MATERIAL SAFETY DATA SHEET
Section 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
CHS Inc. Transportation Emergency (CHEMTREC): 1-800-424-9300
P.O. Box 64089 Technical Information: 1-651-355-8443
Mail station 525 MSDS Information: 1-651-355-8438
St. Paul, MN 55164-0089
PRODUCT NAME: COTTON PICKER SPINDLE KLEAN MSDS: 0169-CPSK 鈥? Rev. C (12/23/03)
COMMON NAME: Emusifiable Oil CHEMICAL NAME:
CHEMICAL FAMILY: Hydrocarbon CHEMICAL FORMULA: Mixture
Section 2 - COMPOSITION AND INFORMATION ON INGREDIENTS
INGREDIENTS PERCENTAGES PEL (OSHA) TLV (ACGIH) CAS #
(by weight)
Severely Hydrotreated
5 mg/m3 TWA (oil mist)
Lubricating Oil 85 - 95% N/D ppm TWA 64742-52-5
Surfactant 5 - 15%
(Traces of ethylene oxide may be present in the headspace of containers, see Section 3 for additional information)
(TWA) - Time Weighted Average is the employee's average airborne exposure in any 8 -hour work shift of a 40-hour work week which shall not be exceeded.
(STEL) - Short Term Exposure Limit is the employee's 15-minute time weighted average exposure which shall not be exceeded at any time during a work day unless another time
limit is specified.
Section 3 - HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
POTENTIAL HEALTH EFFECTS
ROUTES OF ENTRY: Eye Contact, Dermal, Inhalation, Ingestion.
ACUTE EFFECTS OF OVER EXPOSURE:
Eyes - May cause severe irritation to eye tissue from contact.
Skin - Prolonged contact with soaked clothing may cause irritation.
Inhalation - Vapors, mist or spray may cause chest pain, coughing, dizziness, headache, respiratory irritation or
unconsciousness.
Ingestion - May cause nausea, vomiting & diarrhea. Lethal dosage for 150 lb human is about 1 pint to 1 quart.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: May aggravate existing respiratory conditions.
CARCINOGENICITY: NTP: No IARC: No OSHA: No
If the product is handled according to the recommendations set forth in this MSDS, the presence of trace amounts of ethylene
oxide is not expected to result in any short or long-term hazard.
Page 1 of 4
Cotton Picker Spindle Klean,
Section 4 - FIRST AID MEASURES
EMERGENCY AND FIRST AID PROCEDURES:
Eye Contact - If material comes in contact with the eyes, immediately wash the eyes with large amounts of water for 15 minutes,
occasionally lifting the lower and upper lids. Get medical attention.
Skin Contact - If material comes in contact with the skin, promptly wash the contaminated skin with soap and water. If material
penetrates through the clothing, promptly remove the clothing, wash the skin with soap and water. Get medical attention if
symptoms persist.
Inhalation - If a person breathes in large amounts of this material, move the exposed person to fresh air at once. If breathing
has stopped, perform artificial respiration. Get medical attention if symptoms persist.
Ingestion - If material has been swallowed, do not induce vomiting. Get medical attention immediately.
Section 5 - FIRE - FIGHTING MEASURES
FLASH POINT: 300掳F (179掳C) AUTO IGNITION TEMP: N/A
FLAMMABLE LIMITS IN AIR LOWER UPPER
% BY VOLUME N/A N/A
EXTINGUISHING MEDIA: Carbon dioxide, dry chemical, foam and water fog or spray.
SPECIAL FIRE FIGHTING PROCEDURES: Cool containers with water, remove containers from the fire if possible.
UNUSUAL FIRE AND EXPLOSION HAZARDS: Heated containers may explode. Prevent runoff from entering sewer, could create a
fire and explosion hazard.
HAZARD RATINGS: NFPA 704: Health 3 Fire 1 Reactivity 0
Section 6 - ACCIDENTAL RELEASE MEASURES
STEPS TO TAKE IF MATERIAL IS RELEASED OR SPILLED: Prevent runoff from entering sewer or bodies of water, absorb with
inert material. Avoid contact with skin and eyes.
Section 7 - HANDLING AND STORAGE
HANDLING AND STORING: Remove all ignition sources.
Section 8 - EXPOSURE CONTROL - PERSONAL PROTECTION
ENGINEERING CONTROLS: Ventilate as needed to comply with exposure limits.
RESPIRATORY EQUIPMENT: Normally not required, when needed use only an approved NIOSH respirator.
EYE PROTECTION: Chemical splash goggles recommended to minimize exposure.
PROTECTIVE CLOTHING: Impervious clothing, boots and gloves recommended to minimize exposure.
OTHER (SAFETY SHOWERS, EYE WASH STATIONS, ETC.): Water should be available for flushing and washing.
Page 2 of 4
Cotton Picker Spindle Klean,
Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
APPEARANCE: Light straw colored liquid. ODOR: No unpleasant odor.
BOILING POINT: 500掳-1000掳F SPECIFIC GRAVITY (water=1): 0.90
VAPOR PRESSURE: < 1 mmHg @ 68掳F VAPOR DENSITY (air=1): Heavier
SOLUBLE IN WATER: Emusifiable EVAPORATION RATE (ether=1): Slower
pH: N/D
Section 10 - STABILITY AND REACTIVITY
STABILITY:
STABLE X
UNSTABLE
INCOMPATIBILITY:
CONDITIONS TO AVOID: Heat, flame, sparks and other ignition sources.
MATERIALS TO AVOID: Oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS: Smoke, carbon monoxide.
HAZARDOUS POLYMERIZATION: Will not occur.
Section 11 - TOXICOLOGY INFORMATION
Note: CHS has not conducted specific toxicity tests on this product.
Section 12 - ECOLOGICAL INFORMATION
Note: CHS has not conducted specific ecological tests on this product.
Section 13 - DISPOSAL CONSIDERATION
WASTE DISPOSAL PROCEDURES: Consult with Local, State and Federal environmental agencies on appropriate disposal.
Section 14 - TRANSPORTATION
DOT PROPER SHIPPING NAME: Not regulated by DOT. DOT HAZARD CLASS: N/A
DOT IDENTIFICATION NUMBER: N/A DOT EMER. RESPONSE GUIDE NO.: N/A
Section 15 - REGULATORY INFORMATION
This product does not contain toxic chemicals subject to the reporting requirements of SARA Section 313 of the Emergency Planning
and Community Right-To-Know Act of 1986 and of 40 CFR 372.
SARA SECTION 311-312 HAZARD CATEGORIES (40 CFR 370.2):
Page 3 of 4
Cotton Picker Spindle Klean,
FIRE: No SUDDEN RELEASE OF PRESSURE: No REACTIVE: No ACUTE: Yes CHRONIC: No
Section 16 - OTHER INFORMATION
Prepared By: John M. Burgess DATE: December 23, 2003
Updated by: Hue Lam Supersedes: October 25, 2001
Reason for Issue: Company Name Change
THE INFORMATION CONTAINED IN THIS MSDS RELATES ONLY TO THE SPECIFIC MATERIAL IDENTIFIED. IT DOES NOT COVER USE
OF THAT MATERIAL IN COMBINATION WITH ANY OTHER MATERIAL OR IN ANY PARTICULAR PROCESS. IN COMPLIANCE WITH 29
C.F.R. 1910.1200(g), CHS HAS PREPARED THIS MSDS IN SEGMENTS, WITH THE INTENT THAT THOSE SEGMENTS BE READ TOGETHER
AS A WHOLE WITHOUT TEXTUAL OMISSIONS OR ALTERATIONS. CHS BELIEVES THE INFORMATION CONTAINED HEREIN TO BE
ACCURATE, BUT MAKES NO REPRESENTATION, GUARANTEE, OR WARRANTY, EXPRESS OR IMPLIED, ABOUT THE ACCURACY,
RELIABILITY, OR COMPLETENESS OF THE INFORMATION OR ABOUT THE FITNESS OF CONTENTS HEREIN FOR EITHER GENERAL OR
PARTICULAR PURPOSES. PERSONS REVIEWING THIS MSDS SHOULD MAKE THEIR OWN DETERMINATION AS TO THE MATERIAL鈥橲
SUITABILITY AND COMPLETENESS FOR USE IN THEIR PARTICULAR APPLICATIONS.
Cenex庐 is a registered trademark of CHS Inc.
Page 4 of 4
|