MATERIAL SAFETY DATA SHEET
Swift Maintenance Products, Inc.
4592 N. Hiatus Road
Sunrise, FL 33351
GENERAL INFORMATION NUMBER: (954) 748-2555 REVISION DATE: October 31, 2003
CHEMTREC: (800) 424-9300 DATE OF ISSUE: October 31, 2003
I - Product Identification
Snow Plow Coating
PRODUCT CODE: 0385
CHEMICAL FORMULATION: Protective coating mixture
NFPA HAZARD IDENTIFICATION SYSTEM: HEALTH: 1 FLAMMABILITY: 2 REACTIVITY: 0
HAZARD RATING: 4 - Extreme; 3 - High; 2 - Moderate; 1 - Slight; 0 - Insignificant
II - Hazardous Ingredients
Values reported as TWA unless noted.
APPROX OSHA ACGIH EPA 40 CFR:
SUBSTANCE % PEL TLV 302 355 372 CAS #
Mineral spirits > 90.0 N/E N/E N N N 8052-41-3
PEL: Permissible Exposure Limit TLV: Threshold Limit Value C: Ceiling level STEL: Short Term Exposure Limit
Key:
N/A: Not Applicable N/D: Not Determined N/E: Not Established Y: Yes N: No
302: CERCLA List of Hazardous Substances and Reportable Quantities (40 CFR 302.4).
355: SARA TITLE III / List of Extremely Hazardous Substances for Emergency Planning and Notification (40 CFR 355).
372: SARA TITLE III / List of Toxic Chemicals subject to Release Reporting (Community Right to Know) (40 CFR 372).
III - Physical Data
BOILING POINT (鈥? F): N/D SPECIFIC GRAVITY (WATER = 1): 0.787
VAPOR PRESSURE (mm Hg): N/D VOC CONTENT (% by weight): > 90.0
VAPOR DENSITY (AIR = 1): N/D EVAPORATION RATE (WATER = 1): >1.00
SOLUBILITY IN WATER: Insoluble pH: N/A
APPEARANCE AND ODOR: Clear, colorless liquid; characteristic solvent odor.
IV - Fire and Explosion Hazard Data
FLASH POINT (鈥? F): 103 (TEST METHOD): Closed cup
FLAMMABLE LIMITS IN AIR (VOLUME %) UPPER: N/E LOWER: N/E
EXTINGUISHING MEDIA: Foam, carbon dioxide, dry chemical.
SPECIAL FIRE FIGHTING PROCEDURES: Cool fire exposed containers with water fog. Firefighters should be equipped with full
protective gear including self-contained breathing apparatus.
UNUSUAL FIRE AND EXPLOSION HAZARD: May emit toxic fumes when heated. Vapors may travel considerable distance to a source
of ignition and flash back.
PRODUCT NAME: Snow Plow Coating PRODUCT CODE: 0385
V - Reactivity Data
STABILITY: Stable
INCOMPATIBILITY: Strong acids and oxidizing agents.
CONDITIONS TO AVOID: Heat, sparks or open flame.
HAZARDOUS DECOMPOSITION PRODUCTS: Thermal decomposition may produce oxides of carbon and sulfur oxide.
HAZARDOUS POLYMERIZATION: Will not occur.
CONDITIONS TO AVOID: None
VI - Health Hazard Data
ROUTES OF ENTRY INHALATION: X EYE CONTACT: X SKIN CONTACT: X INGESTION: X
INGREDIENTS THAT ARE CONSIDERED BY OSHA, NTP, IARC TO BE SUSPECTED HUMAN CARCINOGENS: None.
EFFECTS OF OVEREXPOSURE
IF IN EYES: Moderate irritation, redness, tearing, blurred vision.
IF ON SKIN: Irritation, with prolonged or repeated contact, dermatitis.
IF SWALLOWED: Gastrointestinal irritation, nausea, cramps, vomiting. May be harmful or fatal if swallowed. Small amounts of the liquid
aspirated into the respiratory system during ingestion, or from vomiting, may cause bronchiopneumonia or pulmonary edema.
IF INHALED: Irritation to upper respiratory tract, dizziness, weakness, headache, nausea, and unconsciousness.
EMERGENCY AND FIRST AID PROCEDURES
IF IN EYES: Flush eyes and under eyelids with plenty of cool water for at least 15 minutes. Obtain medical attention.
IF ON SKIN: Remove contaminated clothing and launder before re-use. Wash with soap and water. If irritation persists, obtain medical
attention.
IF SWALLOWED: Contact physician or poison control center immediately. Do not induce vomiting unless told to do so by a physician
or poison control center. Never give anything to an unconscious person.
IF INHALED: Remove person to fresh air. Perform artificial respiration if indicated. Obtain medical attention.
VII - Spill or Leak Protection
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED: Ventilate area and remove all sources of ignition. Soak up spilled
material with inert absorbent material and place in a properly marked closed container for proper disposal.
WASTE DISPOSAL METHOD: Consult local environmental authorities.
VIII - Special Protection Information
RESPIRATORY PROTECTION: Use with adequate ventilation. If recommended Exposure Limits are exceeded wear a NIOSH approved
respirator, following manufacturer鈥檚 recommendations.
VENTILATION LOCAL: Recommended MECHANICAL: Not required
PROTECTIVE GLOVES: Chemical resistant gloves.
EYE PROTECTION: Safety glasses and/or face shield.
OTHER PROTECTIVE EQUIPMENT: Eye wash station.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Store in a cool, dry place away from heat and open flame. Wash
thoroughly after handling. Keep container tightly closed when not in use.
OTHER PRECAUTIONS: Keep out of reach of children. Do not cut or weld on empty container as they may contain flammable residues.
IX - Transportation Information (ground transportation only)
DOT PROPER SHIPPING NAME: None
DOT CLASS: None DOT ID NUMBER: None DOT PACKING GROUP: None
The shipping information listed above applies only to non-bulk (< 119 gallons) containers of this product. This product may have more than one proper
shipping name depending on packaging, product properties, & mode of shipment. If any alteration of packaging, product, or mode of transportation is
further intended, different shipping names and labeling may apply.
REVISION DATE: October 31, 2003 Prepared by: PMR DATE OF ISSUE: October 31, 2003
This information contained herein is based on data considered accurate. However, no warranty is expressed or implied regarding the accuracy of this
data or the results to be obtained from the use thereof. Total Solutions assumes no responsibility for personal injury or property damage to the vendee,
users or third parties caused by the material such vendees or users assume all risks associated with the use of this material.
|