MATERIAL SAFETY DATA SHEET
COMPLIES WITH OSHA鈥檚 HAZARD COMMUNICATION STANDARD (29 CFT 1910.1200)
SECTION I 鈥? PRODUCT IDENTIFICATION
Product Name: Bowl Cleaner Date Prepaid: 04/12/01 HMIS Rating
Product Number: #36 Emergency Phone: 800-255-3924 Minimal: 0 Sight: 1
Product Type: Liquid Bowl Cleaner Moderate: 2 Serious: 3
Supplier鈥檚 Name: INSCO Extreme: 4
Supplier鈥檚 Address: PO Box 2065/Wilson, NC 27893 HEALTH: 0/FIRE: 2/
REACTIVITY: 0
SECTION II 鈥? HAZARDOUS INGREDIENTS
Chemical Name CAS# OSHA PEL TLV (source)
Hydrochloric Acid* 7647-01-0 N/L 5ppm
Tergitol Nonionic
Surfactant NP10 26027-38-3 N/E N/E
Lytron E305 N/A mixture 50ppm 50ppm
*Contents are reportable under SARA Title III.
SECTION III 鈥? PHYSICAL DATA
Boiling Point: 80 degrees C Evaporation Rate (Butyl Acetate = 1): N/A
Ph: less than 1 Melting Point: N/A
Solubility in Water: Complete Vapor Density (Air = 1): N/E
Appearance/Odor: Milky white color with pungent, sharp odor. Specific Gravity (H2O = 1): 1.130
SECTION IV 鈥? FIRE AND EXPLOSION DATA
Flash Point: None Flammability Limits: None
Extinguishing Media: No fire or explosion hazard exist directly from HCL. Firefighting equipment suitable for other hazards present.
Unusual Fire/Explosion Hazards: Latent fire/explosion hazard when HCL contains metal due to generation of hydrogen.
Special Fire Fighting Procedures: Should the area of the fire contain HCL vapors, firefighter should be protected by full cover plastic, rubber protective clothes and
self-contained breathing apparatus. Latent fire/explosion hazard when HCL contains metal due to generation of hydrogen.
SECTION V 鈥? REACTIVITY DATA
Stability: Material stable Hazardous Polymerization: N/A
Incompatibility: Keep away from oxidizing agents. Hazardous Decomposition Products: None
SECTION VI 鈥? STORAGE AND HANDLING
Precautions to be Taken in Handling/Storage: Avoid contact with skin and eyes. When storing make sure containers are not too full. Allow room for expansion.
SECTION VII 鈥? HEALTH AND FIRST AID
Eyes: Wash freely with water for 15 minutes. Get prompt medical attention.
Skin: Wipe off the acid gently. Immediately flood the surface with water (using soap freely). Cover with water, moist magnesia or baking soda.
Ingestion: Call physician immediately. Drink a teaspoonful or more of magnesia, chalk or small pieces of soap (softened) in milk or raw egg whites.
Inhalation: If bothersome, remove to fresh air.
SECTION VIII 鈥? SPECIAL PROTECTION DATA
Protective Gloves: Recommended Ventilation: Mechanical
Eye Protection: Recommended Other Protective Clothing/Equipment: Rubber or protective
Respiratory Proctection: N/A suits (apron) and rubber safety shoes.
SECTION IX 鈥? SPILL OR LEAK PROTECTION
Steps to be Taken in Case of Spill or Leak: Flush down sewer with large amounts of water when spilled. A fog nozzle attached to water supply from a fire hose will
absorb the gases or vapors in immediate area. Neutralize with soda ash.
Waste Disposal Method: Dispose of in accordance with Federal, State and Local requirements.
N/A = NON APPLICABLE N/E = NOT ESTABLISHED N/D = NOT DETERMINED N/L = NOT LISTED
NOTICE: The information contained on this Material Safety Data Sheet is considered accurate as of the date of publication. It is not necessarily all inclusive nor fully
adequate in every circumstance. The suggestions should not be confused with, nor followed in violation of applicable laws, regulations, rules or insurance
requirements. No warranty (expressed or implied) of merchantability, fitness, accuracy of data, or the results to be obtained from the use thereof is made. The vendor
assumes no responsibility for injury or damages resulting from the inappropriate use of this product.
|