MATERIAL SAFETY DATA SHEET
1. Product and Company Identification
Product Name VeriClean鈩? Solvent; MCC-DC1G, MCC-DC1P, MCC-DC1D
Mixture
CAS #
Circuit Board Cleaner
Product Use
Micro Care Corporation
Manufacturer
595 John Downey Drive
New Britain, CT 06051 US
Phone: 1-860-827-0626
Emergency Phone: 1-860-827-0626
LEGEND /
Health 1
3
HMIS/NFPA
Flammability 3
Severe 4
1 0
Serious 3
Physical Hazard 0
Moderate 2
Slight 1 Personal Protection
B
Minimal 0
2. Hazards Identification
DANGER
Emergency Overview
Flammable liquid - may release vapours that form flammable mixtures at or above the
flash point. Containers may explode when heated.
EYE AND SKIN IRRITANT.
Potential short term health effects
Routes of exposure Eye, Skin contact, Inhalation, Ingestion.
May cause irritation.
Eyes
May cause irritation.
Skin
May cause respiratory tract irritation.
Inhalation
May cause stomach distress, nausea or vomiting.
Ingestion
Eyes. Respiratory system. Skin.
Target organs
Prolonged or repeated exposure can cause drying, defatting and dermatitis.
Chronic effects
Symptoms may include redness, oedema, drying, defatting and cracking of the skin.
Signs and symptoms
Symptoms of overexposure may be headache, dizziness, tiredness, nausea and
vomiting.
3. Composition/Information on Ingredients
Ingredient(s) CAS # Percent
hexamethyldisiloxane 107-46-0 60 - 100
Propylene glycol monomethyl ether 107-98-2 7 - 13
4. First Aid Measures
First aid procedures
Eye contact Flush with cool water. Remove contact lenses, if applicable, and continue flushing.
Obtain medical attention if irritation persists.
Flush with cool water. Wash with soap and water. Obtain medical attention if irritation
Skin contact
persists.
If symptoms develop move victim to fresh air. If symptoms persist, obtain medical
Inhalation
attention.
Do not induce vomiting. Rinse mouth with water, then drink one or two glasses of water.
Ingestion
Obtain medical attention. Never give anything by mouth if victim is unconscious, or is
convulsing.
Symptoms may be delayed.
Notes to physician
#8823 Page 1 of 5 Issue date 28-Jun-2006
If you feel unwell, seek medical advice (show the label where possible). Ensure that
General advice
medical personnel are aware of the material(s) involved, and take precautions to protect
themselves. Show this safety data sheet to the doctor in attendance.
5. Fire-fighting Measures
Flammable by WHMIS criteria. Vapours may travel to a source of ignition and flash
Flammable properties
back. Containers may explode when heated.
Extinguishing media
Suitable extinguishing media Dry chemical. Carbon dioxide. Alcohol foam. Polymer foam.
Unsuitable extinguishing media Water.
Protection of firefighters
Not available
Specific hazards arising from
the chemical
Firefighters should wear full protective clothing including self contained breathing
Protective equipment for
apparatus.
firefighers
May include and are not limited to: Oxides of carbon. Silicon dioxide.
Hazardous combustion products
Explosion data
Not available
Sensitivity to mechanical
impact
Not available
Sensitivity to static discharge
6. Accidental Release Measures
Keep unnecessary personnel away. Do not touch or walk through spilled material. Do
Personal precautions
not touch damaged containers or spilled material unless wearing appropriate protective
clothing. Keep people away from and upwind of spill/leak.
Stop leak if you can do so without risk. Prevent entry into waterways, sewers,
Methods for containment
basements or confined areas.
Before attempting clean up, refer to hazard data given above. Small spills may be
Methods for cleaning up
absorbed with non-reactive absorbent and placed in suitable, covered, labelled
containers. Prevent large spills from entering sewers or waterways. Contact emergency
services and supplier for advice.
7. Handling and Storage
Use good industrial hygiene practices in handling this material.
Handling
Keep out of reach of children. Do not store at temperatures above 49掳C. Store in a
Storage
closed container away from incompatible materials.
8. Exposure Controls / Personal Protection
Exposure limits
Ingredient(s) Exposure limits
hexamethyldisiloxane ACGIH-TLV
Not established
Propylene glycol monomethyl ether ACGIH-TLV
TWA: 100 ppm
STEL: 150 ppm
General ventilation normally adequate.
Engineering controls
Personal protective equipment
Safety glasses
Eye/Face protection
Rubber gloves. Confirm with a reputable supplier first.
Hand protection
As required by employer code.
Skin and body protection
Not normally required if good ventilation is maintained and exposure guidelines are not
Respiratory protection
exceeded. Where exposure guideline levels may be exceeded, use an approved NIOSH
respirator.
General hygiene considerations Handle in accordance with good industrial hygiene and safety practice. When using do
not eat or drink. Wash hands before breaks and immediately after handling the product.
#8823 Page 2 of 5 Issue date 28-Jun-2006
9. Physical & Chemical Properties
Clear.
Appearance
Colourless
Colour
Liquid
Form
Slight ethereal
Odour
Not available
Odour threshold
Liquid
Physical state
Not available
pH
Not available
Freezing point
98 掳C (208.40 掳F)
Boiling point
-4 掳C (24.80 掳F) TCC
Flash point
Not available
Evaporation Rate
1.25
Flammability limits in air, lower, %
by volume
Flammability Limits in Air, Upper, % 18.6
by Volume
44.6 mmHg
Vapour pressure
Not available
Vapour density
0.77 (H2O = 1)
Specific gravity
Not available
Octanol/water coefficient
Insoluble
Solubility (H2O)
365 掳C (689.00 掳F)
Auto-ignition temperature
0.49 cPs
Viscosity
100 %
Percent volatile
10. Chemical Stability & Reactivity Information
Stable under recommended storage conditions.
Chemical stability
Avoid high temperatures. Do not mix with other chemicals.
Conditions to avoid
Caustics. Acids. Oxidizers.
Incompatible materials
Hazardous decomposition products May include and are not limited to: Oxides of carbon. Silicon dioxide.
Hazardous polymerisation does not occur.
Possibility of hazardous reactions
11. Toxicological Information
Component analysis - LC50
Ingredient(s) LC50
hexamethyldisiloxane 15956 ppm rat
Propylene glycol monomethyl ether 15000 ppm rat
Component analysis - Oral LD50
Ingredient(s) LD50
hexamethyldisiloxane Not available
Propylene glycol monomethyl ether 3739 mg/kg rat
Effects of acute exposure
May cause irritation.
Eye
May cause irritation.
Skin
May cause respiratory tract irritation.
Inhalation
May cause stomach distress, nausea or vomiting.
Ingestion
Non-hazardous by WHMIS criteria.
Sensitisation
Non-hazardous by WHMIS criteria.
Chronic effects
Non-hazardous by WHMIS criteria.
Carcinogenicity
Non-hazardous by WHMIS criteria.
Mutagenicity
Non-hazardous by WHMIS criteria.
Reproductive effects
#8823 Page 3 of 5 Issue date 28-Jun-2006
Non-hazardous by WHMIS criteria.
Teratogenicity
12. Ecological Information
Components of this product have been identified as having potential environmental
Ecotoxicity effects
concerns.
Not available
Environmental effects
Not available
Aquatic toxicity
Not available
Persistence and degradability
Not available
Bioaccumulation/accumulation
Not available
Partition coefficient
Not available
Mobility in environmental media
Not available
Chemical fate information
13. Disposal Considerations
Not available
Waste codes
Review federal, provincial, and local government requirements prior to disposal.
Disposal instructions
Not available
Waste from residues / unused
products
Not available
Contaminated packaging
14. Transport Information
Transportation of Dangerous Goods (TDG)
Basic shipping requirements:
FLAMMABLE LIQUID, N.O.S. (hexamethyldisiloxane)
Proper shipping name
3
Hazard class
1993
UN number
II
Packing group
Additional information:
16
Special provisions
15. Regulatory Information
This product has been classified in accordance with the hazard criteria of the Controlled
Canadian federal regulations
Products Regulations and the MSDS contains all the information required by the
Controlled Products Regulations.
Class B - Division 2 - Flammable Liquid, Class D - Division 2B
WHMIS classification
Controlled
WHMIS status
WHMIS labeling
Inventory Status
Country(s) or region Inventory Name On Inventory (Yes/No)*
Canada Domestic Substances List (DSL) Yes
Canada Non-Domestic Substances List (NDSL) No
#8823 Page 4 of 5 Issue date 28-Jun-2006
16. Other Information
Information contained herein was obtained from sources considered technically accurate
Disclaimer
and reliable. While every effort has been made to ensure full disclosure of product
hazards, in some cases data is not available and is so stated. Since conditions of actual
product use are beyond control of the supplier, it is assumed that users of this material
have been fully trained according to the requirements of all applicable legislation and
regulatory instruments. No warranty, expressed or implied, is made and supplier will not
be liable for any losses, injuries or consequential damages which may result from the
use of or reliance on any information contained in this document.
28-Jun-2006
Issue date
01-Jul-2006
Effective Date
01-Jul-2009
Expiry Date
Dell Tech Laboratories Ltd. (519) 858-5021
Prepared by
#8823 Page 5 of 5 Issue date 28-Jun-2006
|