Product name: Dielectric Grease Item No. : 30536
Product type: Lubricant Region: United States
Company address: Contact Information:
Henkel Corporation Telephone: 860.571.5100
1001 Trout Brook Crossing Emergency telephone: 860.571.5100
Rocky Hill, Connecticut 06067 Internet: www.loctite.com
2. COMPOSITION/INFORMATION ON INGREDIENTS
Non hazardous components
This material is not classified as hazardous under The OSHA Hazardous Communication Standard. This material is not WHMIS controlled.
Important NOT EXPECTED TO PRESENT ANY UNUSUAL HAZARDS IN NORMAL USE.
Relevant routes of exposure: Ingestion
Potential Health Effects
Inhalation: Mist or spray may cause respiratory tract irritation and delayed onset pulmonary edema. When heated
to temperatures exceeding 300掳 F (150掳 C) in the presence of air, silicones may form formaldehyde
vapors. Formaldehyde is a potential cancer hazard and a known skin and respiratory sensitizer.
Vapors irritate the eyes, nose and throat. Safe handling conditions may be maintained by keeping
formaldehyde vapor concentrations below the OSHA permissible limt.
Skin contact: Not expected to be a hazard.
Eye contact: Not expected to cause injury. Eye contact may cause mild irritation.
Ingestion: Not expected under normal conditions of use.
Existing conditions aggravated by None known
exposure:
See Section 11 for additional toxicological information.
Item No. : 30536 Product name: Dielectric Grease
1 of 4
4. FIRST AID MEASURES
Inhalation: Remove to fresh air. If symptoms develop and persist, get medical attention. If breathing is difficult,
give oxygen. Get medical attention immediately.
Skin contact: Wash with soap and water. Get medical attention if symptoms develop and persist.
Eye contact: Check for and remove any contact lenses. Immediately flush eyes with plenty of water for at least 15
minutes. Get medical attention.
Ingestion: Do not induce vomiting. Obtain medical attention.
5. FIRE-FIGHTING MEASURES
Flash point: Greater than 260潞C (500潞F) Cleveland open cup
Autoignition temperature: Not determined
Flammable/Explosive limits-lower %: Not available
Flammable/Explosive limits-upper %: Not available
Extinguishing media: Water spray (fog), foam, dry chemical or carbon dioxide.
Special fire fighting procedures: Fire fighters should wear positive pressure self-contained breathing apparatus (SCBA). Water should
be used to cool closed containers to prevent pressure build-up and possible autoignition or explosion
when exposed to extreme heat.
Unusual fire or explosion hazards: None
Hazardous combustion products: Oxides of carbon.
6. ACCIDENTAL RELEASE MEASURES
Environmental precautions: Ventilate area. Prevent product from entering drains or open waters.
Clean-up methods: Scrape up spilled material and place in a closed container for disposal.
7. HANDLING AND STORAGE
Handling: Use only with adequate ventilation. Avoid contact with eyes, skin and clothing.
Storage: Keep in a cool, well ventilated area. Keep away from heat, sparks and flame.
Incompatible products: Not available
For information on product shelf life contact Henkel Customer Service at (800) 243-4874.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Engineering controls: Use local ventilation if general ventilation is insufficient to maintain vapor concentration below
established exposure limits.
Respiratory protection: Use NIOSH approved respirator if there is potential to exceed exposure limit(s). Observe OSHA
regulations for respiratory use (29 CFR 1910.134).
Skin protection: Chemical resistant, impermeable gloves.
Eye/face protection: Chemical splash goggles or safety glasses with side shields.
Item No. : 30536 Product name: Dielectric Grease
2 of 4
See Section 2 for exposure limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state: Liquid
Color: Clear
Odor: Mild
Vapor pressure: <5 mmHg at 25 潞C (77 掳F)
pH: Not applicable
Boiling point/range: Greater than 148掳C (298掳F)
Melting point/range: Not available
Specific gravity: 0.86
Vapor density: Heavier than air
Evaporation rate: Not available
Solubility in water: Not available
Partition coefficient (n-octanol/water): More soluble in octanol
VOC content: Zero
10. STABILITY AND REACTIVITY
Stability: Stable.
Hazardous polymerization: Will not occur.
Hazardous decomposition products: Oxides of carbon. Formaldehyde.
Incompatability: Strong oxidizing agents. Strong acids and strong bases.
Conditions to avoid: Heat, flames and sparks.
11. TOXICOLOGICAL INFORMATION
Carcinogen Status
Literature Referenced Target Organ & Other Health Effects
12. ECOLOGICAL INFORMATION
Ecological information: Not available
13. DISPOSAL CONSIDERATIONS
Information provided is for unused product only.
Recommended method of disposal: Dispose of according to Federal, State and local governmental regulations.
EPA hazardous waste number: Not a RCRA hazardous waste.
14. TRANSPORT INFORMATION
U.S. Department of Transportation Ground (49 CFR):
Proper shipping name: Unrestricted
Hazard class or division: None
Identification number: None
Packing group: None
International Air Transportation (ICAO/IATA):
Proper shipping name: Unrestricted
Hazard class or division: None
Identification number: None
Item No. : 30536 Product name: Dielectric Grease
3 of 4
Packing group: None
WaterTransportation (IMO/IMDG):
Proper shipping name: Unrestricted
Hazard class or division: None
Identification number: None
Packing group: None
Marine pollutant: None
15. REGULATORY INFORMATION
United States Regulatory Information
TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory.
TSCA 12 (b) Export Notification: None.
CERCLA/SARA Section 302 EHS: None.
CERCLA/SARA Section 311/312: None.
CERCLA/SARA 313: This product contains the following toxic chemicals subject to the reporting requirements of section 313
of the Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372). None.
California Proposition 65: This product contains a chemical known to the State of California to cause cancer and birth defects or
other reproductive harm.
Canada Regulatory Information
CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Domestic Substances List.
WHMIS hazard class: Non-controlled
16. OTHER INFORMATION
This material safety data sheet contains changes from the previous version in sections: 9
DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation
does not assume responsibility for any results obtained by persons over whose methods Henkel Corporation has no control. It is the
user's responsibility to determine the suitability of Henkel's products or any production methods mentioned herein for a particular
purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be
involved in the handling and use of any of Henkel Corporation's products. In light of the foregoing, Henkel Corporation specifically
disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale
or use of Henkel Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of
any kind, including lost profits.