49-139 Page: 1
MATERIAL SAFETY DATA SHEET
PRODUCT NAME: WATERBORNE EPOXY LOCK ON--PART B HMIS CODES: H F R P
PRODUCT CODE: 49-139 2*1 0
=================== SECTION I - MANUFACTURER IDENTIFICATION ==================
MANUFACTURER'S NAME: NELSONITE COATINGS (A DIVISION OF ELLIS PAINT CO.)
ADDRESS : 3150 E. PICO BLVD.
LOS ANGELES, CA 90023-3683
EMERGENCY PHONE(CHEMTREC) : (800) 424-9300 DATE PRINTED : 07/27/06
INFORMATION PHONE : (800) 544-1998 NAME OF PREPARER : N/A
=========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION ==========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mmHG @TEMP(F) PERCENT
----------------------------------------------------------------------------------
~ ALKYL GLYCIDYL ETHER 68609-97-2 NA NA 2.82
OSHA PEL: NE, ACGIH TLV: NE
~Indicates toxic chemical(s) subject to the reporting requirements of section
313 of Title III and of 40 CFR 372.
================ SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS =============
BOILING RANGE (Deg F): 420-580 DENSITY: 8.38 lb/gl
VAPOR DENSITY: HEAVIER THAN AIR SPECIFIC GRAVITY (H2O=1): 1.01
COATING V.O.C.: 2.26 lb/gl MATERIAL V.O.C.: 0.39 lb/gl
COATING V.O.C.: 270 g/l MATERIAL V.O.C.: 47 g/l
SOLUBILITY IN WATER: Soluble EVAPORATION RATE: SLOWER THAN ETHER
APPEARANCE AND ODOR: Clear liquid with mild odor
================== SECTION IV - FIRE AND EXPLOSION HAZARD DATA ===============
FLASH POINT (Deg F): >200 METHOD USED: TCC
FLAMMABLE LIMITS IN AIR BY % VOLUME- LOWER: n/a UPPER: n/a
EXTINGUISHING MEDIA: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES
Wear self-contained breathing equipment in confined areas to avoid inhalation of
smoke or fumes. Water should be used to keep fire-exposed containers cool.
UNUSUAL FIRE AND EXPLOSION HAZARDS
Isolate from heat, sparks, electrical equipment and open flames. Vapors formed
by this product may travel and be ignited by sources distant from the handling
or use point.
========================= SECTION V - REACTIVITY DATA ========================
STABILITY: STABLE
CONDITIONS TO AVOID
Sparks, flames, excessive heat, poor ventilation.
INCOMPATIBILITY (MATERIALS TO AVOID)
Strong oxidizing agents, alkalis and reactive metals.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
Thermal decomposition may yield carbon dioxide and/or carbon monoxide.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
49-139 Page: 2
===================== SECTION VI - HEALTH HAZARD DATA ========================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Its use in poorly ventilated areas can cause nausea, headache and dizziness.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Short-term contact will result in eye irritation. Prolonged and repeated contact
can cause a drying of the skin and irritation.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Irritation as noted. Skin sensitization(allergy) may be evidenced by rashes,
especially hives.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
Adverse health effects from ingestion may include respiratory irritation, nausea
and vomiting. Not expected to be acutely toxic by ingestion.
HEALTH HAZARDS (ACUTE AND CHRONIC)
Acute: May cause eye, nose and skin irritation, headache, nausea and vomiting.
Chronic: Reports have associated repeated and prolonged occupational over-
exposure to solvents with permanent brain and nervous system damage.
CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: No OSHA REGULATED: Yes
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
Pre-existing eye, skin and respiratory disorders may be aggravated.
EMERGENCY AND FIRST AID PROCEDURES
INHALATION: MOVE PERSON TO FRESH AIR. PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN
IF BREATHING IS DIFFICULT. EYE & SKIN CONTACT: FLUSH EYES IMMEDIATELY WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. WASH AFFECTED AREAS WITH SOAP
AND WATER IMMEDIATELY. REMOVE CONTAMINATED CLOTHING. INGESTION: INDUCE
VOMITING, iF LARGE AMOUNTS ARE INGESTED. GET MEDICAL ATTENTION IMMEDIATELY.
============ SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE =============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
ELIMINATE ALL SOURCES OF IGNITION. ABSORB WITH INERT MATERIAL (SAND,
VERMICULITE, ETC.), SWEEP OR SCOOP UP AND PUT IN DISPOSAL CONTAINER. FLUSH AREA
OF SPILL WITH WATER.
WASTE DISPOSAL METHOD
Incinerate in an approved incinerator or dispose of in accordance with local,
state and federal regulations.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
COMBUSTIBLE! Keep away from heat, sparks and open flame. Keep containers tightly
closed. Keep away from children.
OTHER PRECAUTIONS
Do not take internally. Avoid prolonged contact with skin.
====================== SECTION VIII - CONTROL MEASURES =======================
VENTILATION
Local exhaust at point of use in closed spaces.
RESPIRATORY PROTECTION
All purpose canister mask or air supplied mask, if TLV limits are exceeded.
49-139 Page: 3
PROTECTIVE GLOVES
Chemical resistant gloves
EYE PROTECTION
Safety glasses and splashproof goggles
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
Eye bath and safety shower
WORK/HYGIENIC PRACTICES
Wash hands thoroughly before eating or using the washroom. Smoke in smoking
areas only.
==================== SECTION IX - REGULATORY INFORMATION =====================
CALIFORNIA PROPOSITION 65
None
========================== SECTION X - DISCLAIMER ============================
The information contained herein is based on the data available to us and is
believed to be correct. However, NELSONITE COATINGS (A DIVISION OF ELLIS PAINT
CO.) makes no warranty expressed or implied regarding the accuracy of these data
or the results to be obtained from the use thereof. NELSONITE COATINGS (A
DIVISION OF ELLIS PAINT CO.) assumes no responsibility for injury from the use
of the product described herein.
|