49-110 Page: 1
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: POOLPOXY SOLVENTBORNE PRIMER WHITE A HMIS CODES: H F R P
PRODUCT CODE: 49-110 2*3 1
=================== SECTION I - MANUFACTURER IDENTIFICATION ==================
MANUFACTURER'S NAME: NELSONITE POOL AND DECK COATING
ADDRESS : 3150 E. PICO BLVD.
LOS ANGELES, CA 90023-3683
EMERGENCY PHONE(CHEMTREC) : (800) 424-9300 DATE PRINTED : 10/27/06
INFORMATION PHONE : (800) 544-1998 NAME OF PREPARER : N/A
=========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION ==========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mmHG @TEMP(F) PERCENT
----------------------------------------------------------------------------------
TITANIUM DIOXIDE (as total nuisance dust) 13463-67-7 NA NA 10
OSHA PEL: 10 ppm, ACGIH TLV: 10 mg/m3
~ XYLENE 1330-20-7 6.1 68 8.65
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
~ METHYL ETHYL KETONE 78-93-3 70.9 68 5.77
OSHA PEL: 200 ppm, ACGIH TLV: 200 ppm
PM ACETATE 108-65-6 3.7 68 3.3
OSHA PEL: N/E, ACGIH TLV: N/E
~ ETHYL BENZENE 100-41-4 10 68 0.20
OSHA PEL: 100 ppm, ACGIH TLV: 100 ppm
CRYSTALLINE SILICA,QUARTZ 14808-60-7 NA NA 0.13
OSHA PEL: 0.1 mg/m3, ACGIH TLV: 0.1 mg/m3
~Indicates toxic chemical(s) subject to the reporting requirements of section
313 of Title III and of 40 CFR 372.
================ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS =============
BOILING RANGE (Deg F): 175 - 286 DENSITY: 13.35 lb/gl
VAPOR DENSITY: HEAVIER THAN AIR SPECIFIC GRAVITY (H2O=1): 1.60
COATING V.O.C.: 2.44 lb/gl MATERIAL V.O.C.: 2.44 lb/gl
COATING V.O.C.: 292 g/l MATERIAL V.O.C.: 292 g/l
SOLUBILITY IN WATER: Insoluble EVAPORATION RATE: SLOWER THAN ETHER
APPEARANCE AND ODOR: White liquid with acetone odor.
================== SECTION IV - FIRE AND EXPLOSION HAZARD DATA ===============
FLASH POINT (Deg F): N/A METHOD USED: N/A
FLAMMABLE LIMITS IN AIR BY % VOLUME- LOWER: 1 UPPER: 11.5
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL
SPECIAL FIREFIGHTING PROCEDURES
Wear self-contained breathing equipment in confined areas to avoid inhalation of
smoke or fumes.
UNUSUAL FIRE AND EXPLOSION HAZARDS
Isolate from heat, sparks, electrical equipment and open flames. Vapors formed
by this product may travel and be ignited by sources distant from the handling
or use point.
49-110 Page: 2
========================= SECTION V - REACTIVITY DATA ========================
STABILITY: STABLE
CONDITIONS TO AVOID
Sparks, flames, excessive heat, poor ventilation.
INCOMPATIBILITY (MATERIALS TO AVOID)
Strong oxidizing agents
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
Thermal decomposition may yield carbon dioxide and/or carbon monoxide.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
===================== SECTION VI - HEALTH HAZARD DATA ========================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Its use in poorly ventilated areas can cause nausea, headache and dizziness.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Short-term contact will result in eye irritation. Prolonged and repeated contact
can cause a drying of the skin and irritation.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
This is a primary source of entry and may cause irritation.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Adverse health effects from ingestion may include respiratory irritation, nausea
and vomiting. Not expected to be acutely toxic by ingestion.
HEALTH HAZARDS (ACUTE AND CHRONIC)
Acute: May cause eye, nose and skin irritation, headache, nausea and vomiting.
Chronic: Reports have associated repeated and prolonged occupational over-
exposure to solvents with permanent brain and nervous system damage.
CARCINOGENICITY: NTP CARCINOGEN: Yes IARC MONOGRAPHS: Yes OSHA REGULATED: No
This material contains crystalline silica, which has been classified as a known
carcinogen for humans (1) by IARC and a probable carcinogen by NTP. Crystalline
silica is also a known cause of silicosis, a non-cancerous lung disease caused
by excessive exposure to crystalline silica.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
Pre-existing eye, skin and respiratory disorders may be aggravated.
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: MOVE PERSON TO FRESH AIR. PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN
IF BREATHING IS DIFFICULT. EYE & SKIN CONTACT: FLUSH EYES IMMEDIATELY WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. WASH AFFECTED AREAS WITH SOAP
ANS WATER IMMEDIATELY. REMOVE CONTAMINATED CLOTHING. INGESTION: IF SWALLOWED,
DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IF IRRITATION PERSISTS.
============ SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE =============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
ELIMINATE ALL SOURCES OF IGNITION. ABSORB WITH INERT MATERIAL (SAND,
VERMICULITE, ETC.), SWEEP OR SCOOP UP AND PUT IN DISPOSAL CONTAINER. FLUSH AREA
OF SPILL WITH WATER.
49-110 Page: 3
WASTE DISPOSAL METHOD
Incinerate in an approved incinerator or dispose of in accordance with local,
state and federal regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
KEEP FROM FREEZING! Keep away from heat, sparks and open flame. Close container
after each use. Keep away from children.
OTHER PRECAUTIONS
Do not take internally. Avoid prolonged contact.
====================== SECTION VIII - CONTROL MEASURES =======================
VENTILATION
Local exhaust at point of use in closed spaces.
RESPIRATORY PROTECTION
All purpose canister mask or air supplied mask, if TLV limits are exceeded.
PROTECTIVE GLOVES
Chemical resistant gloves
EYE PROTECTION
Safety glasses
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
Eye bath and safety shower
WORK/HYGIENIC PRACTICES
Wash hands thoroughly before eating or using the washroom. Smoke in smoking
areas only.
==================== SECTION IX - REGULATORY INFORMATION =====================
CALIFORNIA PROPOSITION 65
This product contains a chemical known to the State of California to cause
cancer.
Contains: Ethylbenzene - Silica, Crystalline -
========================== SECTION X - DISCLAIMER ============================
The information contained herein is based on the data available to us and is
believed to be correct. However, NELSONITE POOL AND DECK COATING makes no
warranty expressed or implied regarding the accuracy of these data or the
results to be obtained from the use thereof. NELSONITE POOL AND DECK COATING
assumes no responsibility for injury from the use of the product described
herein.
|