Material Safety Data Sheet
Revision Date: 04/26/2006 Issue date: 04/26/2006
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product name: LOCQUIC(R) PRIMER N 7649 Item No. : 21348
Product type: Accelerator Region: United States
Company address: Contact Information:
Henkel Corporation Telephone: 860.571.5100
1001 Trout Brook Crossing Emergency telephone: 860.571.5100
Rocky Hill, Connecticut 06067 Internet: www.loctite.com
2. COMPOSITION/INFORMATION ON INGREDIENTS
Hazardous components % ACGIH TLV OSHA PEL OTHER
Acetone 60-100 500 ppm TWA 1000 ppm TWA None
67-64-1 750 ppm STEL 2400 mg/m鲁 TWA
Isobutane 10-30 1000 ppm TWA listed None None
75-28-5 under Aliphatic
hydrocarbon gases alkane
C1-C4
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
HMIS:
Physical state: Liquid HEALTH: 2*
Color: Green FLAMMABILITY: 3
Odor: Acetone PHYSICAL HAZARD: 0
Personal Protection: See Section 8
DANGER: FLAMMABLE LIQUID AND VAPOR.
CAUSES EYE AND SKIN IRRITATION.
MAY CAUSE RESPIRATORY TRACT IRRITATION.
Relevant routes of exposure: Inhalation, Skin contact, Eye contact, Ingestion
Potential Health Effects
Inhalation: Harmful if inhaled. Vapors and mists will irritate nose and throat and possibly eyes. May cause
respiratory tract irritation. Headache, dizziness, nausea, and loss of coordination are indications of
excessive exposure to vapors or spray mists.
Skin contact: May cause skin irritation. Solvent action can dry and defat the skin, causing the skin to crack, leading
to dermatitis.
Eye contact: Vapors may irritate eyes. Contact with eyes will cause irritation.
Ingestion: Harmful if swallowed.
Existing conditions aggravated by Eye, skin, and respiratory disorders.
exposure:
See Section 11 for additional toxicological information.
Item No. : 21348 Product name: LOCQUIC(R) PRIMER N 7649
1 of 5
4. FIRST AID MEASURES
Inhalation: Remove to fresh air. If discomfort persists seek medical attention.
Skin contact: Wash with soap and water.
Eye contact: Flush with copious amounts of water, preferably, lukewarm water for at least 15 minutes, holding
eyelids open all the time.
Ingestion: If conscious, drink plenty of water. Do not induce vomiting. Keep individual calm. Obtain medical
attention.
5. FIRE-FIGHTING MEASURES
Flash point: -20掳C (-4掳F) (estimated)
Autoignition temperature: Not available
Flammable/Explosive limits-lower %: Not available
Flammable/Explosive limits-upper %: Not available
Extinguishing media: Foam, dry chemical or carbon dioxide.
Special fire fighting procedures: Wear self-contained breathing apparatus and full protective clothing, such as turn-out gear.
Unusual fire or explosion hazards: Vapors may accumulate in low or confined areas, travel considerable distance to source of ignition,
and flash back.
Hazardous combustion products: Oxides of carbon. Oxides of nitrogen. Irritating organic vapors.
6. ACCIDENTAL RELEASE MEASURES
Environmental precautions: Prevent product from entering drains or open waters.
Clean-up methods: Remove all ignition sources. Ensure adequate ventilation. Soak up with inert absorbent. Store in a
closed container until ready for disposal.
7. HANDLING AND STORAGE
Handling: Avoid contact with eyes, skin and clothing. Avoid breathing vapor and mist. Wash thoroughly after
handling. During use and until all vapors are gone: Keep area ventilated - do not smoke; extinguish all
flames, pilot lights, and heaters; turn off stoves, electrical tools and appliances, and any other sources
of ignition.
Storage: Store away from heat, sparks, flames, or other sources of ignition. For safe storage, store at or below
49掳C (120掳F).
Incompatible products: Refer to Section 10.
For information on product shelf life contact Henkel Customer Service at (800) 243-4874.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering controls: Use local ventilation if general ventilation is insufficient to maintain vapor concentration below
established exposure limits.
Respiratory protection: Use NIOSH approved respirator if there is potential to exceed exposure limit(s).
Item No. : 21348 Product name: LOCQUIC(R) PRIMER N 7649
2 of 5
Skin protection: Chemical resistant, impermeable gloves. Neoprene, Butyl-rubber, or nitrile-rubber gloves.
Eye/face protection: Safety goggles or safety glasses with side shields.
See Section 2 for exposure limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state: Liquid
Color: Green
Odor: Acetone
Vapor pressure: 172 mmHg at 20 潞C (68 掳F)
pH: Not applicable
Boiling point/range: 56掳C (133掳F) (Base only)
Melting point/range: Not available
Specific gravity: 0.7936
Vapor density: 2.0
Evaporation rate: 1.9 (Ether = 1)
Solubility in water: Completely miscible
Partition coefficient (n-octanol/water): Not available
VOC content: 1.48%; 11.7 grams/liter (EPA Method 24)
10. STABILITY AND REACTIVITY
Stability: Stable.
Hazardous polymerization: Will not occur.
Hazardous decomposition products: Oxides of carbon. Oxides of nitrogen. Irritating organic vapors.
Incompatability: Strong oxidizers. Acids.
Conditions to avoid: See "Handling and Storage" (Section 7) and "Incompatabilty" (Section 10).
11. TOXICOLOGICAL INFORMATION
Carcinogen Status
Hazardous components NTP Carcinogen IARC Carcinogen OSHA Carcinogen
Acetone No No No
67-64-1
Isobutane No No No
75-28-5
Literature Referenced Target Organ & Other Health Effects
Hazardous components Health Effects/Target Organs
Acetone Blood, Central nervous system, Irritant, Reproductive
67-64-1
Isobutane Cardiac, Central nervous system, Lung
75-28-5
12. ECOLOGICAL INFORMATION
Ecological information: Not available
Item No. : 21348 Product name: LOCQUIC(R) PRIMER N 7649
3 of 5
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal: Dispose of according to Federal, State and local governmental regulations.
EPA hazardous waste number: D001: Ignitable.
14. TRANSPORT INFORMATION
U.S. Department of Transportation Ground (49 CFR):
Proper shipping name: Aerosols, flammable
Hazard class or division: 2.1
Identification number: UN 1950
Packing group: None
Exceptions: Consumer Commodity ORM-D (Not more than 1 Liter)
International Air Transportation (ICAO/IATA):
Proper shipping name: Aerosols, flammable
Hazard class or division: 2.1
Identification number: UN1950
Packing group: None
Exceptions: May Qualify as Consumer Commodity ID8000 (Not more than 30 kg)
WaterTransportation (IMO/IMDG):
Proper shipping name: Aerosols, flammable
Hazard class or division: 2.1
Identification number: UN1950
Packing group: None
Exceptions: Limited quantity (Not more than 1 L)
Marine pollutant: None
15. REGULATORY INFORMATION
United States Regulatory Information
TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory.
TSCA 12 (b) Export Notification: None.
CERCLA/SARA Section 302 EHS: None.
CERCLA/SARA Section 311/312: Immediate Health Hazard, Delayed Health Hazard, Fire
CERCLA/SARA 313: None above reporting de minimus.
California Proposition 65: This product contains a chemical known to the State of California to cause cancer and birth defects or
other reproductive harm.
Canada Regulatory Information
CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Domestic Substances List.
WHMIS hazard class: A, B.5, D.2.A, D.2.B
Item No. : 21348 Product name: LOCQUIC(R) PRIMER N 7649
4 of 5
16. OTHER INFORMATION
This material safety data sheet contains changes from the previous version in sections: 2, 11
Prepared by: Kyra Kozak Woods, Product Safety and Regulatory Affairs Specialist
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation
does not assume responsibility for any results obtained by persons over whose methods Henkel Corporation has no control. It is the
user's responsibility to determine the suitability of Henkel's products or any production methods mentioned herein for a particular
purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be
involved in the handling and use of any of Henkel Corporation's products. In light of the foregoing, Henkel Corporation specifically
disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale
or use of Henkel Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of
any kind, including lost profits.
Item No. : 21348 Product name: LOCQUIC(R) PRIMER N 7649
5 of 5
|