAZARDOUS INGREDIENTS
___________________________________________________________________________________________________
This material does not contain any chemical listed as a carcinogen or potential carcinogen by OSHA, IARC
Monographs, or National Toxicology program at a concentration > 0.1%.
30 - 50% PolyEther Amine
` 1-10% Isooctanol - TLV- None established CAS # 104-76-7
5-20% Aliphatic Naphtha - TWA - 100 ppm - CAS # 64742-88-7
___________________________________________________________________________________________________
SECTION 2 - FIRE AND EXPLOSION HAZARDS
___________________________________________________________________________________________________
FLASH POINT: 250掳F (121掳C)
UPPER FLAMMABLE LIMIT: Not Determined.
LOWER FLAMMABLE LIMIT: Not Determined.
EXTINGUISHING MEDIA: CO2, dry chemical, foam.
SPECIAL FIREFIGHTING PROCEDURES: Wear self-contained breathing apparatus with full face piece
UNUSUAL FIRE & EXPLOSION HAZARDS: Toxic fumes, gases, or vapors may evolve on burning. Container may rupture on
heating.
___________________________________________________________________________________________________
SECTION 3 - HEALTH HAZARD DATA
___________________________________________________________________________________________________
ORAL TOXICITY: LD 50 > 5000 mg/kg in rats. Based on data from components.
EYE IRRITATION: May cause eye irritation.
SKIN IRRITATION: May cause skin irritation.
DERMAL TOXICITY: LD 50 in rabbits is > 2000 mg/kg. Based on data from components.
INHALATION TOXICITY: No data available to indicate product may be a toxic inhalation hazard.
OTHER: Nose, throat, and lung irritant. Based on data from components.
CHRONIC TOXICITY: No data are available to indicate any components present at greater than 1% are a chronic health
hazard.
TLV: None established.
___________________________________________________________________________________________________
FIRST AID PROCEDURES
___________________________________________________________________________________________________
SKIN: Wash well with soap and water. See a physician if irritation persists.
EYE: Flush well with water for at least 15 minutes.
INHALATION: Remove to fresh air. See a physician if irritaiton persists. If breathing has stopped, apply artificial
respiration.
ORAL: Call a physician. Do not induce vomiting. If conscious, give two glasses of water.
ADDITIONAL: Note to physician. Treat symptomatically.
___________________________________________________________________________________________________
SECTION 4 - SPECIAL PROTECTION INFORMATION
___________________________________________________________________________________________________
VENTILATION PROCEDURE: Mechanical ventilation recommended.
GLOVES PROTECTION: Neoprene or nitrile rubber gloves recommended.
EYE PROTECTION: Safety glasses recommended.
OTHER PROTECTION: NIOSH-approved organic vapor respirator if TLV exceeded. Long-sleeved shirt.
Page 1
PRODUCT TRADE NAME: RED LINE SI-2
REVISION DATE: July 11, 2005
___________________________________________________________________________________________________
SECTION 5 - PHYSICAL DATA
___________________________________________________________________________________________________
VAPOR PRESSURE: Not Determined
SPECIFIC GRAVITY: 0.89
VISCOSITY @ 40掳C: >19 cSt
WATER SOLUBILITY: Insoluble
PERCENT VOLATILE: Not Determined.
VAPOR DENSITY: Not Determined.
EVAPORATION RATE: Not Determined.
ODOR: Strong.
APPEARANCE: Reddish-colored liquid.
___________________________________________________________________________________________________
SECTION 6 - STABILITY
___________________________________________________________________________________________________
STABILITY: Normally stable at moderately elevated temperatures and pressures.
INCOMPATIBILITY: Strong oxidizing agents.
POLYMERIZATION: Will not occur.
THERMAL DECOMPOSITION: Smoke and oxides of carbon, hydrogen, and nitrogen.
___________________________________________________________________________________________________
SPILL OR LEAK PROCEDURES
___________________________________________________________________________________________________
SPILL PROCEDURES: Ventilate area. Remove sources of ignition. Wear self-contained breathing apparatus, and gloves.
Prevent entry into sewers and waterways. Pick up free liquid for recycle/disposal. Absorb small
amounts on inert material for disposal.
WASTE DISPOSAL: If disposed of, this material is not believed to be a hazardous waste under RCRA. Waste management
should be in compliance with federal, state, and local laws.
CERCLA REPORTING:None.
___________________________________________________________________________________________________
SPECIAL PRECAUTIONS
___________________________________________________________________________________________________
SPECIAL PRECAUTIONS: DO NOT HEAT! Store in a cool (below 120掳F), dry, place away from flame. Keep containers
closed when not in use. Open container in a welll-ventilated area. Remove contaminated
clothing and launder before reuse.
___________________________________________________________________________________________________
TRANSPORTATION AND LABELING
___________________________________________________________________________________________________
DOT PROPER SHIPPING NAME: Not Applicable.
DOT HAZARD CLASS: Not Applicable.
DOT ID NUMBER (UN NO.): Not Applicable.
IMO CLASS: Not Applicable.
EPA HAZARDOUS SUBSTANCES: Not known to contain >1% of any SARA Extremely Hazardous Substances.
SARA SECTION 313: None
U.S. TSCA INVENTORY: All components are included on the U.S. TSCA Inventory.
PRECAUTIONARY LABELS: May cause eye irritation. May cause respiratory tract irritation.
The information presented herein has been compiled from sources considered dependable and is accurate to the best of Red
Line's knowledge; however, Red Line makes no warranty whatsoever, expressed or implied, of merchantability or fitness for the
particular purpose, regarding the accuracy of such data or the results to be obtained from the use thereof. Red Line assumes no
responsibility for injury to recipient or to third persons or for any damage to any property and buyer assumes all such risks.
Page 2
|