MATERIAL SAFETY DATA SHEET
This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174
IDENTITY AND DISTRIBUTOR鈥橲 INFORMATION
NFPA Rating: Health-1; Flammability-1; Reactivity-0; Special-- HMIS Rating: Health-1; Flammability-1; Reactivity-0; Personal Protection- -
Manufacturer鈥檚 Name: AMREP, INC. DOT Hazard Classification: ORM-D
Address: 990 Industrial Park Drive Identity (trade name as used on label):
Address: Marietta, Ga. 30062 I-CHEM RTV CLEAR LOW VISIBILITY # ICA773
Phone: 770-422-2071 MSDS Number: A00773 Revision-3
Emergency Response Number:1-800-255-3924 Date Prepared: 10/29/01 Prepared By: RC/IB
Information Calls: (770) 422-2071
NOTICE: JUDGEMENT BASED ON INDIRECT TEST DATA
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION
CAS Number SARA OSHA PEL ACGIH Carcinogen
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES
III LIST (ppm) TLV (ppm) Ref. Source **
(Hazardous Components 1% or greater; Carcinogens 0.1% or greater)
7631-86-9 No 6mg/m3 10mg/m3 d
SILICA, AMORPHOUS
4253-34-3 No 10 10 d
METHYLTRIACETOXYSILANE
17689-77-9 No 10 10 d
ETHYLTRIACETOXYSILANE
Note: Pressurizing Propellant (Gas is not expelled with product)
75-28-5 No 800 800 d
ISOBUTANE/PROPANE BLEND
74-98-6 No 1000 1000 d
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: N/A Specific Gravity (H2O=1): 1.03
Vapor Pressure: PSIG @ 70掳F (Aerosols): N/A Vapor Pressure (Non-Aerosols)(mm Hg and Temperature): <5
Vapor Density (Air = 1): N/A Evaporation Rate ( = 1): N/A
Solubility in Water: <0.1 Water Reactive: Yes
Appearance and Odor: Colored paste with acetic acid-like odor.
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA
FLAMMABILITY as per USA FLAME Auto Ignition Temperature Flammability Limits in Air by % in Volume:
PROJECTION TEST (aerosols) N/A N/D % LEL: N/D % UEL: N/D
FLASH POINT AND METHOD USED (non-aerosols): N/A SPECIAL FIRE FIGHTING PROCEDURES: Self-contained breathing apparatus
& protective clothing should be worn in fighting fires involving chemicals.
EXTINGUISHER MEDIA: Water, water fog, CO2, dry chemical, foam.
Unusual Fire & Explosion Hazards: Containers may rupture if heated above 130潞F.
SECTION 4 - REACTIVITY HAZARD DATA
STABILITY [ X ] STABLE [] UNSTABLE HAZARDOUS POLYMERIZATION [ ] WILL [ X ] WILL NOT
OCCUR
Incompatibility (Mat. to avoid): Oxidizing materials can cause a Conditions to Avoid: Exposure to air or moisture until ready to use.
reaction. Air or moisture causes curing & acetic acid vapors form.
Hazardous Decomposition Products: Metal oxides, silicon dioxide, carbon dioxide, traces of incompletely burned carbon products, includes
formaldehyde.
SECTION 5 - HEALTH HAZARD DATA
PRIMARY ROUTES OF ENTRY: [ X ] INHALATION [ ] INGESTION [ ] SKIN ABSORPTION [ ] EYE [ ] NOT HAZARDOUS
ACUTE EFFECTS: None known.
Inhalation: Vapor overexposure may irritate eyes, nose, throat.
Eye Contact: Direct contact irritates slightly with swelling and redness. Skin Contact: Short exposure may irritate. Repeated prolonged
contact may irritate moderately.
Ingestion: Swallowing large amounts may seriously injure.
CHRONIC EFFECTS: None known.
Medical Conditions Generally Aggravated by Exposure: Nose, throat, skin and digestive system.
EMERGENCY FIRST AID PROCEDURES
Eye Contact: Flush with water for 15 minutes. Get medical attention.
Skin Contact: Wipe off & flush with water. If irritation develops, get medical attention.
Inhalation: Remove to fresh air. If ill effects persist, get medical attention.
Ingestion: DO NOT INDUCE VOMITING. Drink large quantitiy of water. Get immediate medical attention.
SECTION 6 - CONTROL AND PROTECTIVE MEASURES
Respiratory Protection (specify type): None needed.
Protective Gloves: Rubber or plastic. Eye Protection: Safety glasses.
Ventilation Requirements: Local exhaust adequate.
Other Protective Clothing & Equipment: None
Hygienic Work Practices: Remove contaminated clothing and shoes and clean thoroughly before reuse. Wash hands after handling.
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE
Steps To Be Taken If Material Is Spilled Or Released: Remove product and contain for salvage or disposal.
Waste Disposal Methods: Dispose of in accordance with all local, state and federal regulations.
Precautions To Be Taken In Handling & Storage: Store below 90潞F.
Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN. Product forms acetic acid when exposed to water or
humid air. Provide ventilation during use to control acetic acid exposure limits within 10 PPM.
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any
kind.
** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only
ALL Chemical Property And Toxicity Analysis PAGES IN THIS GROUP