Material Safety Data Sheet
Date last reviewed: January 1, 2005
I. General Information
Chemical Name & Synonyms Trade Name & Synonyms
Proprietary Mixture Peel Away 21
Chemical Family Formula
Organic Solvent/Aqueous mixture Mixture
Proper DOT Shipping Name DOT Hazard Classification
Not Regulated Not Regulated
Manufacturer Manufacturer鈥檚 Phone Number
Dumond Chemicals, Inc. (212) 869-6350
Manufacturer鈥檚 Address Emergency Number:
1501 Broadway, New York, NY 10036 (800) 457-4280
II. Ingredients
Principal Hazardous Components CAS # Percent PEL TLV Other
10 mg/m3
1119-40-0
20-50 None Established None Established
Dibasic Ester 627-93-0 (manufacturer)
N/A 50-80 None Established None Established
Non-hazardous Ingredients
SARA 313: This product contains no chemicals that are regulated under SARA Title III, section 313.
III. Physical Data
Boiling Point (掳F) Specific Gravity (H20 =1)
Not available Greater than 1
Vapor Pressure (mm Hg @ 20潞C) Percent Volatile by Volume (%)
Similar to water Approximately 95%
Vapor Density (Air=1) Evaporation Rate (Butyl Acetate =1)
Unknown Similar to water
Solubility in Water pH
Partial 4.0
Appearance & Odor
Light green paste with a light, sweet odor.
IV. Fire & Explosion Hazard Data
Flash Point (Test Method) Autoignition Temperature
Greater than 200 Not available
Flammable Limits LEL UEL
1.2% 7.9%
Extinguishing Media
Water spray or fog, foam, carbon dioxide or dry chemical.
Special Fire Fighting Procedures
Wear full emergency equipment and NIOSH approved positive pressure SCBA. Cool
containers with water.
Unusual Fire & Explosion Hazards
At elevated temperatures containers may rupture. Decomposition products may be hazardous.
HMIS Ratings Health: 2 Flammability: 1 Reactivity: 0
V. Health Hazard Data
OSHA Permissible Exposure Limit ACGIH Threshold Limit Value
See Section II See Section II
Carcinogen - NTP Program Carcinogen - IARC
No No
Symptoms of Exposure
Acute Effects: Eyes: May cause irritation and blurred vision. Skin: May cause irritation with discomfort or rash.
Inhalation: May cause irritation to the eyes, mucous membranes and upper respiratory tract and blurring vision.
Ingestion: May cause irritation, nausea or vomiting.
Chronic Effects: Repeated skin contact may cause dermatitis.
Medical Conditions Aggravated By Exposure:
Individuals with chronic respiratory or skin diseases may be at risk from exposure.
Primary Route(s) of Entry
Eye, skin, ingestion
Emergency First Aid
Eye: Immediately flush with water for 15 minutes. Get immediate medical attention. Skin: Wash thoroughly w/soap & water.
Remove contaminated clothing. Get medical attention for irritation. Inhalation: Remove to fresh air. Get immediate medical
attention. Ingestion: If conscious, give 2 glasses of water. Do not induce vomiting. Get immediate medical attention.
IV. Reactivity Data
Stability Unstable Conditions to Avoid
X Stable N/A
Incompatibility
Strong acids, bases, oxidizers or reducing agents.
Hazardous May Occur Conditions to Avoid
Polymerization Will Not Occur
X N/A
Hazardous Decomposition
Carbon dioxide, carbon monoxide and oxides of nitrogen.
VII. Environmental Protection Procedures
Spill Response
Wear appropriate protective clothing. Remove ignition sources. Collect with an inert absorbent. Wash spill
area with water. Prevent runoff from entering sewers or waterways. Report spills as required.
Waste Disposal Method
Dispose of in accordance with all state, local and federal regulations.
VIII. Special Protection Information
Eye Protection Skin Protection
Chemical safety glasses/goggles Butyl rubber gloves required.
Respiratory Protection (Specific Type) Ventilation Recommended
For spray application, a NIOSH approved organic Good general ventilation is usually adequate. If exposure
vapor respirator may be used. limits are exceeded, local exhaust may be required.
Other Protection
Impervious apron, boots, safety shower, eye wash as needed.
IX. Special Precautions
Hygienic Practices in Handling & Storage
Store in a cool, well ventilated area away from oxidizers and other incompatible substances.
Work Practices
Avoid eye and skin contact. Avoid breathing vapors. Wash thoroughly after handling.
Other Precautions
Use only with appropriate protective equipment. Wash thoroughly after use.
|