MATERIAL SAFETY DATA SHEET
This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174
IDENTITY AND MANUFACTURER'S INFORMATION
NFPA Rating: Health-1; Flammability-0; Reactivity-0; Special- - HMIS Rating: Health-1; Flammability-0; Reactivity-0; Personal Protection-B
Manufacturer's Name: AMREP, INC. DOT Hazard Classification: Corrosive Material 8
Address: 990 Industrial Park Drive Identity (trade name as used on label):
Marietta, GA 30062 MISTY BIODET APC
Date Prepared: 03/24/97 Prepared By: DL/LF/IB MSDS Number: R 249 Revision - 1
Information Calls: (770)422-2071 NOTICE: JUDGEMENT BASED ON INDIRECT TEST DATA
EMERGENCY RESPONSE NUMBER: 1(800)255-3924
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES CAS Number SARA OSHA PEL ACGIH Carcinogen
III LIST (ppm) TLV (ppm) Ref. Source **
(Hazardous Components 1% or greater; Carcinogens 0.1% or greater)
N-ALKYL DIMETHYL BENZYL AMMONIUM CHLORIDE 8001-54-5 No N/E N/E d
DIDECYL DIMETHYL AMMONIUM CHLORIDE 7173-51-5 No N/E N/E d
OCTYL DIMETHYL AMINE OXIDE 2605-78-9 No N/E N/E d
DIETHYLENE GLYCOL N-BUTYL ETHER 112-34-5 Yes N/E N/E d
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: 212潞F Specific Gravity (H2O=1): 1.005
Vapor Pressure: PSIG @ 70掳F (Aerosols): N/A Vapor Pressure (Non-Aerosols)(mm Hg and Temperature): N/E
Vapor Density (Air = 1): N/E Evaporation Rate ( water = 1): 1
Solubility in Water: Miscible Water Reactive: No
Appearance and Odor: Clear liquid with lemon odor.
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY as per USA FLAME PROJECTION TEST Auto Ignition Temperature Flammability Limits in Air by % in Volume:
(aerosols) N/A N/A % LEL: N/A % UEL: N/A
FLASH POINT AND METHOD USED (non-aerosols): None to boiling (TCC). SPECIAL FIRE FIGHTING PROCEDURES: Firefighters should wear NIOSH
EXTINGUISHER MEDIA: Water, dry chemical, foam, carbon dioxide. approved supplied atmosphere breathing apparatus.
Unusual Fire & Explosion Hazards: Decomposition & oxidation by products in a fire can liberate noxious & toxic fumes.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY [ X ] STABLE [ ] UNSTABLE HAZARDOUS POLYMERIZATION [ ] WILL [ X ] WILL NOT OCCUR
Incompatibility (Mat. to avoid): Aluminum, metal, anionics, acids and strong Conditions to Avoid: None known.
oxidizers.
Hazardous Decomposition Products: Oxides of carbon, ammonia, oxides of nitrogen.
SECTION 5 - HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: [ ] INHALATION [ X ] INGESTION [ ] SKIN ABSORPTION [ X ] EYE [ ] NOT HAZARDOUS
ACUTE EFFECTS
Inhalation: Should not cause respiratory irritation.
Eye Contact: May cause severe eye irritation. Skin Contact: May cause irritation.
Ingestion: Harmful if swallowed.
CHRONIC EFFECTS: None known.
Medical Conditions Generally Aggravated by Exposure: Pre-existing irritation of skin and mucous membranes.
EMERGENCY FIRST AID PROCEDURES
Eye Contact: Flush with water for 15 minutes. If irritation persists, get medical attention.
Skin Contact: Wash contaminated areas with soap and water. If irritation persists, get medical attention.
Inhalation: Remove to fresh air.
Ingestion: DO NOT INDUCE VOMITING. Drink large quantity of milk, egg whites, gelatin solution or water. Get immediate medical attention.
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (specify type): None required.
Protective Gloves: Rubber or neoprene. Eye Protection: Safety glasses or goggles.
Ventilation Requirements: Normal room ventilation is adequate.
Other Protective Clothing & Equipment: None required.
Hygienic Work Practices: Do not eat, drink or smoke in work area. Wash hands after handling.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken If Material Is Spilled Or Released: Contain spill. Keep out of sewers & open bodies of water. Soak up spill on inert absorbent material. Place
in leak-proof container.
Waste Disposal Methods: Dispose of in accordance with all local, state and federal regulations.
Precautions To Be Taken In Handling & Storage: Store in original shipping containers. Keep closed when not in use. Shelf life 1 year. Protect from extreme
heat and cold.
Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN. Read & follow label directions.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind.
** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP