MSDS No.: 302
Revision No.: 002
Revision Date: 02/28/05
庐 Page: 1of 2
MATERIAL SAFETY DATA SHEET
Product name: CP 648-S & CP 648-E Firestop Wrap Strip
1鈥? or 1 3/4鈥? wide - intumescent wrap for plastic or insulated pipe
Description:
Hilti, Inc. P.O. Box 21148, Tulsa, OK 74121
Supplier:
1 800 424 9300 (USA, PR, Virgin Islands, Canada); 703 527 3887 (Other countries)
Emergency # (Chem-Trec.):
INGREDIENTS AND EXPOSURE LIMITS
Not a hazardous chemical as defined by the OSHA Hazard Communication Standard 29 CFR 1910.1200
PHYSICAL DATA
Dark gray colored putty strips. Mild odor.
Appearance: Odor:
Not applicable. Not applicable.
Vapor Density: (air = 1) Vapor Pressure:
Not applicable. 7.6 g/l.
Boiling Point: VOC Content:
Not applicable. Not determined.
Evaporation Rate: Solubility in Water:
3
1.3-1.4 g/cm Not determined.
Density: pH:
FIRE AND EXPLOSION HAZARD DATA
Not applicable. Not applicable.
Flash Point: Flammable Limits:
Use extinguishing media appropriate for the surrounding fire.
Extinguishing Media:
None known.
Special Fire Fighting
Procedures:
None known. Product serves as a firestop; intumescent material begins to expand when
Unusual Fire and Explosion
exposed to temperatures > 160潞 C (320潞 F)
Hazards:
REACTIVITY DATA
Stable. Will not occur.
Stability: Hazardous Polymerization:
None known. None known.
Incompatibility: Conditions to Avoid:
None known.
Decomposition Products:
HEALTH HAZARD DATA
Irritation of the eyes and skin is possible with some individuals.
Known Hazards:
Signs and Symptoms of Eyes: Can cause irritation and watering but injury is unlikely. Skin: Irritation. is possible with
Exposure: some individuals. Inhalation: No effects expected. Ingestion: Not a likely route of exposure.
Can cause irritation. Considered to have a low acute oral toxicity.
Contact.
Routes of Exposure:
No ingredients are classified as a carcinogen by IARC, NTP or OSHA.
Carcinogenicity:
None known.
Medical Conditions
Aggravated by Exposure:
EMERGENCY AND FIRST AID PROCEDURES
Immediately flush with plenty of water. Call a physician if symptoms occur.
Eyes:
Wash with soap and water. Seek medical attention if any effects persist.
Skin:
Not applicable
Inhalation:
Only induce vomiting if directed by a physician. Contact a physician immediately.
Ingestion:
Referral to a physician is recommended if there is any question about the seriousness of the
Other:
injury/exposure.
HILTI 庐 is a registered trademark of Hilti Corp.
CONTROL MEASURES AND PERSONAL PROTECTIVE EQUIPMENT
General (natural or mechanically induced fresh air movements).
Ventilation:
Not required, however, safety glasses should be worn in most industrial settings.
Eye Protection:
Cloth gloves are suitable; impermeable (neoprene or rubber) gloves recommended.
Skin Protection:
Not required.
Respiratory Protection:
PRECAUTIONS FOR SAFE HANDLING AND USE
Avoid prolonged or repeated contact with the skin. Do not rub the eyes after contact with the
Handling and Storing
hands. Practice good hygiene; i.e. wash after using and before eating or smoking. Store above
Precautions:
32潞 F and below 140潞 F (0 - 60潞 C). For industrial use only. Keep out of reach of children.
No special requirements.
Spill Procedures:
REGULATORY INFORMATION
Not a hazardous chemical as defined by the federal OSHA Hazard Communication Standard 29
Hazard Communication:
CFR 1910.1200.
Health 1, Flammability 0, Reactivity 0, PPE B
HMIS Codes:
Not regulated.
DOT Shipping Name:
Not regulated.
IATA / ICAO Shipping Name:
Chemical components listed on TSCA inventory.
TSCA Inventory Status:
This product does not contain any ingredients which are subject to reporting under Section 313 of
SARA Title III, Section 313:
SARA Title III (40 CFR Part 372).
Not regulated by EPA as a hazardous waste
EPA Waste Code(s):
Consult with regulatory agencies or your corporate personnel for disposal methods that comply
Waste Disposal Methods:
with local, state, and federal safety, health and environmental regulations.
CONTACTS
1 800 879 8000 1 800 879 8000
Customer Service: Technical Service:
1 800 879 6000 Jerry Metcalf (x6704)
Health / Safety:
1 800 424 9300 (USA, PR, Virgin Islands, Canada); 703 527 3887 (Other countries)
Emergency # (Chem-Trec):
The information and recommendations contained herein are based upon data believed to be correct; however, no guarantee or
warranty of any kind expressed or implied is made with respect to the information provided.
MSDS302, Page 2 of 2
|