MATERIAL SAFETY DATA SHEET
Swift Maintenance Products, Inc.
4592 N. Hiatus Road
Sunrise, FL 33351
GENERAL INFORMATION NUMBER: (954) 748-2555 REVISION DATE: June 23, 2004
CHEMTREC: (800) 424-9300 DATE OF ISSUE: June 25, 2004
I - Product Identification
Floating Lift Station Degreaser
PRODUCT CODE: 0381
CHEMICAL FORMULATION: Citrus based degreaser.
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1 FLAMMABILITY: 2 REACTIVITY: 0
HAZARD RATING: 4 - Extreme; 3 - High; 2 - Moderate; 1 - Slight; 0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX OSHA ACGIH EPA 40 CFR:
SUBSTANCE % PEL TLV 302 355 372 CAS #
d-Limonene > 90.0 N/E N/E Y N N 5989-27-5
Key: PEL : Permissible Exposure Limit TLV: Threshold Limit Value C : Ceiling level STEL : Short Term Exposure Limit
N/A : Not Applicable N/D: Not Determined N/E : Not Established Y : Yes N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Re lease Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
掳 SPECIFIC GRAVITY (WATER = 1): 0.838-0.843
BOILING POINT (掳C): 175.5-176
VAPOR PRESSURE (mm Hg): 2.0 VOC CONTENT (% by weight): > 90.0
VAPOR DENSITY (AIR = 1): N/D EVAPORATION RATE (WATER = 1): > 1.0
SOLUBILITY IN WATER: Insoluble pH: N/A
APPEARANCE AND ODOR: Clear, reddish-orange liquid; citrus odor.
IV - Fire and Explosion Hazard Data
FLASH POINT ( 掳F): 115 (TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: 6.1 LOWER: 0.7
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Firefighters should be equipped with full protective gear including self-contained breathing
apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: Use water spray to cool fire-exposed containers. Solvent vapors may cause flashbacks.
Guard against spontaneous combustion of improperly disposed oily rags.
PRODUCT NAME: Floating Lift Station Degreaser PRODUCT CODE: 0381
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong oxidizing and acidic agents, peroxides, halogens, vinyl chloride, and iodine pentaflouride.
CONDITIONS TO AVOID: Heat, sparks or open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may yield oxides of carbon.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: EYE CONTACT: X SKIN CONTACT: X INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate to high irritation, redness, tearing.
IF ON SKIN: Irritation, drying, defatting, dermatitis with repeated or prolonged contact. Contains a potential skin sensitizer.
IF SWALLOWED: Harmful if swallowed. Gastrointestinal irritation, nausea, vomiting, diarrhea.
IF INHALED: Irritation of the nose, throat and respiratory tract, coughing and headache.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Remove contacts, if applicable. Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. If irritation
persists, obtain medical attention.
IF ON SKIN: Remove contaminated clothing and launder before re-use. Wash with large amounts of water and soap. If irritation persists,
obtain medical attention.
IF SWALLOWED: Call a physician or poison control center immediately. Do not induce vomiting. Rinse mouth with water, and then
drink one glass of water. Never give anything by mouth to an unconscious or convulsing person.
IF INHALED: Remove person to fresh air. If irritation persists, obtain medical attention.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and extinguish all sources of ignition. Contain
spill. Soak up with inert absorbent and place in a properly labeled closed container for disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation.
VENTILATION LOCAL: Recommended MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant gloves.
EYE PROTECTION: Safety glasses or chemical goggles.
OTHER PROTECTIVE EQUIPMENT: Protective clothing, eye wash and shower station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place, away from heat or open flame. Keep
container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children. Do not cut or weld on empty containers as they may contain combustible
residue.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: None
DOT CLASS: None DOT ID NUMBER: None DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper shipping
name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is further intended,
different shipping names and labeling may apply.
REVISION DATE: June 23, 2004 Prepared by: PMR DATE OF ISSUE: June 25, 2004
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this data
or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee, users or
third parties caused by the material such vendees or users assume all risks associated with the use of this material.
|