Page 1 of 5
MATERIAL SAFETY DATA SHEET
__________________________________________________________________________________________
SECTION 1 IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE
COMPANY/UNDERTAKING
Fiske Brothers Refining Co. Emergency Telephone Number:
129 Lockwood St. 1-800-255-3924-CHEM-TEL (24 hour)
Newark, NJ 07105 Telephone Number for information:
1-973-589-9150
SUBSTANCE: LUBRIPLATE SYNCOOL
TRADE NAMES/SYNONYMS:
PRODUCT USE: Petroleum lubricating oil
CREATION DATE: 06/05/2008
REVISION DATE:
__________________________________________________________________________________________
SECTION 2 COMPOSITION/INFORMATION ON INGREDIENTS
COMPONENT: Oxirane, methyl-, polymer with oxirane, monobutyl ether
CAS NUMBER: 9038-95-3
EC NUMBER (EINECS): NA
PERCENTAGE: 95-100
COMPONENT: Phenothiazine
CAS NUMBER: 92-84-2
EC NUMBER (EINECS): 202-196-5
PERCENTAGE: 0-1
COMPONENT: Proprietary
CAS NUMBER: NA
EC NUMBER (EINECS): NA
PERCENTAGE: 0-1
NOTE: The IP 346 value of the mineral oil is less than 3%
__________________________________________________________________________________________
SECTION 3 HAZARDS IDENTIFICATION
POTENTIAL HEALTH EFFECTS:
INHALATION:
SHORT TERM EXPOSURE: Irritation
LONG TERM EXPOSURE: Lung damage
SKIN CONTACT:
SHORT TERM EXPOSURE: Irritation
LONG TERM EXPOSURE: Irritation, skin disorders
Page 2 of 5
EYE CONTACT:
SHORT TERM EXPOSURE: Irritation
LONG TERM EXPOSURE: No information available
INGESTION:
SHORT TERM EXPOSURE: Diarrhea, difficulty breathing
LONG TERM EXPOSURE: no information on significant adverse effects
__________________________________________________________________________________________
SECTION 4 FIRST AID MEASURES
INHALATION: Vapor pressure is very low and inhalation at room temperature is not a problem. If overcome
by vapor from hot product, immediately remove from exposure and call a physician.
SKIN CONTACT: Remove any contaminated clothing and wash with soap and warm water. If injected by
high pressure under skin, regardless of the appearance or its size, contact a physician IMMEDIATELY. Delay
may cause loss of affected part of body.
EYE CONTACT: Flush eyes with clear water for 15 minutes or until irritation subsides. If irritation persists,
consult a physician.
INGESTION: If ingested, call a physician immediately. Do not induce vomiting.
__________________________________________________________________________________________
SECTION 5 FIRE FIGHTING MEASURES
FIRE AND EXPLOSION HAZARDS: Slight fire hazard
EXTINGUISHING MEDIA: Foam, dry chemical, carbon dioxide or water spray (fog)
FIRE FIGHTING: Cool exposed containers with water. Use air-supplied breathing equipment for enclosed or
confined spaces.
HAZARDOUS COMBUSTION PRODUCTS:
Thermal decomposition products or combustion: oxides of carbon, oxides of sulphur
__________________________________________________________________________________________
SECTION 6 ACCIDENTAL RELEASE MEASURES
OCCUPATIONAL RELEASE: Recover liquid, wash remainder with suitable petroleum solvent or add
absorbent. Keep petroleum products out of sewers and watercourses. Advise authorities if product has entered
or may enter sewers and watercourses.
__________________________________________________________________________________________
SECTION 7 HANDLING AND STORAGE
STORAGE: Store and handle in accordance with all current regulations and standards. Keep container tightly
closed. Keep away from heat, sparks, and flame. See original container for storage recommendations. Keep
separated from incompatible substances.
Page 3 of 5
__________________________________________________________________________________________
SECTION 8 EXPOSURE CONTROLS/PERSONAL PROTECTION
EXPOSURE LIMITS:
White mineral oil:
MINERAL OIL MIST:
5 mg/m3 UK OES TWA
10mg/m3 UK OES STEL
VENTILATION: Provide local exhaust ventilation system. Ensure compliance with applicable exposure
limits.
EYE PROTECTION: Wear splash resistant safety goggles. Provide an emergency eye wash fountain and
quick drench shower in the immediate work area.
CLOTHING: Wear appropriate chemical resistant clothing.
GLOVES: Wear appropriate chemical resistant (nitrile) gloves.
RESPIRATOR: Consider the need for appropriate protective equipment, such as self-contained breathing
apparatus, adequate masks and filters.
__________________________________________________________________________________________
SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: liquid
APPEARANCE: transparent
COLOUR: colorless to yellowish
PHYSICAL FORM: oil
ODOUR: mild odor
BOILING POINT: 310 C
FREEZING POINT: Not available
FLASH POINT: 321 C (COC)
LOWER FLAMMABLE LIMIT: Not determined
UPPER FLAMMABLE LIMIT: Not determined
AUTO IGNITION: 400 C (COC)
VAPOUR PRESSURE: Not available
VAPOR DENSITY (air=1): Not available
SPECIFIC GRAVITY (water=1): 0.984
DENSITY: not available
WATER SOLUBILITY: soluble
pH: 5.5 鈥? 8.0
VOLATILITY: <1% volatiles
ODOUR THRESHOLD: not available
EVAPORATION RATE (Butyl acetate=1): <0.01
VISCOSITY: 46 mm2/s @ 40 C
COEFFICIENT OF WATER/OIL DISTRIBUTION: not available
Page 4 of 5
__________________________________________________________________________________________
SECTION 10 STABILITY AND REACTIVITY
REACTIVITY: Stable at normal temperatures and pressures
CONDITIONS TO AVOID: Keep containers closed when not in use. Do not handle or store near heat,
sparks, flame, or strong oxidants.
INCOMPATIBLES: Avoid contact with strong acids or bases.
HAZARDOUS DECOMPOSITION:
Thermal decomposition products or combustion: oxides of carbon
POLYMERISATION: Will not polymerise.
__________________________________________________________________________________________
SECTION 11 TOXICOLOGICAL INFORMATION
LUBRIPLATE Syncool:
TOXICITY DATA:
Greater than 2,000 mg/kg LD50 oral-rat
____________________________________________________________________________________________________________
SECTION 12 ECOLOGICAL INFORMATION
Biodegradation:
Test method: OECD 301F; ISO 9408;92/69/EEC, C.4-D
Method of analysis: BOD of the ThOD
Degree of elimination: >70%
Evaluation: Readily biodegradable (according to OECD criteria). The product is
biodegradable.
__________________________________________________________________________________________
SECTION 13 DISPOSAL CONSIDERATIONS
Dispose in accordance with all applicable regulations
__________________________________________________________________________________________
SECTION 14 TRANSPORT INFORMATION
LAND TRANSPORT ADR: No classification assigned.
LAND TRANSPORT RID: No classification assigned.
AIR TRANSPORT IATA: No classification assigned.
AIR TRANSPORT ICAO: No classification assigned.
MARITIME TRANSPORT IMDG: No classification assigned.
Page 5 of 5
__________________________________________________________________________________________
SECTION 15 REGULATORY INFORMATION
EUROPEAN REGULATIONS:
EC CLASSIFICATION (CALCULATED): Not classified as dangerous.
__________________________________________________________________________________________
SECTION 16 OTHER INFORMATION
The above information is furnished without warranty, expressed or implied, except that it is accurate to
the best knowledge of Fiske Brothers Refining Company. The data on these sheets relates only to the
specific material designated herein. Fiske Brothers Refining Company assumes no legal responsibility
for use or reliance upon this data.
|