MATERIAL SAFETY DATA SHEET
Product name: CPS Screen Cleaner Tx Page: 1/5
Print date: 2004-01-14
Last revised date: 2004-01-14
SDS-ID: US-D/2.0
1. IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND COMPANY/UNDERTAKING
Product name: CPS Screen Cleaner Tx
Application: Container size: 1, 5, 25, 210 l
To remove ink from screen printing mesh prior
to screen reclaim.
Supplier: Emergency phone no.:
Autotype Americas, Inc. 1-800-424-9300
2050 Hammond Drive
Schaumburg, IL 60173-3810
Tel: 1-847-303-5900
2. COMPOSITION/INFORMATION ON INGREDIENTS
The product contains: dialkylesters and organic solvents.
This product is covered by the OSHA Hazard Communication Rule 29, CFR 1910.1200
The following substances shall be indicated according to legislation:
Dipropylenglycolmethylether, CAS-No. 34590-94-8: 30-60%
2-(2-butoxyethoxy)ethanol, CAS-No. 112-34-5: 1-10%
Distillates (petroleum), hydrotreated light, CAS-No. 64742-47-8: 1-<10%
Propylenecarbonate, CAS-No. 108-32-7 1-<10%
3. HAZARDS IDENTIFICATION
Human health: May cause minor irritation on eye contact. Prolonged skin contact may cause redness and
irritation. In high concentrations, vapours may be irritating to the respiratory system.
This product contains no ingredient listed on the NTP, OSHA or IARC carcinogen lists.
4. FIRST-AID MEASURES
Inhalation: Move injured person into fresh air and keep person calm under observation. If uncomfortable:
Seek hospital and bring along these instructions.
Skin contact: Remove contaminated clothing immediately and wash skin with soap and water. In case of
rashes, wounds or other skin disorders: Seek medical attention and bring along these
instructions.
Eye contact: Immediately flush with plenty of water for up to 15 minutes. Remove any contact lenses and
open eyelids widely. If irritation persists: Seek medical attention and bring along these
instructions.
Ingestion: Immediately rinse mouth and drink plenty of water. Keep person under observation. If
uncomfortable: Seek hospital and bring along these instructions.
20402
Customer No:
-38978
Filing No:
MATERIAL SAFETY DATA SHEET
Product name: CPS Screen Cleaner Tx Page: 2/ 5
Print date: 2004.01.14
Last revised date: 2004-01-14
SDS-ID: US-D/2.0
5. FIRE-FIGHTING MEASURES
Extinguishing media: Extinguish with foam, carbon dioxide, dry powder or water fog. If possible, remove containers
exposed to heat or cool with water.
Specific hazards: During fire, health hazardous gases may be formed. The explosion limits and the flash point are
stated in point 9.
Protective equipment for Selection of respiratory protection for fire fighting: follow the general fire precautions indicated
fire-fighters: by the workplace.
6. ACCIDENTAL RELEASE MEASURES
Personal precautions: Avoid inhalation of vapours and contact with skin and eyes.
Environmental Avoid discharge into drains, water courses or onto the ground.
precautions:
Methods for Absorb spillage with absorbing material. Flush contaminated area with plenty of water. For
cleaning up: waste disposal, see point 13.
7. HANDLING AND STORAGE
Safe handling advice: Avoid inhalation of vapours and contact with skin and eyes.
Technical measures: Keep the workplace clean.
Technical precautions: Mechanical ventilation may be required.
Technical measures for Follow rules for flammable liquids.
safe storage:
Storage conditions: Store in closed original container at temperatures between 40掳F and 85掳F.
20402
Customer No:
-38978
Filing No:
MATERIAL SAFETY DATA SHEET
Product name: CPS Screen Cleaner Tx Page: 3/ 5
Print date: 2004.01.14
Last revised date: 2004-01-14
SDS-ID: US-D/2.0
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering measures: Provide adequate ventilation. Observe Occupational Exposure Limits and minimize the risk of
inhalation of vapours.
Chemical name: Exposure limits: Type: Notes: References:
Dipropylene glycol methyl 100ppm TWA Skin ACGIH
ether
Dipropylene glycol methyl 100ppm 600mg/m鲁 TWA Skin OSHA
ether
Jet fuels, as total hydrocarbon 200mg/m鲁 TWA Skin, A3 ACGIH
vapour
Jet fuels, as total hydrocarbon 200mg/m鲁 TWA Skin, A3 ACGIH
vapour
Respiratory equipment: In case of inadequate ventilation and work of brief duration, use suitable respiratory equipment.
Use respiratory equipment with gas filter, type A2. The use of filtering respirators should be
limited to max. 3 hours per day.
Hand protection: Risk of contact: Wear protective gloves. Be aware that the liquid may penetrate the gloves.
Frequent change is advisable. The product consists of substances for which it is not possible to
suggest a common suitable glove material. Therefore, a suitable type of gloves cannot be
recommended without knowing the actual usage of the product. The most suitable glove must
be chosen in collaboration with the supplier of gloves, who can inform about the breakthrough
time of the glove material.
Eye protection: Risk of splashes: Wear goggles/face shield.
Hygiene measures: Wash hands after handling.
Environmental exposure No information available.
controls:
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: clear liquid
Odour: characteristic
pH: not relevant
Boiling point: 290-465掳F
Flash point: 160掳F
Explosive properties: 1.1-14.0 vol%
Vapour pressure: 0.2 mmHg
Relative density: 0.969
Solubility: Soluble in: organic solvents
Other data: kinematic viscosity at 104掳F: <7 mm虏/s
Autoignition temperature: > 392掳F
Evaporation rate (BuAc=100): <1.
VOC (Volatile Organic Substances, ASTM D2369-01): 900 g/l
20402
Customer No:
-38978
Filing No:
MATERIAL SAFETY DATA SHEET
Product name: CPS Screen Cleaner Tx Page: 4/ 5
Print date: 2004.01.14
Last revised date: 2004-01-14
SDS-ID: US-D/2.0
10. STABILITY AND REACTIVITY
Stability: Stable under normal temperature conditions.
Conditions/ Heating.
materials to avoid:
Hazardous None in particular.
decomposition products:
11. TOXICOLOGICAL INFORMATION
Inhalation: In high concentrations, vapours may irritate throat and respiratory system and cause coughing.
Skin contact: Slightly irritating. Prolonged contact may cause dryness of the skin.
LD50 (skin, rabbit): 10 mL/kg (RTECS) for dipropylenglycolmethylether.
LD50 (skin, rabbit): 2700 mg/kg (RTECS) for 2-(2-butoxyethoxy)ethanol.
Eye contact: May irritate and cause redness and pain.
Ingestion: Irritating. May be absorbed in the body and cause dizziness, nausea and vomiting.
LD50 (oral, dog): 7500 mg/kg (RTECS) for dipropylenglycolmethylether.
LD50 (oral, rat): 5660 mg/kg (RTECS) for 2-(2-butoxyethoxy)ethanol.
Specific effects: Frequent inhalation of even small concentrations may cause irritability, fatigue and memory
failure and eventually permanent damage to the nervous system, including the brain.
This product contains no ingredient listed on the NTP, OSHA or IARC carcinogen lists.
12. ECOLOGICAL INFORMATION
Mobility: The product is insoluble in water. The product contains volatile organic compounds (VOC)
which will evaporate easily from all surfaces.
Degradability: The product is biodegradable, but it must not be discharged into drains without permission from
the authorities.
Ecotoxicity: Not stated.
Bioaccumulative No data available on bioaccumulation.
potential:
Other adverse effects: None known.
13. DISPOSAL CONSIDERATIONS
Dispose of waste and residues according to agreement with local authorities.
20402
Customer No:
-38978
Filing No:
MATERIAL SAFETY DATA SHEET
Product name: CPS Screen Cleaner Tx Page: 5/ 5
Print date: 2004.01.14
Last revised date: 2004-01-14
SDS-ID: US-D/2.0
14. TRANSPORT INFORMATION
The product is not covered by international regulation on the transport of dangerous goods (IMDG, IATA, ADR/RID).
15. REGULATORY INFORMATION
TSCA: All chemicals included in the product are TSCA listed.
2-(2-butoxyethoxy)ethanol, CAS-No. 112-34-5:
SARA Section 313: Form R reporting required for 1.0% de minimis concentration.
NFPA Rating: Health:1 Fire:2 Reactivity:0 Other:-
Specific provisions: State and local regulation may apply.
National regulation: The following lists have been checked:
Threshold Limit Values (2003), ACGIH, by the American Conference on Governmental Industrial
Hygienists.
The Code of Federal Regulation, Title 29, part 1910. Occupational Safety and Health Standards,
Air contaminants.
U.S. Department of health and human services: 2002 - Report on Carcinogens - 10th Ed.
International Agency for Research on Cancer (IARC): IARC Monographs on the Evaluation of
Carcinogenic Risks to Humans. Lyon: IARC, World Health Organization, 1972-2000.
The Code of Federal Regulation, Title 40, part 261.33. Identification and listning of hazardous
waste.
The Code of Federal Regulation. Title 40, part 355.50. Emergency Planning and Notification
The Code of Federal Regulation. Title 40, part 302.4. Designation, Reportable Quantities, and
Notification.
The Code of Federal Regulation. Title 40, part 68.130. Chemical Accident Prevention Provisions.
The Code of Federal Regulation. Title 40, part 372.65. Toxic Chemical Release Reporting:
Community Right to Know.
16. OTHER INFORMATION
The user must be instructed in the proper work procedure and be familiar with the contents of these instructions.
The following sections contain revisions or new statements: 3, 5, 7, 8, 9, 12.
The information on this data sheet represents our current data and is reliable provided that the product is used under the
prescribed conditions and in accordance with the application specified on the packaging and/or in the technical guidance
literature. Any other use of the product which involves using the product in combination with any other product or any
other process is the responsibility of the user.
Made by DANISH TOXICOLOGY CENTRE, Kogle All茅 2, DK-2970 H酶rsholm, Denmark. Telephone +45 45 76 20 55 Telefax +45 45 76 24 55
20402
Customer No:
-38978
Filing No:
|