MATERIAL SAFETY DATA SHEET
COMPLIES WITH OSHA鈥橲 HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200)
SECTION I 路 PRODUCT IDENTIFICATION
Product Name: RTV Gasket Maker Formula: Proprietary HMIS Rating (Based on Aerosol Conc.):
Product Number: 114-Blue, 115-Red, 116-Black Date Prepared: 1-4-04 0-Minimal 1- Slight 2- Moderate
Product Type: AEROSOL Emergency Phone: (800) 255-3924 3- Serious 4- Extreme
Supplier's Name: Swift Maintenance Products, Inc. Information Phone: (954) 748-2555 HEALTH: 1 FIRE: 1 REACTIVITY: 0
Supplier's Address: 4592 N. Hiatus Road, Sunrise, FL 33351 Personal Protection: B
D.O.T. Hazard Class: CONSUMER COMMODITY 路 ORM-D
SECTION II 路 INGREDIENTS
CHEMICAL NAME CAS # %WT 313/Chem Skin Carcinogen PEL TWA/TLV
Silica, Amorphous 7631-86-9 05-10 NO NO NO **See Acetic
Ethyltriacetoxysilane 17689-77-9 01-05 NO NO NO Acid Comments Section
Methyltriacetoxysilane 4253-34-3 01-05 NO NO NO Listed Below**
Liquified Petroleum Gas 68476-85-7 01-05 NO NO NO 1000ppm 1000ppm
Acetic Acid Comments: Acetic Acid is formed upon contact with water or humid air. Provide adequate ventilation to control exposures
within OSHA guidelines. PEL: TWA 10 ppm and ACGIH TLV: TWA 10 ppm, STEL 15 ppm.
SECTION III 路 PHYSICAL DATA
Data Below Based On Aerosol Concentrate Only:
Boiling Point: ~ N/A
pH: N/A Vapor Density(Air=1): N/A
Solubility In Water: None Specific Gravity (H2O=1)@77掳F: 1.03
Appearance/Odor: Paste (Color* Dependant on Product) / Acetic Acid Odor
Data Below Based On Total Contents: *114-Blue, 115-Red, 116-Black
Vapor Pressure of can (psig @70掳F): N/A
Total VOC %: ~ N/A
SECTION IV 路 FIRE AND EXPLOSION DATA
Flash Point (of Aerosol Concentrate Only): ~ N/A Flammability: Container pressurized with a Flammable Gas, as listed in Section II, Do Not
Extinguishing Media: Foam, CO2, Dry Media, Water remove rubber plug from bottom of container, or expose to heat, sparks or flames.
Special Fire Fighting Procedures: Wear self-contained breathing apparatus and protective clothing. Cool fire exposed containers to prevent rupturing.
Unusual Fire and Explosion Hazards: Exposure to temperature above 120掳 F may cause bursting.
SECTION V 路 REACTIVITY DATA
Stability: Material Stable. Hazardous Polymerization: Will not Occur.
Incompatibility: Avoid contact with strong oxidizing agents,
Hazardous Decomposition Products: Thermal breakdown may result in production of, Sulfur Dioxides, COx, Silicon Dioxide, Formaldehyde and NOx
SECTION VI 路 STORAGE AND HANDLING
KEEP OUT OF REACH OF CHILDREN.
For Industrial and Institutional use only.
Store in a cool, dry area away from heat or open flame. NFPA Code 30B Rating: Level 1 Aerosol
Do not store at temperatures above 120掳 F.
SECTION VII 路 HEALTH AND FIRST AID
PRIMARY ROUTES OF ENTRY & EFFECTS OF OVER EXPOSURE:
Eyes: Direct contact may cause irritation associated with redness and swelling.
Skin: Frequent or prolonged contact may cause irritation.
Inhalation: Inhalation of mist can cause irritation of nasal and respiratory passages. Abusive or excessive inhalation may cause irritation to the upper respiratory tract,
dizziness, nausea and other central nervous system effects.
Ingestion: Small amounts transferred to the mouth by fingers during use, etc., should not injure. Swallowing large amounts may cause digestive discomfort.
FIRST AID PROCEDURES:
Eyes: Flush with large amounts of cool running water for at least 15 minutes while holding upper and lower lids open. Seek medical attention immediately.
Skin: Wipe off excess sealant with dry paper towel or cloth, and wash with soap and water. If irritation persists seek medical attention.
Inhalation: Remove to fresh air. Seek medical attention immediately. If breathing stops give artificial respiration.
Ingestion: Do not induce vomiting. No additional first aid should be needed.
SECTION VIII 路 SPECIAL PROTECTION DATA
Respiratory Protection: Use respiratory protection unless adequate local exhaust ventilation is provided.
Ventilation: Provide local exhaust to keep TLV of Section II ingredients below acceptable limits.
Protective Gloves: Use chemical resistant gloves if hand contact will be made.
Eye Protection: Wear safety glasses or chemical proof goggles. Use of product produces Acetic Acid vapors, as described in Section II, do not wear contact lens
when using this product.
SECTION IX 路 SPILL OR LEAK PROTECTION
STEPS TO BE TAKEN IN CASE OF SPILL OR LEAK: Maintain local exhaust and adequate ventilation. No smoking. Keep sparks, heat sources and open flame far
away from spill or leak. Dispose of material in accordance with Federal, State and local laws.
WASTE DISPOSAL METHOD: Consult Federal, State and local authorities for approved procedures.
N/A= NOT APPLICABLE 路 N/E=NOT ESTABLISHED 路 N/D=NOT DETERMINED 路 <=LESS THAN 路 >=MORE THAN
NOTICE: The information contained on this Material Safety Data Sheet is considered accurate as of the date of publication. It is not necessarily all inclusive nor fully adequate in every
circumstance. The suggestions should not be confused with, nor followed in violation of applicable laws, regulations, rules or insurance requirements. No warranty, express or implied, of
merchantability, fitness, accuracy of data, or the results to be obtained from the use thereof is made. The vendor assumes no responsibility for injury or damages resulting from the inappropriate
use of this product.
|