铮?
LUBRIPLATE
MATERIAL SAFETY DATA SHEET
Section 1
PRODUCT NAME OR NUMBER FORMULA
LUBRIPLATE White Lithium Spray Lube "A" (Aerosol) Lithium Grease, Solvent and Propellant
GENERIC/CHEMICAL NAME: NSF Registration No:
Petroleum Lubricating Grease N/A
Manufacturer's Name Emergency Telephone Number
Fiske Brothers Refining Co., d/b/a LUBRIPLATE Lubricants Co. 1-800-255-3924 - CHEM-TEL (24 hour)
Address Telephone Number for Information
1500 Oakdale Ave., Toledo, Ohio 43605 - 129 Lockwood St., Newark, NJ 07105 419-691-2491 - Toledo Office
Section 2 鈥? Composition/Information on Ingredients
Ingredients with CAS #鈥檚 CAS # Percentage
Mineral Oil 64742-52-5 30 - 35%
Lithium Thickener 4485-12-5 0 - 3%
Zinc Oxide 1314-13-2 0 - 4%
Heptane 142-82-5 20 - 25%
LPG (Propellant) 68476-86-8 15 - 20%
Light Distillate 64742-47-8 15 - 20%
Hazardous Material Identification System (HMIS): Health - 1, Flammability - 4, Reactivity 鈥? 0
Not a Controlled Product under (WHMIS) - Canada Special Protection: See Section 9
Section 3 - Health Hazard Data
LPG - 1000 mg/m3, TLV for oil mist = 5mg/m3, PEL for Light Distillate 鈥? 500 ppm
Threshold Limit Value PEL for Heptane - 400 ppm,
Effects of Overexposure Inhalation is the most likely method of exposure. Minimal effects are expected at levels below the TLV of components.
Dizziness, drowsiness, coughing, nasal or throat irritations at higher levels. LPG may act as a simple asphyxiant without other significant physiologic
effects if the oxygen content is low. It is reported that overexposure can cause liver abnormalities, kidney, lung and spleen damage in test animals.
Carcinogenicity: NTP? No IARC Monographs? No OSHA Regulated? No
Section 4 - Emergency and First Aid Procedures
EYE CONTACT: Flush with clear water for 15 minutes or until irritation subsides. If irritation persists, consult a physician.
SKIN CONTACT: Remove any contaminated clothing and wash with soap and warm water.
INHALATION: Remove to fresh air. If breathing has stopped, administer artificial respiration. Get medical help immediately.
INGESTION: If ingested, call a physician immediately. Do not induce vomiting.
Section 5 - Fire and Explosion Hazard Data
Flash Point (Method Used) Propellant <0掳F Flammable Limits - N.D. LEL UEL
Extinguishing Media Foam, Dry Chemical, Carbon Dioxide.
Special Fire Fighting Procedures Keep containers cool. Use air-supplied breathing equipment for enclosed or confined spaces.
Use shielding to protect personnel against bursting containers.
Unusual Fire and Explosion Hazards Do not spray near open flame. At elevated temperatures (over 130掳F.), aerosol containers may
vent, burst, or rupture.
PRODUCT NAME OR NUMBER - LUBRIPLATE White Lithium Spray Lube "A" (Aerosol)
Section 6 - Physical/Chemical Characteristics
Boiling Point (Aerosol) N/A Specific Gravity (H 2O = 1) 0.94
Of Product
Vapor Pressure (mm Hg.) Aerosol @ 130掳F. - 115 psig Melting Point Spray
Vapor Density (AIR = 1) >1 Evaporation Rate Faster
(Butyl Acetate = 1)
Solubility in Water Insoluble
Appearance and Odor White mist with odor of solvent from aerosol can.
Section 7 - Reactivity Data
Stability Unstable Conditions to Avoid Avoid spraying into open flame or onto
Stable X red-hot surfaces.
Incompatibility (Materials to Avoid) Strong oxidizers.
Hazardous Decomposition or Byproducts May form Carbon Monoxide if combustion is not complete.
Hazardous Polymerization May Occur Conditions to Avoid N/A
Will Not Occur X
Section 8 - Spill or Leak Procedures
Steps to be taken in case material is released or spilled
Remove sources of ignition, ventilate area. Use appropriate safety equipment to enter area. Allow time for vapors to be below their TLV.
Add oil absorbent and clean area. Keep petroleum products out of sewers and watercourses.
Waste disposal method
Do not puncture or incinerate containers. Give empty, leaking or full containers to a disposal service equipped to safely handle and dispose
of pressurized containers.
SARA/TITLE III, Section 313 Status - Zinc Compounds - < 4%
Section 9 - Special Protection Information
Respiratory Protection (Specify type) Need approved organic vapor mask if TLV is exceeded.
Ventilation Local Exhaust Use for fumes & to maintain below TLV value. Special N/A
Mechanical (General) Other N/A
Protective Gloves Use oil-impervious gloves. Eye Protection Use goggles or face shield.
Other Protective Equipment Use oil-resistant apron, if needed.
Section 10 - Special Precautions
Precautions to be taken in handling and storing
Store in cool, dry area out of direct sunlight. Do not puncture or incinerate, or heat full or empty containers above 130掳F.
Other Precautions
Please read and follow the directions on the product label. Keep away from children.
The above information is furnished without warranty, expressed or implied, except that it is accurate to the best knowledge of Fiske
Brothers Refining Co., d/b/a LUBRIPLATE Lubricants Co. The data on these sheets relates only to the specific material designated
herein. Fiske Brothers Refining Co., d/b/a LUBRIPLATE Lubricants Co. assumes no legal responsibility for use or reliance upon
this data.
Date Prepared: October 9, 2007 Prepared by: James R. Kontak
|